Abstract
The thermoelectric and transport properties of Ti-doped FeVSb half-Heusler alloys were studied in this study. FeV1−xTixSb (0.1 < x < 0.5) half-Heusler alloys were synthesized by mechanical alloying process and subsequent vacuum hot pressing. After vacuum hot pressing, a near singe phase with a small fraction of second phase was obtained in this experiment. Investigation of microstructure revealed that both grain and particle sizes were decreased on doping which would influence on thermal conductivity. No foreign elements pick up from the vial was seen during milling process. Thermoelectric properties were investigated as a function of temperature and doping level. The absolute value of Seebeck coefficient showed transition from negative to positive with increasing doping concentrations (x ≥ 0.3). Electrical conductivity, Seebeck coefficient and power factor increased with the increasing amount of Ti contents. The lattice thermal conductivity decreased considerably, possibly due to the mass disorder and grain boundary scattering. All of these turned out to increase in power factor significantly. As a result, the thermoelectric figure of merit increased comprehensively with Ti doping for this experiment, resulting in maximum thermoelectric figure of merit for FeV0.7Ti0.3Sb at 658 K.
Graphical Abstract
Similar content being viewed by others
REFERENCES
Neaton, J.B.: Single-molecule junctions: thermoelectricity at the gate. Nat. Nanotechnol. 9, 876 (2014)
Zheng, X.F., Liu, C.X., Yan, Y.Y., Wang, Q.: A review of thermoelectrics research-recent developments and potentials for sustainable and renewable energy applications. Renew. Sustain. Energy Rev. 32, 486 (2014)
Snyder, G.J., Toberer, E.S.: Complex thermoelectric materials. Nat. Mater. 7, 105 (2008)
Pei, Y.Z., Shi, X.Y., Lalonde, A., Wang, H., Chen, L.D., Snyder, G.J.: Convergence of electronic bands for high performance bulk thermoelectrics. Nature 473, 66 (2011)
Hohl, H., Ramirez, A.P., Goldmann, C., Ernst, G., Wolfing, B., Bucher, E.: Efficient dopants for ZrNiSn-based thermoelectric materials. J. Phys. Condens. Matter 11, 1697 (1999)
Xia, Y., Ponnambalam, V., Bhattacharya, S., Pope, A.L., Poon, S.J., Tritt, T.M.: Electrical transport properties of TiCoSb half-Heusler phases that exhibit high resistivity. J. Phys. Condens. Matter 13, 77 (2001)
Fu, C., Bai, S., Liu, Y., Tang, Y., Chen, L., Zhao, X., Zhu, T.: Realizing high figure of merit in heavy-band p-type half-Heusler thermoelectric materials. Nat. Commun. 6, 1 (2015)
Akram, R., Zhang, Q., Yang, D., Zheng, Y., Yan, Y., Su, X., Tang, X.: Enhanced thermoelectric properties of La-doped ZrNiSn half-Heusler compound. J. Electron. Mater. 44, 3563 (2015)
Chen, S., Ren, Z.: Recent progress of half-Heusler for moderate temperature thermoelectric applications. Mater. Today 16, 387 (2013)
Young, D.P., Khalifah, P., Cava, R.J., Ramirez, A.P.: Thermoelectric properties of pure and doped FeMSb (M = V, Nb). J. Appl. Phys. 87, 317 (2000)
Uher, C., Yang, J., Hu, S., Morelli, D.T., Meisner, G.P.: Transport properties of pure and doped MNiSn (M = Zr, Hf). Phys. Rev. B. 59, 8615 (1999)
Xia, Y., Bhattacharya, S., Ponnambalam, V., Pope, A.L., Poon, S.J., Tritt, T.M.: Thermoelectric properties of semimetallic (Zr, Hf)CoSb half-Heusler phases. J. Appl. Phys. 88, 1952 (2000)
Shen, Q., Chen, L., Goto, T., Hiraj, T., Yang, J., Meisner, G.P., Uher, C.: Effects of partial substitution of Ni by Pd on the thermoelectric properties of ZrNiSn-based half-Heusler compounds. Appl. Phys. Lett. 79, 4165 (2005)
Zhao, L.D., Lo, S.H., Zhang, Y., Sun, H., Tan, G., Uher, C., Wolverton, C., Dravid, V.P., Kanatzidis, M.G.: Ultralow thermal conductivity and high thermoelectric figure of merit in SnSe crystals. Nature 508, 373 (2014)
Zou, M., Li, J.F., Kita, T.: Thermoelectric properties of fine-grained FeVSb half-Heusler alloys tuned to p-type by substituting vanadium with titanium. J. Solid State Chem. 198, 125 (2013)
Sakurada, S., Shutoh, N.: Effect of Ti substitution on the thermoelectric properties of (Zr, Hf)NiSn half-Heusler compounds. Appl. Phys. Lett. 86, 82105 (2005)
DeGarmo, E.P., Black, J.T., Kohser, R.A.: Solution Manuals to Accompany-Materials and Process in Manufacturing, p. 107. Wiley, New York (2003)
Kim, I.-H., Kwon, J.-C., Lee, Y.-G., Yoon, M.-S., Ryu, S.-L., Kim, W.-G., Ur, S.-C.: Synthesis and thermoelectric properties of undoped half-Heusler Zr-Co-Sb alloy processed by mechanically alloying and hot pressing. Mater. Sci. Forum 658, 33 (2010)
Hasan, R., Ur, S.-C.: Synthesis of tin-doped FeVSb half-Heusler system by mechanical alloying and evaluation of thermoelectric performance. J. Trans. Electr. Electron. Mater. 19, 106 (2018)
Yuasa, E., Morooka, T., Tsunoda, M., Mishima, J.I.: Vacuum hot pressing of Cu-Ti-B alloy powder prepared by the mechanical alloying and its mechanical properties. J. Jpn. Soc. Powder Powder Metall. 42, 171 (1995)
Chang, K., Feng, W., Chen, L.Q.: Effect of second-phase particle morphology on grain growth kinetics. Acta Mater. 57, 5229 (2009)
Ur, S.-C., Choo, H., Lee, D.B., Nash, P.: Processing and properties of mechanically alloyed Ni(Fe)Al-Al2O3-AlN. Met. Mater. Int. 6, 435 (2000)
Porter, D.A., Easterling, K.E.: Phase Transformations in Metals and Alloys, p. 92. Springer, London (1992)
Lan, Y.C., Minnich, A.J., Chen, G., Ren, Z.: Enhancement of thermoelectric figure-of-merit by a bulk nanostructuring approach. Adv. Funct. Mater. 20, 357 (2010)
Barczak, S.A., Buckham, J., Smith, R.I., Baker, A.R., Don, E., Forbes, I., Bos, J.W.G.: Impact of interstitial Ni on the thermoelectric properties of the half-Heusler TiNiSn. Materials 11, 9 (2018)
Stern, R., Dongre, B., Madsen, G.K.H.: Extrinsic doping of the half-Heusler compounds. Nanotechnology 27, 1 (2016)
Gong, J.J., Hong, A.J., Shuai, J., Li, L., Yan, Z.B., Ren, Z.F., Liu, J.-M.: Investigation of the bipolar effect in the thermoelectric material CaMg2Bi2 using a first-principles study. Phys. Chem. Chem. Phys. 18, 16566 (2016)
Tritt, T.M.: Thermal Conductivity: Theory, Properties and Applications, p. 78. Springer, New York (2004)
Su, C.-H.: Thermal conductivity, electrical conductivity, and thermoelectric properties of CdTe and Cd0.8Zn0.2Te crystals between room temperature and 780 °C. AIP Adv. 5, 057118 (2015)
Acknowledgements
This work was supported by the Regional Innovation Center (RIC) Program, which was conducted by the Ministry of SMEs and Startups of the Korean Government.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Hasan, R., Ur, SC. Thermoelectric and Transport Properties of FeV1−xTixSb Half-Heusler System Synthesized by Controlled Mechanical Alloying Process. Electron. Mater. Lett. 14, 725–732 (2018). https://doi.org/10.1007/s13391-018-0088-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13391-018-0088-0