Colloid Science — as Applied to Ceramics

  • Daniel J. Shanefield

Abstract

The study of very fine particles dispersed in fluids falls under the category of colloid science. Definitions of some of the most important terms used in this field appear in Appendix II. It is suggested that the reader look quickly through that word list and get a general idea of the information available there before proceeding further in this chapter.

Keywords

Shear Rate Zeta Potential Powder Particle Ceramic Powder Powder Surface 
These keywords were added by machine and not by the authors. This process is experimental and the keywords may be updated as the learning algorithm improves.

Preview

Unable to display preview. Download preview PDF.

Unable to display preview. Download preview PDF.

References

  1. 1.
    H. van Olphen, “Clay Colloid Chemistry, “J. Wiley, New York (1977).Google Scholar
  2. G. W. Phelps, et al., “Rheology and Rheometry of Clay-Water Slips,” Cyprus Co., Sandersville, GA (1980) 42.Google Scholar
  3. 2.
    F. M. Fowkes, Advances in Ceramics, 21 (1987) 411 (particularly page 411).Google Scholar
  4. 3.
    M. D. Sacks, et al., Advances in Ceramics, 21 (1987) 500.Google Scholar
  5. 4.
    H. Ishida, et al., Polymer Engrng. and Sci., 18 (1978) 128.CrossRefGoogle Scholar
  6. E. P. Plueddemann, “Silane Coupling Agents,” Plenum Press, New York (1991).Google Scholar
  7. 5.
    M. L. Hair, “Infrared Spectroscopy in Surface Chemistry,” Marcel Dekker, New York (1967).Google Scholar
  8. E. S. Tormey, Advances in Ceram., 9 (1984) 140; R. J. Higgins, Ph.D. Thesis, MIT (1990) [see particularly pages 125, 136].Google Scholar
  9. 6.
    A. Doroszkowski, et al., Faraday Discuss’n of Chem. Soc., 65 (1978) 252.CrossRefGoogle Scholar
  10. 7.
    H. Koelmans and T. G. Overbeek, Disc. Faraday Soc., 1954 (1954) 52.CrossRefGoogle Scholar
  11. A. E. Lewis, J. Am. Ceram. Soc., 44 (1961) 233.CrossRefGoogle Scholar
  12. 8(a).
    D. J. Shanefield, et al., Am. Ceram. Soc. Bul., 53 (1974) 416 [see particularly page 419, and also references 18-24 cited in that article]; 05)Google Scholar
  13. E. S. Tormey, Advances in Ceram., 9 (1984) 140.Google Scholar
  14. 8(c).
    M. D. Sacks, et al., Advances in Ceram., 21 (1987) 495.Google Scholar
  15. 8(d).
    Cesarano, I. A. Aksay, and A. Bleir, J. Am. Ceram. Soc., 71 (1988) 250, 1062.CrossRefGoogle Scholar
  16. 8(e).
    L. Bergstrom, C. H. Schilling, and I. A. Aksay, J Am. Ceram. Soc., 75 (1992) 3305 [adsorbed oleic acid was effectively 2.5 nm thick, and had a 31 square nm area, as reported in Table 1 of this reference].CrossRefGoogle Scholar
  17. 9.
    R. R. Stromberg, et al., J. Res. Nat’l. Bur. Stds., 62 (1959) 71.Google Scholar
  18. R. G. Horn, J. Am. Ceram. Soc., 73 (1990) 1117 (particularly page 1126).CrossRefGoogle Scholar
  19. A. Kerkar, et al., J. Am. Ceram. Soc., 73 (1990) 2879 (particularly page 2880).CrossRefGoogle Scholar
  20. 10.
    E. S. Tormey, L. M. Robinson, W. R. Cannon, A. Bleier, and H. K. Bowen, in “Adsorption of Dispersants from Non-Aqueous Solutions,” J. Pask and A. Evans, eds., Plenum Press, New York (1981) 121.Google Scholar
  21. P. D. Calvert, et al., Am. Ceram. Soc. Bul., 65 (1986) 669.Google Scholar
  22. 11.
    S. Lowell, “Powder Surface Area and Porosity,” Chapman & Hall, N.Y. (1991).Google Scholar
  23. 12.
    V. L Richards, J. Am. Ceram. Soc., 72 (1989) 325.CrossRefGoogle Scholar
  24. 13.
    K. E. Howard, et al., J. Am. Ceram. Soc., 73 (1990) 2543.CrossRefGoogle Scholar
  25. 14.
    F. M. Fowkes, page 325 in “Treatise on Adhesion and Adhesives,” R. L. Patrick, ed. Arnold Publ, London (1967).Google Scholar
  26. 15.
    M. S. Wrighton, et al., Science, 245 (1989) 845.CrossRefGoogle Scholar
  27. I. A. Aksay, Ceram. Int’l., 17 (1991)267.CrossRefGoogle Scholar
  28. 16.
    Cesarano, I. A. Aksay, and A. Bleier, J. Am. Ceram. Soc., 71 (1988) 250.CrossRefGoogle Scholar
  29. 17.
    G. P. Bierwagan, J. Paint Technol., 44 (1972) 46.Google Scholar
  30. G. R. Joppien, et al., J. Oil & Colloid Chem. Assoc., 60 (1977) 412.Google Scholar
  31. 18.
    D. J. Shanefield, et. al., J. Electrochem. Soc., 110 (1963) 973.CrossRefGoogle Scholar
  32. W. D. Kingery, et al., “Introduction to Ceramics,” J. Wiley, New York (1976) [see particularly Fig. 10.7].Google Scholar
  33. 19.
    G. Busca, et al., Mat’ls. Chem. & Phys., 14 (1986) 123 [imine groups].CrossRefGoogle Scholar
  34. N. J. Renault, et al., Colloids and Surfaces, 36 (1989) 59 [amine groups, etc.].CrossRefGoogle Scholar
  35. L. Bergstrom, et al., J. Am. Ceram. Soc., 72 (1989) 103.CrossRefGoogle Scholar
  36. S. G. Malghan, et al., Ceram. Trans., 26 (1992) 38.Google Scholar
  37. 20.
    F. M. Fowkes, Advances in Ceram. 21 (1987) 411 (particularly page 411).Google Scholar
  38. 21.
    M. Liphard and W. von Rybinski, Progr. Coll. & Polymer Sci., 77 (1988) 158.CrossRefGoogle Scholar
  39. 22(a).
    R. J. Hunter, “Foundations of Colloid Science,” Clarendon Press, Oxford (1987) p. 489.Google Scholar
  40. 22(b).
    R. G. Horn, J. Am. Ceram. Soc., 73 (1990) 1117 [see particularly page 1126].CrossRefGoogle Scholar
  41. 23.
    D. E. Niesz and R. B. Bennett, p. 61 in G. Y. Onoda and L. L. Hench, “Ceramic Processing Before Firing,” J. Wiley, New York (1978) [see particularly p. 73].Google Scholar
  42. S. Masia, et al., J. Mats. Sci., 26 (1991) 2081; R. J. Higgins, Ph.D. Thesis, MIT (1990) 138 [only available directly from MIT, not from the usual UMI microfilm service].CrossRefGoogle Scholar
  43. 25.
    H. Ishida, et al., Polymer Engrng. and Sci., 18 (1978) 128 [“silane treatment”].CrossRefGoogle Scholar
  44. M. J. Cima, et al., J. Am. Ceram. Soc., 76 (1993) 3136 [sulfonated PVC].CrossRefGoogle Scholar
  45. 26.
    J. A. Casey, Advances in Ceramics, 21 (1987) 439 (slip was too viscous when slightly wet).Google Scholar
  46. 27.
    B. V. Derjaguin and J. D. Landau, Acta Physicochim. URSS, 14 (1941) 633Google Scholar
  47. E. J. W. Verwey and J. T. G. Overbeek, “Theory of the Stability of Lyophobic Colloids,” Elsevier, Amsterdam (1948).Google Scholar
  48. 28.
    D. J. Shaw, “Intro. to Colloid and Surf. Chem.,” Butterworth-Heinemann, Newton, Mass. (1992).Google Scholar
  49. 29(a).
    R. G. Horn, J. Am. Ceram. Soc., 73 (1990) 1117.CrossRefGoogle Scholar
  50. 29(b).
    R. J. Pugh and L. Bergstrom, “Surface and Colloid Chem. in Advanced Ceram. Processing,” Marcel Dekker, New York (1993).Google Scholar
  51. 30.
    (a)_R. E. Johnson, et al., Advances in Ceram., 21 (1987) 323 [10 & 20 nm, Figs. 11,14 and also p. 328].Google Scholar
  52. 30(b).
    J. A. Casey, et al., Advances in Ceram., 21 (1987) 439 [10 to 20nm, Figs. 4 &5].Google Scholar
  53. 30(c).
    R. Hogg, Advances in Ceram., 21 (1987) 467 [60nm, Fig. 1].Google Scholar
  54. 31.
    W. A. Ducker, Z. Xu, D. R. Clarke, and J. N. Israelachvili, J. Am. Ceram. Soc., 77 (1994) 437.CrossRefGoogle Scholar
  55. 32.
    F. F. Lange, et al., J. Am. Ceram. Soc., 77 (1994) 1047 [pH 2, high NH4Cl, plastic green body].CrossRefGoogle Scholar
  56. 33.
    J.-F. Wang, R. E. Riman, and D. J. Shanefield, Mat’ls. Res. Soc. Sympos. Proc., 180 (1990) 293.CrossRefGoogle Scholar
  57. 34.
    J. F. Kelso, et al., J. Am. Ceram. Soc., 72 (1989) 625.CrossRefGoogle Scholar
  58. 35.
    L. Romo, et al., Disc. Faraday Soc., 42 (1966) 232.CrossRefGoogle Scholar
  59. T. Allen and R. M. Patel, J. Colloid and Interface Sci., 37 (1971) 595.CrossRefGoogle Scholar
  60. 36(a).
    W. R. Cannon, et al., Advances in Ceram., 21 (1987) 525.Google Scholar
  61. 36(b).
    E. M. DeLiso, J. Kowalski, and W. R. Cannon, Adv. Ceram. Mat’ls., 3 (1988) 407.Google Scholar
  62. 36(c).
    R. J. Pugh and L. Bergstrom, “Surface and Colloid Chem. in Advanced Ceram. Processing,” Marcel Dekker, New York (1993).Google Scholar
  63. 37.
    J.-F. Wang, R. E. Riman, and D. J. Shanefield, Ceram. Trans., 26 (1992) 240.Google Scholar
  64. 38.
    A. Foissy, J. Colloid & Interface Sci., 96 (1983) 275.CrossRefGoogle Scholar
  65. H. J. Cesarano and I. A. Aksay, J. Am. Ceram. Soc., 71 (1988) 1062.CrossRefGoogle Scholar
  66. Z. C. Chen, T. A. Ring, and J. Lemaitre, Ceram. Trans., 22 (1991) 257.Google Scholar
  67. 39.
    K. Nagata, Ceramic Trans., 26 (1992) 205 [see Fig. 3].Google Scholar
  68. 40.
    H. J. Cesarano and I. A. Aksay, J. Am. Ceram. Soc., 71 (1988) 1062 (Fig.5).CrossRefGoogle Scholar
  69. 41.
    R. Hogg, Advances in Ceram., 21 (1987) 467 [Fig. 3].Google Scholar
  70. 42.
    G. W. Phelps, et al., “Rheology and Rheometry of Clay-Water Slips,” Cyprus Co., Sandersville, GA (1980) 139.Google Scholar
  71. 43.
    D. J. Shanefield et al., Am. Ceram. Soc. Bul., 53 (1974) 416 (Table 5).Google Scholar
  72. 45.
    K. Nagata, Ceramic Trans., 22 (1991) 335 (see Fig. 1).Google Scholar
  73. 46.
    D. H. Napper, “Polymeric Stabilization of Colloidal Dispersions,” Academic Press, London (1983).Google Scholar
  74. R. G. Horn, J. Am. Ceram. Soc., 73 (1990) 1117.CrossRefGoogle Scholar
  75. 47.
    S. S. Patel, Annual. Rev. Phys. Chem., 40 (1989) 597.CrossRefGoogle Scholar
  76. 48.
    F. J. Micale, et al., Disc. Faraday Soc., Number 42 (1966) 238.CrossRefGoogle Scholar
  77. R. J. Pugh, et al., Colloids and Surfaces, 7 (1983) 183.CrossRefGoogle Scholar
  78. 49.
    W. R. Cannon, et al., Advances in Ceram., 26 (1989) 525.Google Scholar
  79. 50.
    F. F. Lange, et al., J. Am. Ceram. Soc., 77 (1994) 922.CrossRefGoogle Scholar
  80. 51.
    I. Tsao and S. C. Danforth, J. Am. Ceram. Soc., 76 (1993) 2977.CrossRefGoogle Scholar
  81. 52.
    C. Gelassi, et. al., “Third Euro-Ceramics Proa, Vol. 1,” Faenza Editrice, Madrid (1993) 609.Google Scholar
  82. 54.
    G. Y. Onoda, E. G. Liniger, and M. A. Janney, Ceram. Trans., 1B (1988) 611.Google Scholar
  83. D. A. Barclay, Ceram. Trans., 26 (1992) 81.Google Scholar
  84. 65.
    J. W. Goodwin, Am. Ceram. Soc. Bul., 69 (1990) 1694 [see Fig.3].Google Scholar
  85. 56.
    M. Rajala, Am. Ceram. Soc. Bul., 71 (1992) 1817.Google Scholar
  86. 57.
    R. M. German, J. Am. Ceram. Soc., 77 (1994) 283 [see modified Metzner formula, equation 2].CrossRefGoogle Scholar
  87. 58.
    M. A. Janney and G. Y. Onoda, Jr., Advances in Ceramics, 21 (1987) 615 [see equation 8].Google Scholar
  88. 59.
    A. I. Isayev, Advances in Ceramics, 21 (1987) 601 [see equation 3].Google Scholar
  89. 60.
    K. Nagata, Ceramic Trans., 22 (1991) 335 (see Fig. 3).Google Scholar
  90. K. Nagata, Ceramic Trans., 26 (1992) 205 [see Fig. 1].Google Scholar

Copyright information

© Springer Science+Business Media New York 1995

Authors and Affiliations

  • Daniel J. Shanefield
    • 1
  1. 1.Rutgers UniversityUSA

Personalised recommendations