Skip to main content
SpringerLink
Log in

Photoinduced formation of thin-film structures in titanium alkoxides via direct deposition from solution and from spin-coated solid-state precursor films

  • Published:
Journal of Materials Research Aims and scope Submit manuscript

Abstract

The photoinduced formation of thin film structures from a Ti-alkoxide precursor (OPy)2Ti(TAP)2, where OPy = OC6H6N, TAP = OC6H2[CH2N(CH3)2]3-2,4,6, was demonstrated via direct deposition from a pyridine-based solution and by optical illumination of a solid-state spin-coated thin film of the compound. Photopatterned physical relief structures were produced using both of these deposition methods and feature sizes as small as ∼1 μm were readily achieved. Surface investigations of the material’s nanostructure revealed that films photo-deposited from solution exhibited nanometer-scale surface roughness with evenly distributed surface porosity (∼10 nm sized pores) while films produced through the illumination of spin-coated thin films exhibited, in comparison, a reduction in surface roughness. Vibrational spectra were compared with the results of quantum chemical computations (density-functional theory) of potential photoproducts in an attempt to identify and distinguish the dominant structural groups resulting from the optical processing of each precursor form (i.e., solution versus solid-state). It was determined that ultraviolet irradiation for both thin-film formation techniques resulted in a disruption of the ligand groups, facilitating the initiation of hydrolysis and condensation reactions in the films.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

FIG. 1.
FIG. 2.
FIG. 3.
TABLE I.
FIG. 4.
FIG. 5.
FIG. 6.
FIG. 7.
FIG. 8.
FIG. 9.
FIG. 10.
FIG. 11.

Similar content being viewed by others

References

  1. H. Scmidt, H. Krug, R. Kasemann, and F. Tiefensee: Development of optical wave guide by sol-gel techniques for laser patterning. SPIE 1590, 36 (1991).

    Google Scholar 

  2. S. Najafi, T. Touam, R. Sara, M.P. Andrews, and M.A. Fardad: Sol-gel glass waveguide and grating on silicon. J. Lightwave Technol. 16, 1640 (1998).

    Article  CAS  Google Scholar 

  3. N. Tohge, R. Ueno, F. Chiba, K. Kintaka, and J. Nishii: Characteristics of diffraction gratings fabricated by the two-beam interference method using photosensitive hybrid gel films. J. Sol-Gel Sci. Technol. 19, 119 (2000).

    Article  CAS  Google Scholar 

  4. N. Tohge, G. Zhao, and F. Chiba: Photosensitive gel films prepared by the chemical modification and their application to surface-relief gratings. Thin Solid Films 351, 85 (1999).

    Article  CAS  Google Scholar 

  5. M.R. Riley, D. DeRosa, J. Blaine, B.G. Potter Jr., P. Lucas, D. Le Coq, C. Juncker, D.E. Boesewetter, J.M. Collier, C. Boussard-Pledel, and B. Bureau: Biologically inspired sensing: Infrared spectroscopic analysis of cell responses to an inhalation health hazard. Biotechnol. Progr. 22, 24 (2006).

    Article  CAS  Google Scholar 

  6. Z.V. Schneider, K. Simmons-Potter, and T.J. Boyle: Photomodification of heteroleptic titanium-based, complex metal alkoxides. J. Non-Cryst. Solids 355, 536 (2009).

    Article  CAS  Google Scholar 

  7. K. Tadanaga, T. Owan, J. Morinaga, S. Urbanek, and T. Minami: Fine patterning of transparent, conductive SnO2 thin films by UV-irradiation. J. Sol-Gel Sci. Technol. 19, 791 (2000).

    Article  CAS  Google Scholar 

  8. T. Imao, D. Hazama, N. Noma, and S. Ito: Photopatterning of titanium oxide gel films prepared from titanium alkoxide modified with hydroxl-substituted aromatic ketones. J. Ceram. Soc. Jpn. 114, 238 (2006).

    Article  CAS  Google Scholar 

  9. K. Kikuta, K. Takagi, and S. Hirano: Photoreaction of titanium-based metal-organic compounds for ceramic fine patterning. J. Am. Ceram. Soc. 82, 1569 (1999).

    Article  CAS  Google Scholar 

  10. N. Noma, S. Yamazaki, and N. Tohge: Preparation of new photosensitive ZrO2 gel films using hydroxyl-substituted aromatic ketones as chemical modification reagents and their patterning. J. Sol-Gel Sci. Technol. 31, 253 (2004).

    Article  CAS  Google Scholar 

  11. K. Shinmou, N. Tohge, and T. Minami: Fine-patterning of ZrO2 thin films by the photolysis of chemically modified gel films. Jpn. J. Appl. Phys. 33, L1181 (1994).

    Article  CAS  Google Scholar 

  12. H. Segawa, S. Adachi, Y. Arai, and K. Yoshida: Fine patterning of hybrid titania films by ultraviolet irradiation. J. Am. Ceram. Soc. 86, 761 (2003).

    Article  CAS  Google Scholar 

  13. T. Imao, T. Horiuchi, N. Noma, and S. Ito: Preparation of new photosensitive TiO2 gel films using chemical additives including nitrogen and their patterning. J. Sol-Gel Sci. Technol. 39, 119 (2006).

    Article  CAS  Google Scholar 

  14. H. Segawa, K. Tateishi, Y. Arai, K. Yoshida, and H. Kaji: Patterning of hybrid titania film using photopolymerization. Thin Solid Films 466, 48 (2004).

    Article  CAS  Google Scholar 

  15. J.D. Musgraves, B.G. Potter Jr., R.M. Sewell, and T.J. Boyle: Photo-induced structural changes in titanium alkoxides for directing molecular assembly, in Self Assembly of Nanostructures Aided by Ion- or Photon-Beam Irradiation—Fundamentals and Applications, edited by R. Kalyanaraman, U. Valbusa, and Z. Zhang (Mater. Res. Soc. Symp. Proc. 960E, Warrendale, PA, 2007), p. N05–03.

    Google Scholar 

  16. J.D. Musgraves, B.G. Potter Jr., R.M. Sewell, and T.J. Boyle: Preferential photostructural modification of heteroleptic titanium alkoxides for molecular assembly. J. Mater. Res. 22, 1694 (2007).

    Article  CAS  Google Scholar 

  17. J.D. Musgraves, B.G. Potter Jr., and T.J. Boyle: Direct fabrication of physical relief structures via patterned photodeposition of a titanium alkoxide solution. Opt. Lett. 33, 1306 (2008).

    Article  CAS  Google Scholar 

  18. B.G. Potter Jr., J.D. Musgraves, and T.J. Boyle: Photo-initiation of intermolecular bonding and oxide deposition in Ti-based alkoxide solutions. J. Non-Cryst. Solids 354, 2017 (2008).

    Article  CAS  Google Scholar 

  19. J.D. Musgraves, B.G. Potter Jr., and T.J. Boyle: Nanostructure development in photodeposited, titania-based thin films. J. Mater. Res. 24, 3372 (2009).

    Article  CAS  Google Scholar 

  20. T.J. Boyle, R.M. Sewell, L.A.M. Ottley, H.D. Pratt, C.J. Quintana, and S.D. Bunge: Controlled synthesis of a structurally characterized family of sterically constrained heterocyclic alkoxy-modified titanium alkoxides. J. Inorg. Chem. 46, 1825 (2007).

    Article  CAS  Google Scholar 

Download references

ACKNOWLEDGMENTS

This research was supported by the United States Department of Energy, Office of Basic Energy Sciences. Partial support was also provided by the University of Arizona, State of Arizona, TRIF Optics Initiative program and by Sandia National Laboratories. Sandia is a multi-program laboratory operated by Sandia Corporation, a Lockheed Martin Company for the United States Department of Energy’s National Nuclear Security Administration under Contract No. DE-AC04-94AL85000.

Author information

Authors and Affiliations

  1. University of Arizona, Tucson, Arizona, 85721-0104, USA

    Z.V. Schneider, J.D. Musgraves, K. Simmons-Potter & B.G. Potter

  2. Sandia National Laboratories, Advanced Materials Laboratory, Albuquerque, New Mexico, 87106, USA

    T.J. Boyle Jr.

Authors
  1. Z.V. Schneider
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. J.D. Musgraves
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. K. Simmons-Potter
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. B.G. Potter
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. T.J. Boyle Jr.
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to K. Simmons-Potter.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Schneider, Z., Musgraves, J., Simmons-Potter, K. et al. Photoinduced formation of thin-film structures in titanium alkoxides via direct deposition from solution and from spin-coated solid-state precursor films. Journal of Materials Research 26, 754–762 (2011). https://doi.org/10.1557/jmr.2010.34

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1557/jmr.2010.34

Search

Navigation