Skip to main content
SpringerLink
Log in

Investigation of Electron Transport Across Vertically Grown CNTs Using Combination of Proximity Field Emission Microscopy and Scanning Probe Image Processing Techniques

  • Published:
Electronic Materials Letters Aims and scope Submit manuscript

Abstract

Field emission from nanostructured films is known to be dominated by only small number of localized spots which varies with the voltage, electric field and heat treatment. It is important to develop processing methods which will produce stable and uniform emitting sites. In this paper we report a novel approach which involves analysis of Proximity Field Emission Microscopic (PFEM) images using Scanning Probe Image Processing technique. Vertically aligned carbon nanotube emitters have been deposited on tungsten foil by water assisted chemical vapor deposition. Prior to the field electron emission studies, these films were characterized by scanning electron microscopy, transmission electron microscopy, and Atomic Force Microscopy (AFM). AFM images of the samples show bristle like structure, the size of bristle varying from 80 to 300 nm. The topography images were found to exhibit strong correlation with current images. Current–Voltage (I–V) measurements both from Scanning Tunneling Microscopy and Conducting-AFM mode suggest that electron transport mechanism in imaging vertically grown CNTs is ballistic rather than usual tunneling or field emission with a junction resistance of ~10 kΩ. It was found that I–V curves for field emission mode in PFEM geometry vary initially with number of I–V cycles until reproducible I–V curves are obtained. Even for reasonably stable I–V behavior the number of spots was found to increase with the voltage leading to a modified Fowler–Nordheim (F–N) behavior. A plot of ln(I/V3) versus 1/V was found to be linear. Current versus time data exhibit large fluctuation with the power spectral density obeying 1/f2 law. It is suggested that an analogue of F–N equation of the form ln(I/Vα) versus 1/V may be used for the analysis of field emission data, where α may depend on nanostructure configuration and can be determined from the dependence of emitting spots on the voltage.

Graphical Abstract

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7

Similar content being viewed by others

References

  1. de Heer, W.A., Chatelain, A., Ugarte, D.: A carbon nanotube field-emission electron source. Science 270, 1179 (1995)

    Article  Google Scholar 

  2. Saito, Y., Hamaguchi, K., Hata, K., Uchida, K., Tasaka, Y., Ikazaki, F., Yumura, M., Kasuya, A., Nishina, Y.: Conical beams from open nanotubes. Nature 389, 554 (1997)

    Article  Google Scholar 

  3. Chhowalla, M., Ducati, C., Rupesinghe, N.L., Teo, K.B.K., Amaratunga, G.A.J.: Field emission from short and stubby vertically aligned carbon nanotubes. Appl. Phys. Lett. 79, 2079 (2001)

    Article  Google Scholar 

  4. Choi, W.B., Chung, D.S., Kang, J.H., Kim, H.Y., Jin, Y.W., Han, I.T., Lee, Y.H., Lee, J.E., Lee, N.S., Park, G.S., Kim, J.M.: Fully sealed, high-brightness carbon-nanotube field-emission display. Appl. Phys. Lett. 75, 3129 (1999)

    Article  Google Scholar 

  5. Lee, N.S., Chung, D.S., Han, I.T., Kang, J.H., Choi, Y.S., Kim, H.Y., Park, S.H., Jin, Y.W., Yi, W.K., Yun, M.J., Jung, J.E., Lee, C.J., You, J.H., You, S.H., Jo, S.H., Lee, C.G., Kim, J.M.: Application of carbon nanotubes to field emission displays. Diam. Relat. Mater. 10, 265–270 (2001)

    Article  Google Scholar 

  6. Yue, G.Z., Qiu, Q., Gao, B., Cheng, Y., Zhang, J., Shimoda, H., Chang, S., Lu, J.P., Zhou, O.: Generation of continuous and pulsed diagnostic imaging X-ray radiation using a carbon-nanotube-based field-emission cathode. Appl. Phys. Lett. 81, 355 (2002)

    Article  Google Scholar 

  7. de Jonge, N., Lamy, Y., Schoots, K., Oosterkamp, T.H.: High brightness electron beam from a multi-walled carbon nanotube. Nature 420, 393 (2002)

    Article  Google Scholar 

  8. Chen, J., Liang, X.H., Deng, S.Z., Xu, N.S.: Flat-panel luminescent lamp using carbon nanotube cathodes. J. Vac. Sci. Technol. B21, 1727 (2003)

    Article  Google Scholar 

  9. Teo, K.B.K., Minoux, E., Hudanski, L., Peauger, F., Schnell, J.P., Gangloff, L., Legagneux, P., Dieumegard, D., Amaratunga, G.A.J., Milne, W.I.: Microwave devices: carbon nanotubes as cold cathodes. Nature 437, 968 (2005)

    Article  Google Scholar 

  10. Yabushita, R., Hata, K., Sato, H., Saito, Y.: Development of compact field emission scanning electron microscope equipped with multiwalled carbon nanotube bundle cathode. J. Vac. Sci. Technol. B25, 640 (2007)

    Article  Google Scholar 

  11. Rinzler, A.G., Hafner, J.H., Nikolaev, P., Lou, L., Kim, S.G., Tomanek, D., Nordlander, P., Colbert, D.T., Smalley, R.E.: Unraveling nanotubes: field emission from an atomic wire. Science 269, 1550 (1995)

    Article  Google Scholar 

  12. Wong, T.-H., Gupta, M.C., Hernandez-Garcia, C.: Nanosecond laser pulse-induced electron emission from multiwall carbon nanotube film. Nanotechnology 18, 135705 (2007)

    Article  Google Scholar 

  13. Watts, P.C.P., Lyth, S.M., Mendoza, E., Silva, S.R.P.: Polymer supported carbon nanotube arrays for field emission and sensor devices. Appl. Phys. Lett. 89, 103113 (2006)

    Article  Google Scholar 

  14. Bonard, J.M., Weiss, N., Kind, H., Stöckli, T., Forró, L., Kern, K., Chátelain, A.: Tuning the field emission properties of patterned carbon nanotube films. Adv. Mater. 13, 184 (2001)

    Article  Google Scholar 

  15. Rao, A.M., Jacques, D., Haddon, R.C.: In situ-grown carbon nanotube array with excellent field emission characteristics. Appl. Phys. Lett. 76, 3813 (2000)

    Article  Google Scholar 

  16. Liu, Y.M., Fan, S.S.: Enhancement of field emission properties of cyanoacrylate–carbon nanotube arrays by laser treatment. Nanotechnology 15, 1033 (2004)

    Article  Google Scholar 

  17. Hata, K., Futaba, D.N., Mizuno, K., Namai, T., Yumura, M., Iijima, S.: Water-assisted highly efficient synthesis of impurity-free singlewalled carbon nanotubes. Science 306, 1362 (2004)

    Article  Google Scholar 

  18. Zeng, B.Q., Xiong, G.Y., Chen, S., Wang, W.Z., Wang, D.Z., Ren, Z.F.: Enhancement of field emission of aligned carbon nanotubes by thermal oxidation. Appl. Phys. Lett. 89, 223119 (2006)

    Article  Google Scholar 

  19. Zhong, G.F., Iwasaki, T., Kawarada, H.: Semi-quantitative study on the fabrication of densely packed and vertically aligned single-walled carbon nanotubes. Carbon 44, 2009 (2006)

    Article  Google Scholar 

  20. Chen, G., Shin, D.H., Iwasaki, T., Kawarada, H., Lee, C.J.: Enhanced field emission properties of vertically aligned double-walled carbon nanotube arrays. Nanotechnology 19, 415703 (2008)

    Article  Google Scholar 

  21. Nilsson, L., Groening, O., Groening, P., Kuettel, O., Schlapbach, L.: Characterization of thin film electron emitters by scanning anode field emission microscopy. J. Appl. Phys. 90, 768 (2001)

    Article  Google Scholar 

  22. Patole, S.P., Alegaonkar, P.S., Shin, H.C., Yoo, J.B.: Alignment and wall control of ultra long carbon nanotubes in water assisted chemical vapour deposition. J. Phys. D: Appl Phys. 41, 155311 (2008)

    Article  Google Scholar 

  23. Patole, S.P., Park, J.H., Lee, T.Y., Lee, J.H., Patole, A.S., Yoo, J.B.: Growth interruption studies on vertically aligned 2–3 wall carbon nanotubes by water assisted chemical vapor deposition. Appl. Phys. Letts. 93, 114101 (2008)

    Article  Google Scholar 

  24. http://sine.ni.com/nips/cds/view/p/lang/en/nid/14132

  25. Late, D.J., Date, K.S., More, M.A., Misra, P., Singh, B.N., Kukreja, L.M., Dharmadhikari, C.V., Joag, D.S.: Enhanced field emission from LaB6 thin films with nanoprotrusions grown by pulsed laser deposition on Zr foil. Nanotechnology 19, 265605 (2008)

    Article  Google Scholar 

  26. Saito, R., Dresselhaus, G., Dresselhaus, M.S.: Physical Properties of Carbon Nanotubes, pp. 142–145. World Scientific, Singapore (1998)

    Book  Google Scholar 

  27. Fowler, R.H., Nordheim, L.W.: Electron Emission in Intense Electric Fields. Proc. R. Soc. London, Ser. A. 119, 173 (1928)

    Article  Google Scholar 

  28. Kolekar, S., Patole, S.P., Patil, S., Yoo, J.B., Dharmadhikari, C.V.: Study of thermal-field emission properties and investigation of temperature dependent noise in the field emission current from vertical carbon nanotube emitters. Surf. Sci. 664, 76 (2017)

    Article  Google Scholar 

  29. Edgcombe, C.J., Valdre, U.: Experimental and computational study of field emission characteristics from amorphous carbon single nanotips grown by carbon contamination. I. Experiments and computation. Philos. Mag. B82, 987 (2002)

    Google Scholar 

  30. Kolekar, S.K., Patole, S.P., Alegaonkar, P.S., Yoo, J.B., Dhamadhikari, C.V.: A comparative study of thermionic emission from vertically grown carbon nanotubes and tungsten cathodes. Appl. Surf. Sci. 257, 10306–10310 (2011)

    Article  Google Scholar 

  31. Gonzalez, R.C., Woods, R.E.: Digital Image Processing, (3rd Edition), Prentice Hall, Prentice, ISBN-10: 9780131687288 (2007)

  32. Gesley, M., Swanson, L.: Thermal-field emission flicker (1/f) noise and diffusive equilibrium density fluctuations. Phys. Rev. A. 37, 4879 (1988)

    Article  Google Scholar 

  33. Dharmadhikari, C.V., Khairnar, R.S., Joag, D.S.: Noise in field-induced electron emission from graphite composite: spectral density and autocorrelation investigations. J. Phys. D Appl. Phys. 25, 125 (1992)

    Article  Google Scholar 

Download references

Acknowledgements

SK would like to acknowledge UGC for Junior Research Fellowship (JRF) and CNQS, Savitribai Phule Pune University for technical assistantship.

Author information

Author notes

  1. Sadhu Kolekar

    Present address: Department of Physics, University of South Florida, Tampa, FL, 33620-995, USA

  2. Shashikant P. Patole

    Present address: Department of Materials Science and Engineering, King Abdullah University of Science and Technology, Thuwal, 23955-6900, Saudi Arabia

  3. Chandrakant V. Dharmadhikari

    Present address: Indian Institute of Science Education and Research, Pashan, Pune, 411008, India

Authors and Affiliations

  1. Department of Physics, Savitribai Phule Pune University, Pune, 411007, India

    Sadhu Kolekar & Chandrakant V. Dharmadhikari

  2. School of Advanced Materials Science and Engineering, Sungkyunkwan University, Suwon, 16419, Korea

    Shashikant P. Patole & Ji-Beom Yoo

Authors
  1. Sadhu Kolekar
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Shashikant P. Patole
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Ji-Beom Yoo
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Chandrakant V. Dharmadhikari
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding authors

Correspondence to Sadhu Kolekar or Chandrakant V. Dharmadhikari.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Kolekar, S., Patole, S.P., Yoo, JB. et al. Investigation of Electron Transport Across Vertically Grown CNTs Using Combination of Proximity Field Emission Microscopy and Scanning Probe Image Processing Techniques. Electron. Mater. Lett. 14, 173–180 (2018). https://doi.org/10.1007/s13391-018-0009-2

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s13391-018-0009-2

Keywords

Search

Navigation