Abstract
The continuation of Moore’s law requires new materials at both extremes of the dielectric permittivity spectrum and an increased understanding of the fundamental mechanisms limiting their electrical reliability. To address the latter, reflection electron energy loss spectroscopy has been utilized to measure the band gap of various oxide-based low and high dielectric constant (k) materials of interest to the semiconductor industry. In situ Ar+ sputtering has been additionally utilized to simulate process-induced defect states that are believed to contribute to electrical leakage, time-dependent dielectric breakdown, charge trapping, and other fixed-charge reliability issues in nano-electronic devices. It is observed that Ar+ sputtering predominantly generates surface oxygen vacancy defects in the upper portion of the band gap for both low and high-k dielectric materials. These results are in agreement with numerous theoretical investigations of defects in low and high-k dielectric materials and models for mechanisms that limit their reliability.
Similar content being viewed by others
References
P. Solomon: Breakdown in silicon oxide: A review. J. Vac. Sci. Technol. 14, 1122 (1977).
K. Maex, M.R. Baklanov, D. Shamiryan, F. Iacopi, S.H. Brongersma, and Z.S. Yanovitskaya: Low dielectric constant materials for microelectronics. J. Appl. Phys. 93, 8793 (2003).
W. Volksen, R.D. Miller, and G. Dubois: Low dielectric constant materials. Chem. Rev. 110, 56 (2010).
G.D. Wilk, R.M. Wallace, and J.M. Anthony: High-k gate dielectrics: Current status and materials properties considerations. J. Appl. Phys. 89, 5243 (2001).
R.H. Dennard, F.H. Gaensslen, H.N. Yu, V.L. Rideout, E. Bassous, and A.R. LeBlanc: Design of ion-implanted MOSFETs with very small physical dimensions. IEEE J. Solid-State Circuits 9, 256 (1974).
J. Robertson: High dielectric constant gate oxides for metal oxide Si transistors. Rep. Prog. Phys. 69, 327 (2006).
G. Moore: Cramming more components onto integrated circuits. Electron. Mag. 38, 4 (1965).
C. Auth, A. Cappellani, J.-S. Chun, A. Dalis, A. Davis, T. Ghani, G. Glass, T. Glassman, M. Harper, M. Hattendorf, P. Hentges, S. Jaloviar, S. Joshi, J. Klaus, K. Kuhn, D. Lavric, M. Lu, H. Mariappan, K. Mistry, B. Norris, N. Rahhal-orabi, P. Ranade, J. Sandford, L. Shifren, V. Souw, K. Tone, F. Tambwe, A. Thompson, D. Towner, T. Troeger, P. Vandervoorn, C. Wallace, J. Wiedemer, and C. Wiegand: 45nm high-k + metal gate strain-enhanced transistors. In IEEE VLSI Technology Symposium, Honolulu, HI, 2008; p. 128.
G. Ribes, J. Mitard, M. Denais, S. Bruyere, F. Monsieur, C. Parthasarathy, E. Vincent, and G. Ghibaudo: Review on high-k dielectrics reliability issues. IEEE Trans. Device Mater. Reliab. 5, 5 (2005).
A. Kerber and E.A. Cartier: Reliability challenges for CMOS technology qualifications with hafnium oxide/titanium nitride gate stacks. IEEE Trans. Device Mater. Reliab. 9, 147 (2009).
G. Haase: A model for electric degradation of interconnect low-k dielectrics in microelectronic integrated circuits. J. Appl. Phys. 105, 44908 (2009).
K.J. Kuhn: Moore’s crystal ball: Device physics and technology past the 15 nm generation. Microelectron. Eng. 88, 1044 (2011).
International Technology Roadmap for Semiconductors (ITRS): 2009 (Semiconductor Industry Association, San Jose, CA, 2009). http://www.itrs.net/Links/2009ITRS/Home2009.htm.
Y. Ou, P. Wang, M. He, T. Lu, P. Leung, and T. Spooner: Conduction mechanisms of Ta/porous SiCOH films under electrical bias. J. Electrochem. Soc. 155, G283 (2008).
R. Wang, K. Chang-Liao, T. Wang, M. Chang, C. Wang, C. Lin, C. Lee, C. Chiu, and K. Wu: Electrical conduction and TDDB reliability characterization for low-k SiCO dielectric in Cu interconnects. Thin Solid Films 517, 1230 (2008).
Y.C. Yeo, T.J. King, and C. Hu: Dielectric tunneling leakage current and scalability of alternative gate dielectrics. Appl. Phys. Lett. 81, 2091 (2002).
Z. Xu, M. Houssa, S. De Gendt, and M. Heyns: Polarity effect on the temperature dependence of leakage current through HfO2/SiO2 gate dielectric stacks. Appl. Phys. Lett. 80, 1975 (2002).
C. Chiang, I. Ko, M. Chen, Z. Wu, Y. Lu, S. Jang, and M. Liang: Improvement in leakage current and breakdown field of Cu-comb capacitor using a silicon oxycarbide dielectric barrier. J. Electrochem. Soc. 151, G606 (2004).
F. Chen and M. Shinovsky: Soft breakdown characteristics of ultralow-k time dependent dielectric breakdown for advanced complementary metal-oxide semiconductor technologies. J. Appl. Phys. 108, 54107 (2010).
S. Lombardo, J.H. Stathis, B.P. Linder, K.L. Pey, F. Palumbo, and C.H. Tung: Dielectric breakdown mechanisms in gate oxides. J. Appl. Phys. 98, 121301 (2005).
J. McPherson: Time dependent dielectric breakdown physics–models revisited. Microelectron. Reliab. 52, 1753 (2012).
F. Chen and M. Shinovsky: Addressing Cu/low-k dielectric TDDB-reliability challenges for advanced CMOS technologies. IEEE Trans. Electron Devices 56, 2 (2009).
L. Zhao, M. Pantouvaki, K. Croes, Z. Tokei, Y. Barbarin, C. Wilson, M. Baklanov, G. Beyer, and C. Claeys: Role of copper in time dependent dielectric breakdown of porous organo-silicate glass low-k materials. Appl. Phys. Lett. 99, 222110 (2011).
T. Kauerauf, R. Degraeve, E. Cartier, C. Soens, and G. Groeseneken: Low Weibull slope of breakdown distributions in high-k layers. IEEE Electron Device Lett. 23, 215 (2002).
E. Rosenbaum and L.F. Register: Mechanism of stress-induced leakage current in MOS capacitors. IEEE Trans. Electron Devices 44, 317 (1997).
S. Pae, T. Ghani, M. Hattendorf, J. Hicks, J. Jopling, J. Maiz, K. Mistry, J. O’Donnell, C. Prasad, J. Wiedemer, and J. Xu: Characterization of SILC and its end-of-life reliability assessment on 45 nm high-k and metal-gate technology. In Proceedings of the IEEE International Reliability Physics Symposium, Montreal, QC (IEEE, 2009); p. 499.
X.J. Zhou, L. Tsetseris, S.N. Rashkeev, D.M. Fleetwood, R.D. Schrimpf, S.T. Pantelides, J.A. Felix, E.P. Gusev, and C. D’Emic: Negative bias-temperature instabilities in metal-oxide-silicon devices with SiO2 and SiOxNy/HfO2 gate dielectrics. Appl. Phys. Lett. 84, 4394 (2004).
A. Rahman, M. Agostinelli, P. Bai, G. Curello, H. Deshpande, W. Hafez, C-H. Jan, K. Komeyli, J. Park, K. Phoa, C. Tsai, J-Y. Yen, and J. Xu: Reliability studies of a 32 nm System-on-chip (SOC) platform technology with 2nd generation high-k/metal gate transistors. Proceedings of the IEEE International Reliability Physics Symposium, Monterey, CA (IEEE, 2011); p. 533.
J.L. Lauer, H. Sinha, M.T. Nichols, G.A. Antonelli, Y. Nishi, and J.L. Shohet: Charge trapping within UV and vacuum UV irradiated low-k porous organosilicate dielectrics. J. Electrochem. Soc. 157, G177 (2010).
J. Atkin, E. Cartier, T.M. Shaw, R.B. Laibowitz, and T.F. Heinz: Charge trapping at the low-k dielectric-silicon interface probed by the conductance and capacitance techniques. Appl. Phys. Lett. 93, 122902 (2008).
W.J. Zhu, T.P. Ma, and T. Tamagawa: Charge trapping in ultrathin hafnium oxide. IEEE Electron Device Lett. 23, 597 (2002).
M. Bargallo Gonzalez, J.M. Rafi, O. Beldarrain, M. Zabala, and F. Campabadal: Charge trapping analysis of Al2O3 films deposited by atomic layer deposition using H2O or O3 as oxidant. J. Vac. Sci. Technol., B 31, 1A101 (2013).
H. Sinha, M. Nichols, A. Sehgal, M. Tomoyasu, N. Russell, G. Antonelli, Y. Nishi, and J. Shohet: Effect of vacuum ultraviolet and ultraviolet irradiation on mobile charges in the bandgap of low-k-porous organosilicate dielectric. J. Vac. Sci. Technol. 29, 10601 (2011).
G. Bersuker, P. Zeitzoff, J.H. Sim, B.H. Lee, R. Choi, G. Brown, and C.D. Young: Mobility evaluation in transistors with charge-trapping gate dielectrics. Appl. Phys. Lett. 87, 42905 (2005).
V. Ligatchev, T.K.S. Wong, B. Liu, and Rusli: Atomic structure and defect densities in low dielectric constant carbon doped hydrogenated silicon oxide films, deposited by plasma-enhanced chemical vapor deposition. J. Appl. Phys. 92, 4605 (2002).
J.M. Atkin, D. Song. T.M. Shaw, E. Cartier, R.B. Laibowitz, and T.F. Heinz: Photocurrent spectroscopy of low-k dielectrics materials: Barrier heights and trap densities. J. Appl. Phys. 103, 94104 (2008).
J.M. Atkin, E. Cartier, T.M. Shaw, J.R. Lloyd, R.B. Laibowitz, and T.F. Heinz: The evolution of optical and electrical properties of low-k dielectrics under bias stress. Microelectron. Eng. 86, 1891 (2009).
G. Bersuker, J.H. Sim, C.D. Young, R. Choi, M. Zeitzoff, G.A. Brown, B.H. Lee, and R.W. Murto: Effect of pre-existing defects on reliability assessment of high-k gate dielectrics. Microelectron. Reliab. 44, 1509 (2004).
M. Houssa, M. Tuominen, M. Naili, V. Afanas’ev, A. Stesmans, S. Haukka, and M.M. Heyns: Trap-assisted tunneling in high permittivity gate dielectric stacks. J. Appl. Phys. 87, 8615 (2000).
E. Harrari and B.S.H. Royce: Trap structure of pyrolytic Al2O3 in MOS capacitors. Appl. Phys. Lett. 22, 106 (1973).
R. Ludeke, M.T. Cuberes, and E. Cartier: Local transport and trapping issues in Al2O3 gate oxide structures. Appl. Phys. Lett. 76, 2886 (2000).
M. Specht, M. Stadele, S. Jakschik, and U. Schroder: Transport mechanisms in atomic-layer-deposited Al2O3 dielectrics. Appl. Phys. Lett. 84, 3076 (2004).
O. Blank, H. Reisinger, R. Stengl, M. Gutsche, F. Wiest, V. Capodieci, J. Schulze, and I. Eisele: A model for multistep trap-assisted tunneling in thin high-k dielectrics. J. Appl. Phys. 97, 44107 (2005).
L. Sambuco-Salomone, J. Lipovetsky, S.H. Carbonetto, M.A. Garcia Inza, E.G. Redin, F. Campabadal, and A. Faigon: Experimental evidence and modeling of two types of electron traps in Al2O3 for nonvolatile memory applications. J. Appl. Phys. 113, 74501 (2013).
J.R. Chaves, R.A.B. Devine, and L. Koltunski: Evidence for hole and electron trapping in plasma deposited thin films. J. Appl. Phys. 90, 4284 (2001).
J.H. Stathis: Physical and predictive models of ultrathin oxide reliability in CMOS devices and circuits. IEEE Trans. Dev. Mater. Reliab. 1, 43 (2001).
P.M. Lenahan and J.F. Conley, Jr: What can electron paramagnetic resonance tell us about the Si/SiO2 system?. J. Vac. Sci. Technol., B 16, 2134 (1998).
L. Skuja: Optically active oxygen-deficiency-related centers in amorphous silicon dioxide. J. Non-Cryst. Solids 239, 16 (1998).
N.L. Anderson, R.P. Vedula, P.A. Schultz, R.M. Van Ginhoven, and A. Strachan: Defect level distributions and atomic relaxations induced by charge trapping in amorphous silica. Appl. Phys. Lett. 100, 172908 (2012).
M. Heyns and W. Tsai: Ultimate scaling of CMOS logic devices with Ge and III-V materials. MRS Bull. 34, 485 (2009).
K. Kim, J.Y. Choi, T. Kim, S.H. Cho, and H.J. Chung: A role for graphene in silicon-based semiconductor devices. Nature 479, 338 (2011).
R. Murali, K. Brenner, Y. Yang, T. Beck, and J.D. Meindl: Resistivity of graphene nanoribbon interconnects. IEEE Electron Device Lett. 30, 611 (2009).
X. Chen, D. Akinwande, K.J. Lee, G.F. Close, S. Yasuda, B.B. Paul, S. Fujita, J. Kong, and H.S. Philip Wong: Fully integrated graphene and carbon nanotube interconnects for gigahertz high-speed CMOS electronics. IEEE Trans. Electron Devices 57, 3137 (2010).
W. Tsai, N. Goel, S. Koveshnikov, P. Majhi, and W. Wang: Challenges of integration of high-k dielectrics with III-V materials. Microelectron. Eng. 86, 1540 (2009).
L. Lin and J. Robertson: Passivation of interfacial defects at III-V oxide interfaces. J. Vac. Sci. Technol., B 30, 4E101 (2012).
K. Nagashino, T. Yamashita, T. Nishimura, K. Kita and A. Tonumi: AU11 Electrical transport properties of graphene on SiO2 with specific surface structures. J. Appl. Phys. 110, 24513 (2011).
X.F. Fan, W.T. Zheng, V. Chihaia, Z.X. Shen, and J.L. Kuo: Interaction between graphene and the surface of SiO2. J. Phys. Condens. Matter 24, 305004 (2012).
V.C. Ngwan, C. Zhu, and A. Krishnamoorthy: Dependence of leakage mechanisms on dielectric barrier in Cu-SiOC damascene interconnects. Appl. Phys. Lett. 84, 2316 (2004).
K.Y. Yiang, W.J. Yoo, Q. Guo, and A. Krishnamoorthy: Investigation of electrical conduction in carbon-doped silicon oxide using a voltage ramp method. Appl. Phys. Lett. 83, 524 (2003).
G.G. Gischia, K. Croes, G. Groeseneken, Z. Tokei, V. Afanas’ev, and L. Zhao: Study of leakage mechanism and trap density in porous low-k materials. Proceedings of the IEEE International Reliability Physics Symposium, Anaheim, CA (IEEE, 2010); p. 539.
G. Jegert, A. Kersch, W. Weinreich, U. Schroder, and P. Lugli: Modeling of leakage currents in high-k dielectrics: Three dimensional approach via Monte Carlo. Appl. Phys. Lett. 96, 62113 (2010).
D. Ruiz Agaudo, B. Govoreanu, W. Dong Zhang, M. Jurczak, K. De Meyer, and J. Van Houdt: A novel trapping/detrapping model for defect profiling in high-k materials using the two-pulse capacitance-voltage technique. IEEE Trans. Electron Devices 57, 2726 (2010).
M. Wang, W. He, and T.P. Ma: Electron tunneling spectroscopy study of traps in high-k gate dielectrics: Determination of physical locations and energy levels of traps. Appl. Phys. Lett. 86, 192113 (2005).
Z. Liu and T.P. Ma: Determination of energy and spatial distributions of traps in ultrathin dielectrics by use of inelastic electron tunneling spectroscopy. Appl. Phys. Lett. 97, 172102 (2010).
R. Rao and F. Irrera: Detrapping dynamics in Al2O3 metal-oxide-semiconductor. J. Appl. Phys. 107, 103708 (2010).
C.C. Yeh, T.P. Ma, N. Ramaswamy, N. Rocklein, D. Gealy, T. Graettinger, and K. Min: Frenkel-Poole trap energy extraction of atomic layer deposited Al2O3 and HfxAlyO thin films. Appl. Phys. Lett. 91, 113521 (2007).
X.F. Zheng, W.D. Zhang, B. Govoreanu, J.F. Zhang, and J. van Houdt: A new multipulse technique for probing electron trap energy distribution in high-k materials for flash memory application. IEEE Trans. Elect. Dev. 57, 2484 (2010).
D.W. Winslow, J.P. Johnson, and C.C. Williams: Nanometer scale study of HfO2 trap states using single electron tunneling force spectroscopy. Appl. Phys. Lett. 98, 172903 (2011).
D.S. Jeong and C.S. Hwang: Tunneling-assisted Poole-Frenkel conduction mechanism in HfO2 thin films. J. Appl. Phys. 98, 113701 (2005).
S. Shamuilia, V. Afanas’ev, P. Somers, A. Stesmans, Y. Li, Z. Tokei, G. Groeseneken, and K. Maex: Internal photoemission of electrons at interfaces of metals with low-k insulators. Appl. Phys. Lett. 89, 202909 (2006).
K. Tanbara and Y. Kamigaki: Paramagnetic defect generation and microstructure change in porous low-k SiOCH films with vacuum baking. J. Electrochem. Soc. 157, G95 (2010).
H. Ren, M. Nichols, G. Jiang, G. Antonelli, Y. Nishi, and J. Shohet: Defects in low-k organosilicate glass and their response to processing as measured with electron-spin resonance. Appl. Phys. Lett. 98, 102903 (2011).
V. Afanas’ev, K. Keunen, A. Stesmans, M. Jivanescu, Z. Tokei, M. Baklanov, and G. Beyer: Electron spin resonance study of defects in low-k oxide insulators (k=2.5-2.0). Microelectron. Eng. 88, 1503 (2011).
A.Y. Kang, P.M. Lenahan, J.F. Conley Jr., and R. Solanki: Electron spin resonance study of interface defects in atomic layer deposited hafnium oxide on Si. Appl. Phys. Lett. 81, 1128 (2002).
A.Y. Kang, P.M. Lenahan, and J.F. Conley Jr.: Electron spin resonance observation of trapped electron centers in atomic layer deposited hafnium oxide on Si. Appl. Phys. Lett. 83, 3407 (2003).
P.M. Lenahan and J.F. Conley Jr.: Magnetic resonance studies of trapping centers in high-k dielectric films on silicon. IEEE Trans. Dev. Mater. Reliab. 5, 90 (2005).
T. Kanashima, K. Ikeda, T. Tada, M. Sohgawa, and M. Okuyama: Electron spin resonance characterization of defects in high-k HfO2 thin film prepared by pulsed laser deposition. J. Korean Phys. Soc. 46, 258 (2005).
B.B. Triplett, P.T. Chen, Y. Nishi, P.H. Kasai, J.J. Chambers, and L. Colombo: Electron spin resonance study of as-deposited and annealed (HfO2)x(SiO2)1-x high-k dielectrics on Si. J. Appl. Phys. Lett. 101, 13703 (2007).
R.C. Barklie and S. Wright: Electron paramagnetic resonance characterization of defects in HfO2 and ZrO2 powders and films. J. Vac. Sci. Technol., B 27, 317 (2009).
S. Wright and R.C. Barklie: Electron paramagnetic resonance characterization of defects in monoclinic HfO2 and ZrO2 powders. J. Appl. Phys. 106, 103917 (2009).
R.H. Bartram, C.E. Swenberg, and J.T. Fournier: Theory of trapped-hole centers in aluminum oxide. Phys. Rev. 139, 941 (1965).
S. Ciraci and I.P. Batra: Electronic structure of a-alumina and its defect states. Phys. Rev. B 28, 982 (1983).
G.J. Dienes, D.O. Welch, C.R. Fischer, R.D. Hatcher, O. Lazareth, and M. Samberg: Shell-model calculation of some point-defect properties in a-Al2O3. Phys. Rev. B 11, 3060 (1975).
A. Stashans, E. Kotomin, and J-L. Calais: Calculations of the ground and excited states of F-type centers in corundum crystal. Phys. Rev. B 49, 14854 (1994).
Y-N. Xu, Z-Q. Gu, Z-F. Zhong, and W.Y. Ching: Ab-initio calculations for the neutral and charged O vacancy in sapphire. Phys. Rev. B 56, 7277 (1997).
K. Matsunaga, T. Tanaka, T. Yamamoto, and Y. Ikuhara: First principles calculations of intrinsic defects in Al2O’3. Phys. Rev. B 68, 85110 (2003).
J. Carrasco, J.R.B. Gomes, and F. Illas: Theoretical study of bulk and surface oxygen and aluminum vacancies in a-Al2O3. Phys. Rev. B 69, 64116 (2004).
D. Liu, S.J. Clark, and J. Robertson: Oxygen vacancy levels and electron transport in Al2O3. Appl. Phys. Lett. 96, 32905 (2010).
J.R. Weber, A. Janotti, and C.G. Van de Walle: Native defects in Al2O3 and their impact on III-V/Al2O3 metal-oxide-semiconductor-based devices. J. Appl. Phys. 109, 33715 (2011).
M. Choi, A. Janotti, and C. Van de Walle: Native point defects and dangling bonds in a-Al2O3. J. Appl. Phys. 113, 44501 (2013).
J. Kang, E-C. Lee, K.J. Chang, and Y-G. Jin: H-related defect complexes in HfO2: A model for positive fixed charge defects. Appl. Phys. Lett. 84, 3894 (2004).
J.L. Gavartin, D. Munoz Ramo, A.L. Shluger, G. Bersuker, and B.H. Lee: Negative oxygen vacancies in HfO2 as charge traps in high-k stacks. Appl. Phys. Lett. 89, 82908 (2006).
K. Xiong, J. Robertson, M.C. Gibson, and S.J. Clark: Defect energy levels in HfO2 high-dielectric-constant gate oxide. Appl. Phys. Lett. 87, 183505 (2005).
Y.P. Feng, A.T.L. Lim, and M.F. Li: Negative-U property of oxygen vacancy in cubic HfO2. Appl. Phys. Lett. 67, 62105 (2005).
R. Gillen, J. Robertson, and S.J. Clark: Electron spin resonance signature of the oxygen vacancy in HfO2. Appl. Phys. Lett. 101, 102904 (2012).
D.M. Ramo, A.L. Shluger, J.L. Gavartin, and G. Bersuker: Theoretical prediction of intrinsic self-trapping of electrons and holes in monoclinic HfO2. Phys. Rev. Lett. 99, 155504 (2007).
D. Ramo, J.L. Gavartin, A.L. Shluger, and G. Bersuker: Spectroscopic properties of oxygen vacancies in monoclinic HfO2 calculated with periodic and embedded cluster density functional theory. Phys. Rev. B 75, 205336 (2007).
D.M. Ramo, P.V. Sushko, J.L. Gavartin, and A.L. Shluger: Oxygen vacancies in cubic ZrO2 nanocrystals studied by an ab initio embedded cluster method. Phys. Rev. B 78, 235432 (2008).
T.J. Chen and C.L. Kuo: First principles study of the oxygen vacancy formation and the induced defect states in hafnium silicates. J. Appl. Phys. 111, 74106 (2012).
A.S. Foster, V.B. Sulimov, F. Lopez Gejo, A.L. Shluger, and R.M. Nieminen: Structure and electrical levels of point defects in monoclinic zirconia. Phys. Rev. B 64, 224108 (2001).
J.X. Zheng, G. Ceder, T. Maxisch, W.K. Chim, and W.K. Choi: First-principles study of native point defects in hafnia and zirconia. Phys. Rev. B 75, 104112 (2007).
J. Robertson, K. Xiong, and B. Falabretti: Point defects in ZrO2 high-k gate oxide. IEEE Trans. Dev. Mater. Reliab. 5, 84 (2005).
C.R.A. Catlow, R. James, W.C. Mackrodt, and R.F. Stewart: Defects energetics in a-Al2O3 and rutile TiO2. Phys. Rev. B 25, 1006 (1982).
N. Yu and J. Woods Halley: Electronic structure of point defects in rutile TiO2. Phys. Rev. B 51, 4768 (1995).
S. Na-Phtattalung, M.F. Smith, K. Kim, M-H. Du, S-H. Wei, S.B. Zhang, and S. Limpijumnong: First-principles study of native defects in anatase TiO2. Phys. Rev. B 73, 125205 (2006).
M. Nolan, S.D. Elliott, J.S. Mulley, R.A. Bennett, M. Basham, and P. Mulheran: Electronic structure of point defects in controlled self-doping of the TiO2 (110) surface: Combined photoemission spectroscopy and density functional theory study. Phys. Rev. B 77, 235424 (2008).
R.H. French: Electronic band structure of Al2O3, with comparison to AlON and AlN. J. Amer. Ceram. Soc. 73, 477 (1990).
E. Bersch, S. Rangan, R.A. Bartynski, E. Garfunkel, and E. Vescovo: Band offsets of ultrathin high-k oxide films with Si. Phys. Rev. B 78, 85114 (2008).
K.H. Lee and J.H. Crawford Jr.: Electron centers in single crystal Al2O3. Phys. Rev. B 15, 4065 (1977).
B.D. Evans: Optical transmission in undoped crystalline a-Al2O3 grown by several techniques. J. Appl. Phys. 70, 3995 (1991).
H. Takeuchi, D. Ha, and T.J. King: Observation of bulk HfO2 defects by spectroscopic ellipsometry. J. Vac. Sci. Technol., A 22, 1337 (2004).
N.V. Nguyen, A.V. Davydov, D. Chandler-Horowitz, and M.M. Frank: Sub-bandgap defect states in polycrystalline hafnium oxide and their suppression by admixture of silicon. Appl. Phys. Lett. 87, 192903 (2005).
J. Price, G. Bersuker, and P.S. Lysaght: Identification of interfacial defects in high-k gate stack films by spectroscopic ellipsometry. J. Vac. Sci. Technol., B 27, 310 (2009).
A. Stesmans and V.V. Afanas’ev: Si dangling-bond-defects at the interface of (100) Si with ultrathin layers of SiOx, Al2O3, and ZrO2. Appl. Phys. Lett. 80, 1957 (2002).
A. Stesmans and V.V. Afanas’ev: Si dangling-bond-type defects at the interface of (100) Si with ultrathin HfO2. Appl. Phys. Lett. 82, 4074 (2003).
A. Stesmans, V.V. Afanas’ev, F. Chen, and S.A. Campbell: Paramagnetic NO2 centers in thin ?-irradiated HfO2 layers on (100)Si revealed by electron spin resonance. Appl. Phys. Lett. 84, 4574 (2004).
A. Stesmans, K. Clemer, and V.V. Afanas’ev: P-associated defects in the high-k insulators HfO2 and ZrO2 revealed by electron spin resonance. Phys. Rev. B 77, 125241 (2008).
B.G. Draeger and G.P. Summers: Defects in unirradiated a-Al2O3. Phys. Rev. B 19, 1172 (1979).
R.C. DuVarney, A.K. Garrison, J.R. Nilas, and M. Spaeth: Electron-nuclear double resonance of the F+ center in a-alumina. Phys. Rev. B 24, 3693 (1981).
M. Vilmay, D. Roy, F. Volpi, and J-M. Chaix: Characterization of low-k SiOCH dielectric for 45 nm technology and link between the dominant leakage path and the breakdown localization. Microelectron. Eng. 85, 2075 (2008).
J.M. Atkin, T.M. Shaw, E. Liniger, R.B. Laibowitz, and T.F. Heinz: The effect of voltage bias stress on temperature-dependent conduction properties of low-k dielectrics. IEEE International Reliability Physics Symposium, Anaheim, CA (IEEE, 2012); p. BD.1.1.
M. Baklanov, L. Zhao, E. Van Besien, and M. Pantouvaki: Effect of porogen residue on electrical characteristics of ultra low-k material. Microelectron. Eng. 88, 990 (2011).
B. Bittel, P. Lenahan, and S. King: Ultraviolet radiation effects on paramagnetic defects in low-k dielectrics for ultralarge scale integrated circuit interconnects. Appl. Phys. Lett. 97, 63506 (2010).
H. Sinha, G. Antonelli, G. Jiang, Y. Nishi, and J. Shohet: Effects of vacuum ultraviolet radiation on deposited and ultraviolet-cured low-k porous organosilicate glass. J. Vac. Sci. Technol., A 29, 30602 (2011).
H. Ren, G. Jiang, G. Antonelli, Y. Nishi, and J. Shohet: The nature of the defects generated from plasma exposure in pristine and ultraviolet-cured low-k organosilicate glass. Appl. Phys. Lett. 98, 252902 (2011).
M. Nichols, H. Sinha, C. Wiltbank, G. Antonelli, Y. Nishi, and J. Shohet: Time-dependent dielectric breakdown of plasma-exposed porous organosilicate glass. Appl. Phys. Lett. 100, 112905 (2012).
H. Sinha, H. Ren, M.T. Nichols, J.L. Lauer, M. Tomoyasu, N.M. Russell, G. Jiang, G.A. Antonelli, N.C. Fuller, S.U. Engelmann, Q. Lin, V. Ryan, Y. Nishi, and J.L. Shohet: The effects of vacuum ultraviolet radiation on low-k dielectric films. J. Appl. Phys. 112, 111101 (2012).
S. Miyazaki: Photoemission study of energy-band alignments and gap state density distributions for high-k gate dielectrics. J. Vac. Sci. Technol., B 19, 2212 (2001).
N. Ikarashi, M. Miyamura, K. Masuzaki, and T. Tatsumi: Electron energy-loss spectroscopy analysis of the electronic structure of nitrided Hf silicate films. Appl. Phys. Lett. 84, 2672 (2004).
Y. Kamimuta, M. Koike, T. Ino, M. Suzuki, M. Koyama, Y. Tsunashima, and A. Nishiyama: Determination of band alignment of hafnium silicon oxynitride/silicon (HfSiON/Si) structures using electron spectroscopy. Jpn. J. Appl. Phys. 44, 1301 (2005).
M. Koike, T. Ino, Y. Kamimuta, M. Koyama, Y. Kamata, M. Suzuki, Y. Mitani, and A. Nishiyama: Dielectric properties of noncrystalline HfSiON. Phys. Rev. B 73, 125123 (2006).
H. Jin, S.K. Oh, H.J. Kang, and M.H. Cho: Band gap and band offsets for ultrathin (HfO2)x(SiO2)1-x dielectric films on Si (100). Appl. Phys. Lett. 89, 122901 (2006).
C.J. Yim, D.H. Ko, M.H. Jang, K.B. Chung, M.H. Cho, and H.T. Jeon: Change in band alignment of HfO2 films with annealing treatments. Appl. Phys. Lett. 92, 12922 (2008).
S. Swaminathan, Y. Sun, P. Pianetta, and P.C. McIntyre: Ultrathin ALD-Al2O3 layers for Ge (001) gate stacks: Local composition evolution and dielectric properties. J. Appl. Phys. 110, 94105 (2011).
S. King, M. French, M. Jaehnig, M. Kuhn, B. Boyanov, and B. French: X-ray photoelectron spectroscopy measurement of the Schottky barrier at the SiC(N)/Cu interface. J. Vac. Sci. Technol., B 29, 51207 (2011).
S. King, M. French, M. Jaehnig, M. Kunh, and B. French: X-ray photoelectron spectroscopy investigation of the Schottky barrier at low-k a-SiO(C):H/Cu interfaces. Appl. Phys. Lett. 99, 202903 (2011).
S.W. King, M. French, J. Bielefeld, M. Jaehnig, M. Kuhn, G. Xu, and B. French: Valence band offset at the amorphous hydrogenated boron nitride silicon (100) interface. Appl. Phys. Lett. 101, 42903 (2012).
S.W. King, B. French, and E. Mays: Detection of defect states in low-k dielectrics using reflection electron energy loss spectroscopy. J. Appl. Phys. 113, 44109 (2013).
F. Bart, M. Gautier, J. Duraud, and M. Henriot: (01-10) a-quartz: A LEED, XANES and ELS study. Surf. Sci. 274, 317 (1992).
F. Bart, M. Gautier, F. Jollet, and J. Duraud: Electronic structure of the (0001) and (10-10) quartz surfaces and of their defects as observed by reflection electron energy loss spectroscopy (REELS). Surf. Sci. 306, 342 (1994).
P. Poveda and A. Glachant: Energy gap-determination of a carbon contaminated thermal silicon oxide thin film using reflection electron energy loss spectroscopy. J. Non-Cryst. Solids 216, 83 (1997).
P. Poveda and A. Glachant: Low energy electron-beam-enhanced formation of ultrathin insulating silicon oxynitride layers on Si(100) at moderate temperatures: In situ determination of the band gap energy using electron energy loss spectroscopy. Surf. Sci. 323, 258 (1995).
C. Morant, A. Fernandez, A.R. Gonzales-Elipe, L. Soriano, A. Stampfl, A.M. Bradshaw, and J.M. Sanz: Electronic structure of stoichiometric Ar+-bombarded ZrO2 determined by resonant photoemission. Phys. Rev. B 52, 11711 (1995).
M.A. Schildbach and A.V. Hamza: Sapphire (11-20) surface: Structure and laser-induced desorption of aluminum. Phys. Rev. B 45, 6197 (1992).
J. Olivier and R. Poirier: Electronic structure of Al2O3 from electron energy loss spectroscopy. Surf. Sci. 105, 347 (1981).
M. Gautier, J.P. Duraud, L. Pham Van, and M.J. Guittet: Modifications of a-Al2O3 (0001) surfaces induced by thermal treatments or ion bombardment. Surf. Sci. 250, 71 (1991).
W.J. Gignac, R. Williams, and S. Kowalczyk: Valence-and conduction-band structure of the sapphire (1-102) surface. Phys. Rev. B 32, 1237 (1985).
M-C. Wu, C.M. Truong, and D.W. Goodman: Electron-energy-loss-spectroscopy studies of thermally generated defects in pure and lithium-doped MgO(100) films on Mo(100). Phys. Rev. B 46, 12688 (1992).
S. King and J. Gradner: Intrinsic stress fracture energy measurements for PECVD thin films in the SiOxCyNz:H system. Microelectron. Reliab. 49, 721 (2009).
S. King, D. Jacob, D. Vanleuven, B. Colvin, J. Kelly, M. French, J. Bielefeld, D. Dutta, M. Liu, and D. Gidley: Film property requirements for hermetic low-k a-SiOxCyNz:H dielectric barriers. ECS J. Solid State Sci. Technol. 1, N115 (2012).
S. King, R. Chu, G. Xu, and J. Huening: Intrinsic stress effect on fracture toughness of plasma enhanced chemical vapor deposited SiNx:H films. Thin Solid Films 518, 4898 (2010).
E. Andideh, M. Lerner, G. Palmrose, S. El-Mansy, T. Scherban, G. Xu, and J. Blaine: Compositional effects on electrical and mechanical properties in carbon-doped oxide dielectric films: Application of Fourier-transform infrared spectroscopy. J. Vac. Sci. Technol., B 22, 196 (2004).
V. Jousseaume, A. Zenasni, L. Favennec, G. Gerbaud, M. Bardet, J.P. Simon, and A. Humbert: Comparison between e-beam and ultraviolet curing to perform porous a-SiOC: H. J. Electrochem. Soc. 154, G103 (2007).
S. Bailey, E. Mays, D.J. Michalak, R. Chebiam, S. King, and R. Sooryakumar: Mechanical properties of high porosity low-k dielectric nano-films determined by Brillouin light scattering. J. Phys. D: Appl. Phys. 46, 45308 (2013).
V. Miikkulainen, M. Leskela, M. Ritala, and R. Puurunen: Crystallinity of inorganic films grown by atomic layer deposition: Overview and general trends. J. Appl. Phys. 113, 21301 (2013).
H. Kim, H.B.R. Lee, and W.J. Maeng: Applications of atomic layer deposition to nanofabrication and emerging nanodevices. Thin Solid Films 517, 2563 (2009).
C.J. Powell and A. Jablonski: Nist Electron Effective-Attenuation-Length Database, Version 1.3 (SRD 82), (NIST, Gaithersburg, MD, 2011).
W.M. Haynes, ed.: Crc Handbook of Physics and Chemistry, 93rd ed., W.M. Haynes (CRC Press, Boca Raton, FL, 2012).
A. Zangwill: Physics at Surfaces (Cambridge University Press, New York, 1988).
A. Jablonski and C.J. Powell: The electron attenuation length revisited. Surf. Sci. Rep. 47, 33 (2002).
C. Pantano and T. Madey: Electron beam damage in Auger electron spectroscopy. Appl. Surf. Sci. 7, 115 (1981).
R. Zallen: The Physics of Amorphous Solids (Wiley-Interscience, New York, 1983).
T. Mok and S. O’Leary: The dependence of the Tauc and Cody optical gaps associated with hydrogenated amorphous silicon on film thickness: αI experimental limitations and the impact of curvature in the Tauc and Cody plots. J. Appl. Phys. 102, 113525 (2007).
Z. Weinberg, G. Rubloff, and E. Bassous: Transmission, photoconductivity, and the experimental band gap of thermally gown SiO2 films. Phys. Rev. B 19, 3107 (1979)
T. DiStefano and D. Eastman: The band edge of amorphous SiO2 by photoinjection and photoconductance measurements. Solid State Commun. 9, 2259 (1971).
E. O’Reilly and J. Robertson: Theory of defects in vitreous silicon dioxide. Phys. Rev. B 27, 3780 (1983).
A. Rudenko, F. Keil, M. Katsnelson, and A. Lichtenstein: Interfacial interactions between local defects in amorphous SiO2 and supported graphene. Phys. Rev. B 84, 85438 (2011).
E.K. Chang, M. Rohlfing, and S.G. Louie: Excitons and optical properties of a-quartz. Phys. Rev. Lett. 85, 2613 (2000).
L. Skuja, K. Kajihara, Y. Ikuta, M. Hirano, and H. Hosono: Urbach absorption edge of silica: Reduction of glassy disorder by fluorine doping. J. Non-Cryst. Solids 345–346, 328 (2004).
K. Saito and A.J. Ikushima: Absorption edge in silica glass. Phys. Rev. B 62, 8584 (2000).
S.C. Cheng, S.L. Schiefelbein, L.A. Moore, M. Pierson-Stull, C.M. Smith, and S. Sen: Use of EELS to study the absorption edge of fused silica. J. Non-Cryst. Solids 352, 3140 (2006).
B. Sadigh, P. Erhart, D. Aberg, A. Trave, E. Schwegler, and J. Bude: First-principles calculations of the Urbach tail in the optical absorption spectra of silica glass. Phys. Rev. Lett. 106, 027401 (2011).
D.J. Dunstan: Evidence for a common origin of the Urbach tails in amorphous and crystalline semiconductors. J. Phys. C: Solid State Phys. 30, L419 (1982).
D.A. Drabold, Y. Li, B. Cai, and M. Zhang: Urbach tails of amorphous silicon. Phys. Rev. B 83, 045201 (2011).
I.A. Vainshtein, A.F. Zatsepin, V.S. Kortov, and V. Yu Shchapova: The urbach rule for the PbO–SiO2 Glasses. Fizika Tverdogo Tela 42, 224 (2000).
Y. Pan, F. Inam, M. Zhang, and D.A. Drabold: Atomistic origin of Urbach tails in amorphous silicon. Phys. Rev. Lett. 100, 206403 (2008).
A. Alkauskas, P. Broqvist, and A. Pasquarello: Alignment of defect energy levels at SiSiO2 interface from hybrid density functional calculations. AIP Conference Proceedings, Vol. 1199 2010; p. 79.
M. Tamaoki, K. Nishiki, A. Shimazaki, Y. Sasaki, and S. Yanagi: The effect of airborne contaminants in the cleanroom for ULSI manufacturing process. IEEE/SEMI Advanced Semiconductor Manufacturing Conference and Workshop, Cambridge, MA (IEEE, 1995); p. 322.
U. Zammit, F. Gasparrini, M. Marinelli, R. Pizzoferrato, A. Agostini, and F. Mercuri: Ion dose effect in subgap absorption spectra of defects in ion implanted GaAs and Si. J. Appl. Phys. 70, 7060 (1991).
S.T. Sundari: Optical absorption in Ar+ irradiated silicon studied through spectroscopic ellipsometry. Nucl. Instrum. Methods Phys. Res., Sect. B 215, 157 (2004).
G.P. Lopinski and J.S. Lannin: High resolution electron energy loss spectroscopy: A new probe of subgap absorption in amorphous solids. Appl. Phys. Lett. 69, 2400 (1996).
M. Worsley, S. Bent, N. Fuller, T. Tai, J. Doyle, M. Rothwell, and T. Dalton: Effect of radical species density and ion bombardment during ashing of extreme ultralow-k interlevel dielectric materials. J. Appl. Phys. 101, 13305 (2007).
J. Bao, H. Shi, H. Huang, P. Ho, M. Goodner, M. Moinpour, and G. Kloster: Mechanistic study of plasma damage of low k dielectric surfaces. J. Vac. Sci. Technol., B 26, 219 (2008).
H. Yamamoto, K. Asano, K. Ishikawa, M. Sekine, H. Hayashi, I. Sakai, T. Ohiwa, K. Takeda, H. Kondo, and M. Hori: Chemical bond modification in porous SiOCH films by H2 and H2/N2 plasmas investigated by in situ infrared reflection absorption spectroscopy. J. Appl. Phys. 110, 123301 (2011).
D. Tahir, H.L. Kwon, H.C. Shin, S.K. Oh, H.J. Kang, S. Heo, J.G. Chung, J.C. Lee, and S. Tougaard: Electronic and optical properties of Al2O3/SiO2 thin films grown on Si substrate. J. Phys. D: Appl. Phys. 43, 255301 (2010).
R. Degraeve, M. Cho, B. Govoreanu, B. Kaczer, M.B. Zahid, J. Van Houdt, M. Jurczak, and G. Groeseneken: Trap spectroscopy by charge injection and sensing (TSCIS): A quantitative electrical technique for studying defects in dielectric stacks. IEEE Electron Devices Meeting, 2008. DOI: 10.1109/IEDM.2008.4796812
M.L. Huang, Y.C. Chang, Y.H. Chang, T.D. Lin, J. Kwo, and M. Hong: Energy-band parameters of atomic layer deposited Al2O3 and HfO2 on InxGa1-xAs. Appl. Phys. Lett. 94, 052106 (2009).
S. Miyazaki: Characterization of high-k gate dielectric/silicon interfaces. Appl. Surf. Sci. 190, 66 (2002).
I. Geppert, M. Eizenberg, A. Ali, and S. Datta: Band offsets determination and interfacial chemical properties of the Al2O3/GaSb system. Appl. Phys. Lett. 97, 162109 (2010).
M.A. Henderson, W.S. Epling, C.H.F. Peden, and C.L. Perkins: Insights into photoexcited electron scavenging processes on TiO2 obtained from studies of the reaction of O2 with OH groups adsorbed at electronic defects on TiO2(110). J. Phys. Chem. B 107, 534 (2003).
C. Di Valentin and G. Pacchioni: Electronic structure of defect states in hydroxylated and reduced rutile TiO2110Surfaces. Phys. Rev. Lett. 97, 166803 (2006).
M. Landmann, E. Rauls, and W.G. Schmidt: The electronic structure and optical response of rutile, anatase and brookite TiO2. J. Phys. Condens. Matter 24, 195503 (2012).
R.H. French, S.J. Glass, F.S. Ohuchi, Y.N. Xu, and W.Y. Ching: Experimental and theoretical determination of the electronic structure and optical properties of three phases of ZrO2. Phys. Rev. B 49, 5133 (1994).
H. Jin, S.K. Oh, H.J. Kang, and S. Tougaard: Electronic properties of ultrathin HfO2, Al2O3, and Hf–Al–O dielectric films on Si(100) studied by quantitative analysis of reflection electron energy loss spectra. J. Appl. Phys. 100, 083713 (2006).
M.H. Jang, K.S. Jeong, K.B. Chung, J.W. Lee, M.H. Lee, and M.H. Cho: Effect of nitrogen incorporation and oxygen vacancy on electronic structure and the absence of a gap state in HfSiO films. Surf. Sci. 606, L64 (2012).
K. Xiong and J. Robertson: Point defects in HfO2 high K gate oxide. Microelectronic Eng. 80, 408 (2005).
A.S. Foster, F. Lopez Gejo, A.L. Shluger, and R.M. Nieminen: Vacancy and interstitial defects in hafnia. Phys. Rev. B 65, 174117 (2002).
Author information
Authors and Affiliations
Additional information
Address all correspondence to this author.
This paper has been selected as an Invited Feature Paper.
Rights and permissions
About this article
Cite this article
French, B.L., King, S.W. Detection of surface electronic defect states in low and high-k dielectrics using reflection electron energy loss spectroscopy. Journal of Materials Research 28, 2771–2784 (2013). https://doi.org/10.1557/jmr.2013.274
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1557/jmr.2013.274