Abstract
The suitability of nanosized-POFA (nPOFA) as a supplementary cementing material has not been discovered enough. Therefore, the present study investigates the degree of cement hydration of Hardened Cement Paste (HCP) incorporating nPOFA via thermal and XRD analysis. The nPOFA was prepared by grinding the micro-POFA (mPOFA) using ceramic ball milling for 30 h. A series of Hardened Cement Paste (HCP) incorporating 10–60% of nPOFA and 10–30% of mPOFA were prepared and examined at 28- and 90-day curing age. The hydration of cement was assessed by monitoring the dehydroxylation of portlandite (CH) through Thermogravimetric Analysis (TGA) and X-ray Diffraction (XRD) analysis. The prepared nPOFA possesses average crystallite size calculated from the XRD diffractogram which is 34.74 nm, and BET surface area of 145.35 m2/g. Based on the TG analysis, the HCP with 30% nPOFA replacement gives the highest CH consumption in the HCP within the interval time of two curing ages. Significantly, it indicates that 30% nPOFA replacement in HCP accelerates the hydration of cement through the pozzolanic reaction between the amorphous silica and CH from the hydrated products. Meanwhile, the XRD analysis indicated a decrease in CH peaks intensity in nPOFA HCP, which corresponds to the consumption of CH in the pozzolanic reaction. The results show that the high fineness of nPOFA results in the high distribution in HCP and rapid dissolution as it increases the rate of pozzolanic reaction.
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
References
Abdullah K, Hussin MH, Zakaria M et al (2006) POFA: a potential partial cement replacement material in aerated concrete. In: 6th Asia Pacific structural engineering and construction (APSEC 2006), 5–6 September. https://doi.org/10.4028/www.scientific.net/AMM.567.446
Tangchirapat W, Khamklai S, Jaturapitakkul C (2012) Use of ground palm oil fuel ash to improve strength, sulfate resistance, and water permeability of concrete containing high amount of recycled concrete aggregates. Mater Des 41:150–157. https://doi.org/10.1016/j.matdes.2012.04.054
Al-Mulali MZ et al (2015) The incorporation of oil palm ash in concrete as a means of recycling: a review. Cem Concr Compos 55:129–138. https://doi.org/10.1016/j.cemconcomp.2014.09.007
Safiuddin M, Salam MA, Jumaat MZ (2013) Utilization of palm oil fuel ash in concrete: a review. J Civ Eng Manag 17(2):234–247. https://doi.org/10.3846/13923730.2011.574450
Singh LP et al (2013) Beneficial role of nanosilica in cement-based materials: a review. Constr Build Mater 47:1069–1077. https://doi.org/10.1016/j.conbuildmat.2013.05.052
Al-Jabri K, Shoukry H (2014) Use of nano-structured waste materials for improving mechanical, physical and structural properties of cement mortar. Constr Build Mater 73:636–644. https://doi.org/10.1016/j.conbuildmat.2014.10.004
Abdul Khalil HPS et al (2011) Preparation and characterization of nanostructured materials from oil palm ash: a bioagricultural waste from oil palm mill. BioResources 6(4):4537–4546
Zhang J, Scherer GW (2011) Comparison of methods for arresting hydration of cement. Cem and Concr Res 41(10):1024–1036. https://doi.org/10.1016/j.cemconres.2011.06.003
Megat Johari MA et al (2012) Engineering and transport properties of high-strength green concrete containing high volume of ultrafine palm oil fuel ash. Constr Build Mater 30:281–288. https://doi.org/10.1016/j.conbuildmat.2011.12.007
El-Diadamony H et al (2016) Hydration and characteristics of metakaolin pozzolanic cement pastes. HBRC J 14(2):150–158. https://doi.org/10.1016/j.hbrcj.2015.05.005
Deboucha et al (2017) Hydration development of mineral additives blended cement using thermogravimetric analysis (TGA): methodology of calculating the degree of hydration. Constr Build Mater 146:687–701. https://doi.org/10.1016/j.conbuildmat.2017.04.132
Morsy MS, Alsayed SH, Aqel M (2010) Effect of nano-clay on mechanical properties and microstructure of ordinary portland cement mortar. Int J Civ Environ Eng 10(1):23–27
Saikia N, Kato S, Kojima T (2006) Thermogravimetric investigation on the chloride binding behaviour of MK-lime paste. Thermochim Acta 444(1):16–25. https://doi.org/10.1016/j.tca.2006.02.012
Rajak MAA, Majid ZA, Ismail M (2019) Pozzolanic activity of nanosized palm oil fuel ash: a comparative assessment with various fineness of palm oil fuel ash. IOP Conf Ser Earth Environ Sci 220:012061. https://doi.org/10.1088/1755-1315/220/1/012061
Siddique R, Khan MI (2011) Supplementary cementing material. Springer-Verlag, Berlin Heidelberg
Rajak MAA, Majid ZA, Ismail M (2015) Morphological characteristics of hardened cement pastes incorporating nano-palm oil fuel ash. Procedia Manuf 2:512–518. https://doi.org/10.1016/j.promfg.2015.07.088
Pacheco-Torgal F, Jalali S (2011) Nanotechnology: advantages and drawbacks in the field of construction and building materials. Constr Build Mater 25(2):582–590. https://doi.org/10.1016/j.conbuildmat.2010.07.009
Acknowledgements
The authors thank the staff of Department of Chemistry, Faculty of Science and the Department of Structure and Materials, Faculty of Civil Engineering, Universiti Teknologi Malaysia. The authors also acknowledge Universiti Malaysia Sabah and Ministry of High Education Malaysia for the financial support.
Author information
Authors and Affiliations
Corresponding author
Editor information
Editors and Affiliations
Rights and permissions
Copyright information
© 2020 Springer Nature Singapore Pte Ltd.
About this paper
Cite this paper
Rajak, M.A.A., Majid, Z.A., Ismail, M. (2020). Cement Hydration Extents for Hardened Cement Paste Incorporating Nanosized-Palm Oil Fuel Ash: A Thermal and XRD Analysis Study. In: Awang, M., Meor M Fared, M. (eds) ICACE 2019. Lecture Notes in Civil Engineering, vol 59. Springer, Singapore. https://doi.org/10.1007/978-981-15-1193-6_7
Download citation
DOI: https://doi.org/10.1007/978-981-15-1193-6_7
Published:
Publisher Name: Springer, Singapore
Print ISBN: 978-981-15-1192-9
Online ISBN: 978-981-15-1193-6
eBook Packages: EngineeringEngineering (R0)