Severe tracheal stenosis due to prolonged tracheostomy tube placement: a case report
- 3.2k Downloads
Tracheal stenosis is the most common late airway complication of tracheostomy. Severe tracheal stenosis resulted in hemodynamic deterioration and impairment of respiratory system mechanics. We cared for an 86-year-old man with severe tracheal stenosis due to prolonged placement of a tracheostomy tube for 42-months. At the distal tip of the tracheostomy tube, bronchoscopy revealed severe tracheal luminal obstructions by granulation tissue. During pressure-controlled ventilation, the peak airway pressure was much higher than the inspiratory pressure. For patients with clinical signs of tracheal stenosis after tracheotomy, bronchoscopy should be done as early as possible.
KeywordsContinuous Renal Replacement Therapy Inspiratory Pressure Tracheostomy Tube Tracheal Stenosis Peak Airway Pressure
intensive care unit
positive end expiratory pressure
peak airway pressure
synchronized intermittent mandatory ventilation.
Severe tracheal stenosis can be life-threatening when critical narrowing of the airway occurs [1, 2]. However, identification of tracheal stenosis may be particularly challenging due to the insidious development and the patient's co-existent severe illness. Fiberoptic bronchoscopy is the gold standard for identification of tracheal stenosis . We recently cared for a patient with severe tracheal stenosis after a tracheostomy in situ for nearly 4 years.
A 86-year-old Han Chinese man had a hypertensive intraventricular hemorrhage on 7 December 2004. He immediately underwent emergency surgical placement of bilateral external ventricular drains under general anesthesia, and was transferred to the intensive care unit (ICU) for mechanical ventilation. After 3 days, a standard surgical tracheostomy was performed because the patient had a short thick neck. A high-volume, low-pressure cuffed tracheostomy tube with an 8.0 mm ID and an 11.0 mm OD was inserted. On 20 December 2004, he was weaned off of ventilatory support. The patient remained deeply comatose and descended into a persistent vegetative state. His stay in the ICU with aggressive nursing measures continued.
On 25 June 2007, the patient had progressive respiratory distress with rapid shallow breathing, while using all accessory muscles of respiration. He had a respiratory rate of 50 breaths.min-1, and a fluctuating arterial oxygen saturation of 70~80% with 10 L.min-1 of supplementary oxygen. The patient was ventilated with the synchronized intermittent mandatory ventilation (SIMV) pressure-controlled mode. The settings were as follows: respiratory rate (RR), 16 breaths/min; inspiratory pressure, 16 cm H2O; inspiratory time, 0.9 second; pressure support (PS), 16 cm H2O; positive end expiratory pressure (PEEP), 3 cm H2O; and FiO2, 0.35. With these settings, the peak airway pressure (PIP) was 19 cm H2O, the exhaled tidal volume was 600 ml, and the arterial blood gas parameters were satisfactory. He was weaned off of mechanical ventilatory support after 9 days. On 14 January 2008, he experienced a similar episode of dyspnea and received intermittent mechanical ventilation for 5-15 d at 1-2 month intervals. The patient's dyspnea worsened progressively, requiring ongoing ventilator dependency, accompanied with PIP, which was gradually increased to 35~45 cm H2O.
Tracheal stenosis is the most common late airway complication of tracheostomy . In the patient presented herein, tracheal stenosis occurred at the site of the tracheostomy tube's distal tip by granulation tissue . There are multiple risk factors associated with tracheal stenosis. Prolonged placement of a tracheostomy tube accounts for 90% of cases ; in the patient described herein, the tracheostomy tube was in place for 42 months. Second, the patient coughed up airway secretions and underwent suctioning frequently, which resulted in excessive tube motion and irritation. Third, the patient's short, thick neck made the tracheostomy tube too short, and the tube tip rubbed against the tracheal membranous wall, resulting in injury, granulation tissue formation, and an obstructed tracheal lumen.
Severe tracheal stenosis can also create intrinsic positive end expiratory pressure, increase the patient's effort to breathe, especially in patients with asthma or chronic obstructive pulmonary disease, and limit weaning from the respirator . For this patient, he had to rely on mechanical ventilation to prolong his life. Moreover, severe tracheal stenosis can deteriorate cardiac output through increased airway pressure and intrathoracic pressure . Therefore, the reduced cardiac output affects systemic and renal hemodynamics, which is one mechanism for mechanical ventilation initiation or aggravation acute renal failure [6, 7]. We think that the higher PIP contributed to the patient's renal failure.
As is known, the PIP should be equal to the level of inspiratory pressure in the pressure-controlled ventilation mode. In this patient, however, the PIP progressively increased to 35~45 cm of H2O, even though the inspiratory pressure was 16 cm H2O during the pressure-controlled ventilation mode. As Brouns et al.  reported, the pressure drop over tracheal stenosis dramatically increased dependence on the severity of stenosis. During pressure-controlled ventilation, the peak airway pressure was much higher than the inspiratory pressure because of the pressure drop over severe tracheal airway stenosis; this may explain a rare abnormal phenomenon. The ventilatory strategies for severe tracheal stenosis should include volume-controlled ventilation, tidal volume, respiratory rate, and an inspiratory peak flow at low values, according to the pressure drop over tracheal stenosis depending on inspiratory flow [7, 8].
However, the diagnosis of tracheal stenosis is often made until the tracheal lumen has been reduced by 75%-90% and subsequent endanger the patients' life at any time. There are three explanations for the delayed diagnosis of this patient's tracheal stenosis: 1) the rarity of severe stenosis and its atypical respiratory symptoms, 2) the patients have other co-existing severe illnesses and the physicians lack suspicion of the possibility of tracheal stenosis, and 3) bronchoscopy, which is the most reliable method for identification of tracheal stenosis, is not routinely performed in patients with a history of intubation or tracheostomy in China . For patients with clinical signs of tracheal stenosis, a number of protocolized approaches have been recommended, and the treatment often required as a semi-emergency [1, 10].
In conclusion, severe tracheal stenosis resulted in higher PIP and hemodynamic deterioration. For patients with clinical signs of tracheal stenosis after tracheotomy, bronchoscopy should be done as early as possible.
Written informed consent was obtained from the patient's authorized guardian for publication of this case report and accompanying images. A copy of the written consent is available for review by the Editor-in-Chief of this journal.
Additional file 1: (AVI 9 MB)
Additional file 2: (AVI 9 MB)
- 5.Rumbak MJ, Walsh FW, Anderson WM, Rolfe MW, Solomon DA: Significant tracheal obstruction causing failure to wean in patients requiring prolonged mechanical ventilation: a forgotten complication of long-term mechanical ventilation. Chest. 1999, 115: 1092-1095. 10.1378/chest.115.4.1092.CrossRefPubMedGoogle Scholar
This article is published under license to BioMed Central Ltd. This is an Open Access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/3.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.