Biomass Conversion and Biorefinery

, Volume 8, Issue 2, pp 447–454 | Cite as

An integrated approach for extracting fuel, chemicals, and residual carbon using pine needles

  • Vinod Kumar
  • Manisha Nanda
  • Monu Verma
  • Ajay Singh
Original Article
  • 21 Downloads

Abstract

The present study describes an integrated method that can be used to sequentially extract five economically important fractions viz., essential oil, organic acids, resin, cellulose, and residual carbon from biomass of pine needles. It is a simple but very effective approach which can give consistent yields from the residual biomass with every successive extraction step. For example, aqueous extracts 0.2 ± 0.5 ml/g, essential oil 0.03 ± 0.1 ml/g, resin 64.125 ± 0.2 mg/g, and 302.20 ± 04 mg/g of sugar and 1 ± 0.3 g of residual carbon. Sugars were further fermented under optimized conditions for the production of ethanol (18.2 ± 0.4 g/l). These yields were compared to direct processing of the individual components. Residual carbon obtained after hydrolysis was used for the preparation of activated carbon. This combined ethanol production and chemical extraction approach may provide a compelling model for a biorefinery and increasing commercial viability.

Keywords

Pine needles Essential oil Organic acids Resin Residual carbon 

Supplementary material

13399_2018_304_MOESM1_ESM.doc (99 kb)
ESM 1 (DOC 99 kb)
13399_2018_304_MOESM2_ESM.docx (844 kb)
ESM 2 (DOCX 844 kb)

References

  1. 1.
    Noori MS, Karimi K (2016) Detailed study of efficient ethanol production from elmwood by alkali pretreatment. Biochem Eng J 105:197–204.  https://doi.org/10.1016/j.bej.2015.09.019 CrossRefGoogle Scholar
  2. 2.
    Safari A, Karimi K, Shafiei M (2017) Dilute alkali pretreatment of softwood pine: a biorefinery approach. Bioresour Technol 234:67–76.  https://doi.org/10.1016/j.biortech.2017.03.030 CrossRefGoogle Scholar
  3. 3.
    Kumar R, Tabatabaei M, Karimi K, Horváth IS (2016) Recent updates on lignocellulosic biomass derived ethanol—a review. Biofuel Res J 9:347–356.  https://doi.org/10.18331/BRJ2016.3.1.4 CrossRefGoogle Scholar
  4. 4.
    Kumar A, Randa R (2014) Experimental analysis of a producer gas generated by a Chir pine needle (leaf ) in a downdraft biomass gasifier. Int J Eng Res Appl 4:122–130Google Scholar
  5. 5.
    Bisht M, Singh S, Kumar M (2014) Pine needles a source of energy for Himalayan region. Int J Sci Technol Res 3:161–164Google Scholar
  6. 6.
    Dwivedi RK, Singh RP, Bhattacharya TK (2016) Studies on bio-pretreatment of pine needles for sustainable energy thereby preventing wild forest fires. Curr Sci 111:388–394.  https://doi.org/10.18520/cs/v111/i2/388-394 CrossRefGoogle Scholar
  7. 7.
    (1977) LF J, JW C, AH S (1977) Experimentally induced pine needle abortion in range cattle. Cornell Vet 67:294–299. 1977Google Scholar
  8. 8.
    Ghosh MK, Ghosh UK (2011) Utilization of pine needles as bed material in solid state fermentation for production of lactic acid by lactobacillus strains. Bio Resour 6:1556–1575Google Scholar
  9. 9.
    Selvakumar G, Saha S, Kundu S (2007) Inhibitory activity of pine needle tannin extracts on some agriculturally resourceful microbes. Indian J Microbiol 47:267–270.  https://doi.org/10.1007/s12088-007-0049-z CrossRefGoogle Scholar
  10. 10.
    Tripathi AK, Kumari M, Kumar A, Kumar S (2015) Generation of biogas using pine needles as substrate in domestic biogas plant Int. 5 (2015) 716–721. Int J Renew Energy Res 5:716–721Google Scholar
  11. 11.
    A.A Ray, Das M (2010) Eco friendly utilization of hazardous pine needle waste for the production of paper, conference proceedings of American Institute of Chemical Engineers”, a IChE, USA. In: ference Proc. Am. Inst. Chem. Eng. AIChE, USA. p 2010Google Scholar
  12. 12.
    Lal PS, Sharma A, Bist V (2013) Pine needle—an evaluation of pulp and paper. J For Prod Ind 2:42–47Google Scholar
  13. 13.
    Zeng W-C, Zhang Z, Gao H, Jia LR, He Q (2012) Chemical composition, antioxidant, and antimicrobial activities of essential oil from pine needle (Cedrus deodara). J Food Sci 77:C824–C829.  https://doi.org/10.1111/j.1750-3841.2012.02767.x CrossRefGoogle Scholar
  14. 14.
    Feng S, Zeng W, Luo F, Zhao J, Yang Z, Sun Q (2010) Antibacterial activity of organic acids in aqueous extracts from pine needles (Pinus massoniana Lamb.) Food Sci Biotechnol 19:35–41.  https://doi.org/10.1007/s10068-010-0005-2 CrossRefGoogle Scholar
  15. 15.
    Singh S, Vaid A, Singh PS, Bajaj BK (2016) Physicochemical pretreatment of pine needle biomass by design of experiments approach for efficient enzymatic saccharificatio. J Mater Environ Sci 7:2034–2041Google Scholar
  16. 16.
    Crini G (2006) Non-conventional low-cost adsorbents for dye removal: a review. Bioresour Technol 97:1061–1085CrossRefGoogle Scholar
  17. 17.
    Wang MH, Li J, Ho YS (2011) Research articles published in water resources journals: a bibliometric analysis. Desalin Water Treat 28:353–365CrossRefGoogle Scholar
  18. 18.
    Kumar V, Nanda M, Joshi HC, Singh A, Sharma S, Verma M (2018) Production of biodiesel and bioethanol using algal biomass harvested from fresh water river. Renew Energy 116:606–612CrossRefGoogle Scholar
  19. 19.
    Kumar V, Nanda M, Singh A (2016) Effect of bacterial amylase pretreatment on bioethanol production from starch-based solid waste (SBSW). Energy Sources, Part A Recover Util Environ Eff 38:2604–2609CrossRefGoogle Scholar
  20. 20.
    Duman G, Onal Y, Okutucu C, Onenc S, Yanik J (2009) Production of activated carbon from pine cone and evaluation of its physical, chemical, and adsorption properties. Energy Fuel 23:2197–2204.  https://doi.org/10.1021/ef800510m CrossRefGoogle Scholar
  21. 21.
    Üner O, Geçgel Ü, Kolancılar H, Bayrak Y (2017) Adsorptive removal of rhodamine B with activated carbon obtained from okra wastes. Chem Eng Commun 204:772–783.  https://doi.org/10.1080/00986445.2017.1319361 CrossRefGoogle Scholar
  22. 22.
    Koukos PK, Papadopoulou KI, Patiaka DT, Papagiannopoulos AD (2000) Chemical composition of essential oils from needles and twigs of Balkan pine (Pinus peuce Grisebach) grown in northern Greece. J Agric Food Chem 48:1266–1268.  https://doi.org/10.1021/jf991012a CrossRefGoogle Scholar
  23. 23.
    Rezzoug SA (2009) Optimization of steam extraction of oil from maritime pine needles. J Wood Chem Technol 29:87–100.  https://doi.org/10.1080/02773810902879025 CrossRefGoogle Scholar
  24. 24.
    Bakkali F, Averbeck S, Averbeck D, Idaomar M (2008) Biological effects of essential oils—a review. Food Chem Toxicol 46:446–475.  https://doi.org/10.1016/j.fct.2007.09.106 CrossRefGoogle Scholar
  25. 25.
    Linde M, Galbe M, Zacchi G (2007) Simultaneous saccharification and fermentation of steam-pretreated barley straw at low enzyme loadings and low yeast concentration. Enzym Microb Technol 40:1100–1107.  https://doi.org/10.1016/j.enzmictec.2006.08.014 CrossRefGoogle Scholar
  26. 26.
    Ballesteros M, Oliva JM, Negro MJ, Manzanares P, Ballesteros I (2004) Ethanol from lignocellulosic materials by a simultaneous saccharification and fermentation process (SFS) with Kluyveromyces marxianus CECT 10875. Process Biochem 39:1843–1848.  https://doi.org/10.1016/j.procbio.2003.09.011 CrossRefGoogle Scholar
  27. 27.
    Castro RCA, Roberto IC (2014) Selection of a thermotolerant Kluyveromyces marxianus strain with potential application for cellulosic ethanol production by simultaneous saccharification and fermentation. Appl Biochem Biotechnol 172:1553–1564.  https://doi.org/10.1007/s12010-013-0612-5 CrossRefGoogle Scholar
  28. 28.
    Guha S, H., Fukuoka A (2010) Conversion of cellulose to sugars. In Conversion of biomass to liquid fuels and chemicals. 1:344–364Google Scholar
  29. 29.
    Taherzadeh MJ, Karimi K (2008) Pretreatment of lignocellulosic wastes to improve ethanol and biogas production: a review. Int J Mol Sci 9:1621–1651.  https://doi.org/10.3390/ijms9091621 CrossRefGoogle Scholar
  30. 30.
    Argun ME, Dursun S, Karatas M, Gürü M (2008) Activation of pine cone using Fenton oxidation for cd(II) and Pb(II) removal. Bioresour Technol 99:8691–8698.  https://doi.org/10.1016/j.biortech.2008.04.014 CrossRefGoogle Scholar
  31. 31.
    Ofomaja AE, Naidoo EB, Modise SJ (2009) Removal of copper(II) from aqueous solution by pine and base modified pine cone powder as biosorbent. J Hazard Mater 168:909–917.  https://doi.org/10.1016/j.jhazmat.2009.02.106 CrossRefGoogle Scholar
  32. 32.
    Sen TK, Afroze S, Ang HM (2010) Equilibrium, kinetics and mechanism of removal of methylene blue from aqueous solution by adsorption onto pine cone biomass of Pinus radiate. Water Air Soil Pollut 218:499–515CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2018

Authors and Affiliations

  • Vinod Kumar
    • 1
  • Manisha Nanda
    • 2
  • Monu Verma
    • 1
  • Ajay Singh
    • 1
  1. 1.Department of ChemistryUttaranchal UniversityDehradunIndia
  2. 2.Department of BiotechnologyDolphin (PG) Institute of Biomedical and Natural SciencesDehradunIndia

Personalised recommendations