Advertisement

The Corrosion and Electrochemical Behavior of Tungsten-Based CVD Coatings in Alkaline Aqueous Solutions

  • V. V. DushikEmail author
  • Y. V. Lakhotkin
  • V. P. Kuzmin
  • T. V. Rybkina
  • N. V. Rozhanskii
  • B. A. Rychkov
PROTECTIVE COATINGS
  • 8 Downloads

Abstract

The results of corrosion-resistance analysis for tungsten-based coatings obtained by means of low-temperature chemical-vapor deposition from fluorine-containing media in alkaline solution are presented in this article. The study was carried out in the pH region where, according to the Pourbaix diagram, tungsten undergoes corrosion by the active dissolution mechanism. It is shown that, in alkaline solutions, the rate of general corrosion of a tungsten coating in solutions of natural aeration reaches values of 20–25 μm/year. An analysis of the electrochemical behavior of the coatings confirmed that the mode of corrosion dissolution is active, but it was noted that, in the region of high anodic polarization values, the growth of the anode current appears to be limited, which may be due to the formation of oxide layers that hinder the kinetics of anodic dissolution.

Keywords:

tungsten (W) corrosion in alkaline media chemical vapor deposition CVD 

Notes

ACKNOWLEDGMENTS

This work was supported by the Russian Foundation for Basic Research (grant no. 15-08-01386).

REFERENCES

  1. 1.
    Lakhotkin, Yu.V., Kuz’min, V.P., Goncharov, V.L., Dushik, V.V., Anufriev, N.G., Toporov, Yu.P., and Rozhanskii, N.V., Korroz.: Mater., Zashch., 2011, no. 2, pp. 28–33.Google Scholar
  2. 2.
    Lakhotkin, Yu.V., Dushik, V.V., Kuz’min, V.P., and Rozhanskii, N.V., Korroz.: Mater., Zashch., 2014, no. 3, pp. 21–37.Google Scholar
  3. 3.
    Dushik, V.V., Lakhotkin, Yu.V., Anufriev, N.G., Kuz’min, V.P., and Rozhanskii, N.V., Korroz.: Mater., Zashch., 2012, no. 1, pp. 31–36.Google Scholar
  4. 4.
    Dushik, V.V., Lakhotkin, Yu.V., Kuzmin, V.P., and Rozhanskii, N.V., Prot. Met. Phys. Chem. Surf., 2016, vol. 52, no. 7, pp. 1153–1156.CrossRefGoogle Scholar
  5. 5.
    Pourbaix, M., Atlas of Electrochemical Equilibrium in Aqueous Solutions, Houston, TX: NACE, 1974.Google Scholar
  6. 6.
    Dushik, V.V., Cand. Sci. (Chem.) Dissertation, Moscow, 2013.Google Scholar
  7. 7.
    Anik, M., Turk. J. Chem., 2002, no. 26, pp. 915–924.Google Scholar
  8. 8.
    Anik, M. and Osseo-Asare, K., J. Electrochem. Soc., 2002, vol. 149, no. 6, pp. 224–233.CrossRefGoogle Scholar

Copyright information

© Pleiades Publishing, Ltd. 2018

Authors and Affiliations

  • V. V. Dushik
    • 1
    Email author
  • Y. V. Lakhotkin
    • 1
  • V. P. Kuzmin
    • 1
  • T. V. Rybkina
    • 1
  • N. V. Rozhanskii
    • 1
  • B. A. Rychkov
    • 1
  1. 1.A.N. Frumkin Institute of Physical Chemistry and Electrochemistry, Russian Academy of SciencesMoscowRussia

Personalised recommendations