Fabrication of c-axis oriented higher manganese silicide by a high-magnetic-field and its thermoelectric properties

Abstract

We report the preparation and thermoelectric properties of oriented higher manganese silicide (HMS) with a composition of MnSi1.73 bulk. The grain alignment and densification were achieved by rotating high magnetic field and spark plasma sintering (SPS) techniques, respectively. The easy magnetization axis of MnSi1.73 was found to be c-axis, and the applied magnetic field of 2 T was strong enough to rotate the powder with a mean grain size of 1 μm. The c-axis of grains was oriented when applying the magnetic field, and the degree of orientation was further increased after heat treatment. However, a secondary phase that was mono manganese silicide (MnSi) was observed as a result of oxidation on the surface of synthesized powder. The electrical conductivity of the c-axis oriented specimen along the ab-plane was about 40% larger than that for sample processed only by SPS, while the Seebeck coefficient of oriented and nonoriented specimens showed similar values regardless of existence of the second phase. Consequently, the power factor of the c-axis oriented specimen along the ab-plane was enhanced by about 35% compared to the nonoriented one. The proposed approach is found to be very effective not only in obtaining the oriented materials with nonductility but also in enhancing the thermoelectricity.

This is a preview of subscription content, access via your institution.

FIG. 1
TABLE I.
FIG. 2
FIG. 3
FIG. 4
FIG. 5
FIG. 6
FIG. 7
FIG. 8

References

  1. 1

    E.N. Nikitin, V.I. Tarasov, A.A. Andreev L.N. Shumilova: Electrical properties of higher manganese silicide. Fiz. Tverd. Tela. 11, 3389 1969

    CAS  Google Scholar 

  2. 2

    I. Nishida: Semiconducting properties of nonstoichiometric manganese silicides. J. Mater. Sci. 7, 435 1972

    CAS  Article  Google Scholar 

  3. 3

    A.W. Searcy: Predicting the thermodynamic stabilities and oxidation resistances of silicide cermets. J. Am. Ceram. Soc. 40, 431 1957

    CAS  Article  Google Scholar 

  4. 4

    E. Groß, M. Riffel U. Stöhrer: Thermoelectric generators made of FeSi2 and HMS: Fabrication and measurement. J. Mater. Res. 10, 34 1995

    Article  Google Scholar 

  5. 5

    S. Okada, T. Shishido, M. Ogawa, F. Matsukawa, Y. Ishizawa, K. Nakajima, T. Fukuda T. Sundstrand: MnSi and MnSi2−x single crystals growth by Ga flux method and properties. J. Cryst. Growth 229, 532 2001

    CAS  Article  Google Scholar 

  6. 6

    M. Umemoto, Z.G. Liu, R. Omatsuzawa K. Tsuchiya: Production and characterization of Mn–Si thermoelectric material. Mater. Sci. Forum 343, 918 2000

    Article  Google Scholar 

  7. 7

    V.K. Zaitsev, S.V. Ordin, V.I. Tarasov M.I. Fedorov: Optical properties of higher manganese silicide. Sov. Phys. Solid State 21, 1454 1979

    Google Scholar 

  8. 8

    V.K. Zaitsev: In CRC Handbook of Thermoelectrics edited by D.M. Rowe CRC Press Boca Raton, FL 1995 Chap. 25, p. 304

  9. 9

    I. Engstrom B. Lonnberg: Thermal expansion studies of the group IV–VII transition-metal disilicides. J. Appl. Phys. 63, 4476 1988

    Article  Google Scholar 

  10. 10

    B.K. Voroniv, L.D. Dudkin N.N. Trusova: Anisotropy of thermoelectric properties in chromium disilicide and higher manganese silicide single crystal. Kristallografiya 12, 1527 1964

    Google Scholar 

  11. 11

    L.M. Levinson: Investigation of the defect manganese silicide MnnSi2n2m. J. Solid State Chem. 6, 126 1973

    CAS  Article  Google Scholar 

  12. 12

    L.D. Ivanova, N.Kh. Abrikosova, E.I. Elangina V.D. Khvostikova: Preparation and study of properties of higher manganese silicide single crystals. Izv. Akad. Nauk SSSR Neorg. Mater. 5, 1933 1969

    CAS  Google Scholar 

  13. 13

    I. Aoyama, M.I. Fedorov, V.K. Zaitsev, F.Y. Solomkin, I.S. Eremin, A.Y. Samunin, M. Mukoujima, S. Sano T. Tsuji: Effects of Ge doping on micromorphology of MnSi in MnSi1.7 and on their thermoelectric transport properties. Jpn. J. Appl. Phys. 12, 8562 2005

    Article  Google Scholar 

  14. 14

    S. Miura, Y. Sato, K. Fukuda, K. Nishimura K. Ikeda: Texture and thermoelectric properties of hot-extruded Bi2Te3 compound. Mater. Sci. Eng., A 227, 244 2000

    Article  Google Scholar 

  15. 15

    P. Pierrat, A. Dauscher, B. Lenoir, R.M. Lopez H. Scherrer: Preparation of the Bi8Sb32Te60 solid solution by mechanical alloying. J. Mater. Sci. 32, 3653 1997

    CAS  Article  Google Scholar 

  16. 16

    J. Seo, K. Park, D. Lee C. Lee: Thermoelectric properties of hot-pressed n-type Bi2Te2.85Se0.15 compounds doped with SbI3. Mater. Sci. Eng., B 49, 247 1997

    Article  Google Scholar 

  17. 17

    Y. Sakka T.S. Suzuki: Textured development of feeble magnetic ceramics by colloidal processing under high magnetic field. J. Ceram. Soc. Jpn. 113, 26 2005

    CAS  Article  Google Scholar 

  18. 18

    H. Kaga, Y. Kinemuchi, S. Tanaka, A. Makiya, Z. Kato, K. Uematsu K. Watari: Fabrication of c-axis oriented Zn0.98Al0.02O by a high-magnetic-field via gelcasting and its thermoelectric properties. J. Ceram. Soc. Jpn. 114, 1085 2006

    CAS  Article  Google Scholar 

  19. 19

    S. Tanaka, A. Makiya, Z. Kato, N. Uchida, T. Kimura K. Uematsu: Fabrication of c-axis oriented polycrystalline ZnO by using a rotating magnetic field and following sintering. J. Mater. Res. 21, 703 2006

    CAS  Article  Google Scholar 

  20. 20

    H. Kaga, Y. Kinemuchi, S. Tanaka, A. Makiya, Z. Kato, K. Uematsu K. Watari: Preparation and thermoelectric properties of highly oriented Al doped ZnO ceramics by a high magnetic field. Jpn. J. Appl. Phys. 45, L1212 2006

    CAS  Article  Google Scholar 

  21. 21

    T. Nakajima J. Schelten: Peculiarities of the band magnetism in the higher manganese silicide. J. Magn. Magn. Mater. 21, 157 1980

    CAS  Article  Google Scholar 

  22. 22

    U. Gottlieb, A. Sulpoce, B. Lambert-Andron O. Laborde: Magnetic properties of single crystalline Mn4Si7. J. Alloys Compd. 361, 13 2003

    CAS  Article  Google Scholar 

Download references

Acknowledgments

The authors sincerely thank Dr. Y. Yoshizawa, Dr. Y. Zhou, and Dr. A. Tsuge of National Institute of Advanced Industrial Science and Technology (AIST) for experimental help. The authors also thank Dr. H. Yilmaz for his valuable discussions.

Author information

Affiliations

Authors

Corresponding author

Correspondence to Hisashi Kaga.

Rights and permissions

Reprints and Permissions

About this article

Cite this article

Kaga, H., Kinemuchi, Y., Watari, K. et al. Fabrication of c-axis oriented higher manganese silicide by a high-magnetic-field and its thermoelectric properties. Journal of Materials Research 22, 2917–2923 (2007). https://doi.org/10.1557/JMR.2007.0360

Download citation