Abstract
The oil fraction is one of the key parameters in the design of horizontal pipes and relevant equipment in the oil production and transportation process of the petrochemical industry. Several existing models and correlations were applied as the predictive method, but due to the empirical nature of the models and correlations and limited data used for the benchmarking process, the applicability of the existing models and correlations to all flow regimes and full oil fraction range has not been well-examined. In view of these issues, this study is aiming at developing a predictive model of oil fraction in horizontal oil–water two-phase flow applicable to all flow regimes as well as full oil fraction range. In the modeling process, the oil–water two-phase flow is geometrically modeled as the stratified flow with dispersed water-continuous oil flow in the upper part of the circular channel and dispersed oil-continuous water flow in the lower part of the circular channel. An analytical model for predicting oil fraction in horizontal oil–water two-phase flows has been derived based on the assumption of velocity heads of two phases being equal. The analytical model includes two entrainment factors, e1 and e2, and the values of e1 and e2 are determined to be 0.2 considering bi-lateral droplet entrainments to oil and water phases. The analytical model has been validated with existing experimental data taken in a variety of test conditions. The comparison results demonstrate that the predictive capability of the analytical model is reasonably good for most of the existing test database including all six distinct oil–water two-phase flow regimes with the mean absolute error (or bias), standard deviation (random error), mean relative deviation, and mean absolute relative deviation of 0.0116, 0.0422, 1.61%, and 8.50%, respectively. Additionally, it is confirmed that the applicability of the analytical model can be ex tended to the steam–water two-phase flow in horizontal channels.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
Change history
05 February 2022
A Correction to this paper has been published: https://doi.org/10.1007/s42757-022-0132-z
References
Abduvayt, P., Manabe, R., Watanabe, T., Arihara, N. 2004. Analysis of oil–water flow tests in horizontal, hilly-terrain, and vertical pipes. In: Proceedings of the SPE Annual Technical Conference and Exhibition, SPE-90096-MS.
Baotong, S., Rassame, S., Nilsuwankosit, S., Hibiki, T. 2019. Drift-flux correlation of oil–water flow in horizontal channels. J Fluids Eng, 141: 031301.
Brauner, N., Moalem Maron, D., Rovinsky, J. 1998. A two-fluid model for stratified flows with curved interfaces. Int J Multiphase Flow, 24: 975–1004.
Charles, M. E., Govier, G. W., Hodgson, G. W. 1961. The horizontal pipeline flow of equal density oil–water mixtures. Can J Chem Eng, 39: 27–36.
Edomwonyi-Otu, L. C., Angeli, P. 2015. Pressure drop and holdup predictions in horizontal oil–water flows for curved and wavy interfaces. Chem Eng Res Des, 93: 55–65.
Fujii, T., Ohta, J., Nakazawa, T., Morimoto, O. 1994. The behavior of an immiscible equal-density liquid-liquid two-phase flow in a horizontal tube. JSME Int J, 37: 22–29.
Haywood, R. W., Knights, G. A., Middleton, G. E., Thom, J. R. S. 1961. Experimental study of the flow conditions and pressure drop of steam–water mixtures at high pressures in heated and unheated rubes. P I Mech Eng, 175: 669–747.
Hewitt, G. F., Delhaye, J.-M., Zuber, N. 1986. Multiphase Science and Technology, Vol. 2. Springer Science & Business Media.
Hibiki, T., Mao, K., Ozaki, T. 2017. Development of void fractionquality correlation for two-phase flow in horizontal and vertical tube bundles. Prog Nucl Energ, 97: 38–52.
Li, D., Xu, J. 2015. Measurement of oil-water flow via the correlation of turbine flow meter, gamma ray densitometry and drift-flux model. J Hydrodyn, 27: 548–555.
Liu, Y., Zhang, H., Wang, S., Wang, J. 2009. Prediction of pressure gradient and holdup in horizontal liquid–liquid segregated flow with small Eötvös number. Chem Eng Commun, 196: 697–714.
Lovick, J., Angeli, P. 2004. Experimental studies on the dual continuous flow pattern in oil–water flows. Int J Multiphase Flow, 30: 139–157.
Onuoha, M. D. U., Ismail, I., Ismail, A. S., Mansor, M. F. 2016. Experimental determination of flow patterns and water holdup of low viscosity oil–water system in horizontal pipes. Sains Malaysiana, 45: 1635–1642.
Rodriguez, I. H., Yamaguti, H. K. B., de Castro, M. S., da Silva, M. J., Rodriguez, O. M. H. 2011. Slip ratio in dispersed viscous oil–water pipe flow. Exp Therm Fluid Sci, 35: 11–19.
Rodriguez, O. M. H., Baldani, L. S. 2012. Prediction of pressure gradient and holdup in wavy stratified liquid–liquid inclined pipe flow. J Pet Sci Eng, 96–97: 140–151.
Russell, T. W. F., Hodgson, G. W., Govier, G. W. 1959. Horizontal pipeline flow of mixtures of oil and water. Can J Chem Eng, 37: 9–17.
Smith, S. L. 1969. Void fractions in two-phase flow: A correlation based upon an equal velocity head model. P I Mech Eng, 184: 647–664.
Sunder Raj, T., Chakrabarti, D. P., Das, G. 2005. Liquid–liquid stratified flow through horizontal conduits. Chem Eng Technol, 28: 899–907.
Trallero, J. L. 1995. Oil–water flow patterns in horizontal pipe. Ph.D. Dissertation. Tulsa, USA: The University of Tulsa.
Trallero, J. L., Sarica, C., Brill, J. P. 1997. A study of oil–water flow patterns in horizontal pipes. SPE Prod Facil, 12: 165–172.
Vielma, M. A., Atmaca, S., Sarica, C., Zhang, H.-Q. 2008. Characterization of oil/water flows in horizontal pipes. SPE Projects, Facilities & Construction, 3: 1–21.
Wang, L. P., Carey, V. P., Greif, R., Abdollahian, D. 1990. Experimental simulation and analytical modeling of two-phase flow under zero-gravity conditions. Int J Multiphase Flow, 16: 407–419.
Xu, J., Wu, Y., Chang, Y., Guo, J. 2008. Experimental investigation on the holdup distribution of oil–water two-phase flow in horizontal parallel tubes. Chem Eng Technol, 31: 1536–1540.
Xu, M., Xiong, R. H., Li, Y. F., Yang, J. M., Luo, X., Yu, Y. B., Zhao, T. Z. 2010. Pattern transition and holdup behaviors of horizontal oil–water pipe flow. In: Proceedings of the 7th International Conference on Multiphase Flow, 1–6.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Hibiki, T., Rassame, S. Analytical model for predicting oil fraction in horizontal oil–water two-phase flow. Exp. Comput. Multiph. Flow 1, 73–84 (2019). https://doi.org/10.1007/s42757-019-0013-2
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s42757-019-0013-2