Abstract
The adhesion of organic surface coatings to the substrate, whether metal, wood or plastic, is an important property since, to afford protection or decoration, the coatings must adhere to the substrate and remain adherent during the service environment. Many types of conventional coatings show a marked loss of adhesion under conditions of high humidity and under water immersion conditions;1–3 often this observed loss of adhesion is both rapid and dramatic. The importance of high ‘wet’ adhesion in corrosion protection has been stressed by Funke and other workers.4–6 The aim must, therefore, be to develop a coating/substrate combination which has high initial adhesion, maximum ‘wet’ adhesion, i.e. adhesion under the most severe environmental conditions met in service, and a high recovered adhesion. Ideally, the recovered adhesion should not be affected by repeated exposure cycling.
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
Preview
Unable to display preview. Download preview PDF.
Bibliography
Silanes
Johannson, O. K. et al., Investigation of the Physical-Chemical Nature of the Matrix-Reinforcement Interface, AFML-TR-65-303, Parts 1 and 2, 1965–1966.
Bascom, W. D., The Function of Adhesion Promoters in Adhesive Bonding, NRL Report 6916, 1969.
Plueddemann, E. P., Aqueous solutions of organoalkoxy-silanes’, Paper presented at 24th Annual SPI RP/C Conference, 1969, Section 19A, Paper 1.
Orenski, P., Silane coupling agents performance in engineering plastics, Paper presented at 28th Annual SPI RP/C Conference, 1973, Section 3E, Paper 1.
Plueddemann, E. P. and Stark, G. L., Surface modification of fillers and reinforcements in plastics, Paper presented at 32nd Annual SPI RP/C Conference, 1977, Section 4C, Paper 1.
Leyden, D. E. and Collins, W. T., Silylated Surfaces, 1980, Gordon and Breach Science Publishers, New York.
Plueddemann, E. P., Silane Coupling Agents, 1982, Plenum Press, New York.
Titanates
Monte, S. J., Improved coatings performance with titanium coupling agents, Paper presented at Improving Protective Performance of Coatings Symposium, 1–3 June, 1977, North Dakota State University, Fargo, N. Dakota, USA.
Monte, S. J. and Sugerman, G., University of Southern Mississippi, Water Borne and High Solids Coating Symposium, 8–11 February, 1978, New Orleans, USA.
Monte, S. J. and Sugerman, G., Applications of titanate coupling agents in latex and the water phase, Amer. Chem. Soc. Rubber Division 113th Meeting, 2–5 May 1978, Montreal, Canada.
Monte, S. J. and Sugerman, G., New corrosion resistance opportunities with titanate coupling agents in coatings AICHE 71st Annual Meeting, 16 November 1978, Miami Beach, Florida, USA.
Monte, S. J. and Sugerman, G., Titanate chelates for improving the properties of paints, 6th International Coating Conference, 16 July 1980, Athens, Greece.
Monte, S. J. and Sugerman, G., High solids and non-chromate corrosion resistant primers with titanate coupling agents, Amer. Chem. Soc. Organic Coatings and Plastics Chemistry Division, 26–28 August 1980, San Francisco, USA.
Monte, S. J. and Sugerman, G., The use of titanate coupling agents in urethanes, SPI Urethane Division, 19–20 October 1982, Bai Harbor, Florida, USA.
Monte, S. J. and Sugerman, G., The use of titanate coupling agents as adhesion and conductivity promoters, Circuit Expo 82, October 1982, Worcester, Montana, USA.
Monte, S. J. and Sugerman, G., New neoalkoxy titanate and zirconate coupling agents, SPE ANTEC, 29 April, 2 May, 1985, Washington DC, USA, Paper 201.
References
James, D. M., J. Oil Col. Chem. Assoc., 1960, 43, 391.
Dunkley, F. and Earp, D. F., J. Oil Col. Chem. Assoc., 1961, 44, 649.
Walker, P., Off. Digest, 1965, 37, 1561.
Van Fischer, W. and Bobalek, E. G., Organic Protective Coatings, 1st edn, 1953, Renhold Publishing Corp., New York.
Timmins, F., J. Oil Col. Chem. Assoc., 1979, 61, 131.
Funke, W., J. Oil Col. Chem. Assoc., 1985, 68, 229.
Soliman, K. J., private communication.
Anon., Silane Coupling Agents, Dow Corning Literature, 23-012A-81.
Erickson, P. W. and Plueddemann, E. P., in Composite Materials, Vol. 6, ed. Plueddemann, E. P., 1974, Academic Press, New York.
Bascom, W. D., NRL Report 6916, 1969.
Bascom, W. D., Macromolecules, 1972, 5, 792.
Sterman, S., Marsden, J. G. and Ranney, M. W., RPG Conference on New and Improved Resin Systems, 1973, London.
Falconer, D. J., MacDonald, N. and Walker, P., Chem. Ind., July 1964, 1230.
Sato, F., Uchiyama, H. and Samadder, A. K., Chem. Ind., October 1984, 743.
Sounak, D. F. and Kenney, M. E., Polym. Comp., 1985, 6, 151.
Bascom, W. D., in Composite Materials, Vol. 6, ed. Plueddemann, E. P., 1974, Academic Press, New York.
Rosen, M. R., J. Coat. Technol., 1978, 50 (644), 70.
Plueddemann, E. P., Electrochem. Soc. Symposium on Coatings, 14 May, 1981, Minneapolis, USA.
Gettings, M. and Kinloch, J., Mater. Sci., 1977, 12, 251.
Boerio, F. J. and Williams, J. W., Applications of Surface Science, Vol.7, 1981, North Holland Publishing Company, Amsterdam, p. 19.
Colthrup, N. B., Daley, L. H. and Wiberley, S. E., Introduction to Infrared and Raman Spectroscopy, 2nd edn, 1975, Academic Press, New York.
Sung, H. H. and Sung, C. S. P., 35th Ann. Tech. Conf. Reinf. Plastics/Composite Inst., 1980, SPI 23B.
Sung, H H. and Sung, C. S. P., Org. Coat. Plast. Chem., 1980, 42, 743.
Koenig, J. L. and Shik, P. T. K., Mater. Sci. Eng., 1975, 20, 127.
Boerio, F. J., Gosselin, C. A. and Dillingham, R. G., 15th National SAMPE Tech. Conf, Oct. 4–6 1983, p. 212.
Holloway, M. W. and Walker, P., J. Oil Col. Chem. Assoc., 1964, 47, 112.
Plueddemann, E. P., Prog. Org. Coat., 1983, 11, 297.
US Patent 4154 638.
European Patent 972173.
US Patent 4233 428.
Graham, L. and Emerson, J. A., Adhesion Aspects of Polymeric Coatings, ed. K. L. Mittal, 1983, Plenum Press, New York.
Japanese Patent 82 059 271.
Japanese Patent (U) 57153 055.
Walker, P., J. Oil Col. Chem. Assoc., 1982, 65, 415.
Walker, P., J. Oil Col. Chem. Assoc., 1982, 65, 436.
Matsuda, Y. and Yasuda, H., Thin Solid Films, 1984, 118, 211.
Walker, P., J. Oil Col. Chem. Assoc., 1983, 66, 188.
Walker, P., J. Oil Col. Chem. Assoc., 1984, 67, 108.
Joint Services Ramp;D Committee on Adhesion and Accelerated Weathering, J. Oil Col. Chem. Assoc., 1963, 46, 4.
Cleveland Society for Coatings Technology, J. Coat. Technol., 1979, 51, 53.
Walker, P., J. Oil Col. Chem. Assoc., 1984, 67, 126.
US Patent 4 231910.
Buening, R. and Koetzsh, H. J., Angew. Makromol. Chem., 1976, 13, 89.
Thomas, S. F. and Evans, J. M. Paint Technol., 1976, 43, 558.
Plueddemann, E. P., Poly electrolytes and Their Applications, 1975, D. Reidel, Dordrecht.
Helbert, J. N. and Hughes, H. G., Adhesion Aspects of Polymeric Coatings, ed. K. L. Mittal, 1983, Plenum Press, New York.
US Patent 4069192.
US Patent 4122 062.
US Patent 4 417 009.
Anon., Ken-React Reference Manual, KR-1084L, Kenrich Petrochemical Inc, Bayonne, NJ, 1985.
Cleveland Society for Coatings Technology, J. Coat. Technol., 1979, 51 (655), 38.
Anon., Magnesium Elektron Data Sheet 103A, March 1982, Twickenham, UK.
Anon., Magnesium Elektron Data Sheets 157, Nov. 1984; 114D, Nov. 1983; 114C, Nov. 1983, Twickenham, UK.
Anon., Magnesium Elektron Data Sheet 114B, Nov. 1983, Twickenham, UK.
Moles, P. J., Polymers, Paint Col. J., 1985, 175 (4146), 447.
Cohen, B. L., High Solids Coatings, 1984, 9 (3), 2.
Cassidy, P. E. and Yager, B. J., Polym. Technol., 1972, 1, 1.
Deutsch, L., Schrader, M. E., Lerner, I. and D’Oria, F. J., Proc. Ann. Tech. Conf. 22nd SPI Reinforced Plastics Div., 1967, Washington DC, USA.
French Patent 1152267.
US Patent 2 941912.
Anon., Japanese Patent Gazette, Vol. E, No. 27, Group G12, 1982.
Paramanov, V. A., Ilalova, R. K., Popova, I. A., Katser, I. M. and Litvinenko, V. A., Prot. Metals, 1983, 19 (3), 343.
Yates, P. C. and Trebilcock, J. W., Reinforced Plastics Div. Soc. Plastics Ind., 1961,16, 8-B.
US Patent 4 319 032.
US Patent 4 487 940.
US Patent 4487 941.
US Patent 4357181.
US Patent 3 356 655.
US Patent 3 509085.
Liang, F. and Dreyfuss, P., Amer. Chem. Soc. Div. of ORPL Papers, 1983, 48, 18.
Wilhelm, S. M., Tanizawa, Y., Liu, C. Y. and Hackerman, N., Corros. Sci., 1982, 22, 791.
Cassidy, P. E. and Yager, B. J., TRACOR Document No. T70-AU- 7362-U, NASA Contract NA-58-24073.
US Patent 4476263.
Shim-Ton, J., Varevorakul, S. and Woodhams, R. T., Polym. Sci. Rev., 1984, 26, 391.
Mahajon, S. S. and Ghatge, N. D., Int. J. Polym. Mater., 1983, 10, 141.
US Patent 3 838078.
European Patent Application 114208.
Anon., Hardlen Technical Report, Siber Hegner Limited, Beckenham, Kent.
European Patent Application 069 826.
US Patent 4 357 440.
European Patent Application 084 111.
Anon., European Patent Report, Vol. K, No. 31, Gp. Gl, 1983.
Anon., Soviet Invent. III., Vol. K, No. 30, Gp. 4, 1983.
Japanese Patent 82 63 367 A2.
US Patent 4428 987.
Islam, M., Gupta, P. C. and Prasad, R., Res. Ind., 1982, 27, 178.
Anon., European Patent Report, Vol. E, No. 4, Gp. M4, 1982.
Shaw, R. G., Proc. 25th Annual Tech. Conf. SPI Reinforced Plastics I Composites, Feb. 1970, Washington, DC, USA.
Japanese Patent 59 66251.
Japanese Patent 57149 356.
Japanese Patent 58 74 747.
US Patent 4 374 780.
Anon., Union Carbide Data Sheet E-100E, 1974, Tarrytown NY.
Author information
Authors and Affiliations
Editor information
Editors and Affiliations
Rights and permissions
Copyright information
© 1987 Elsevier Applied Science Publishers Ltd
About this chapter
Cite this chapter
Walker, P. (1987). Adhesion Promoters. In: Wilson, A.D., Nicholson, J.W., Prosser, H.J. (eds) Surface Coatings—1. Springer, Dordrecht. https://doi.org/10.1007/978-94-009-3441-2_6
Download citation
DOI: https://doi.org/10.1007/978-94-009-3441-2_6
Publisher Name: Springer, Dordrecht
Print ISBN: 978-94-010-8040-8
Online ISBN: 978-94-009-3441-2
eBook Packages: Springer Book Archive