Skip to main content
SpringerLink
Log in

Enzyme induced cementation of biochar-intercalated soil: fabrication and characterization

  • S. I. BIOCHAR
  • Published:
Arabian Journal of Geosciences Aims and scope Submit manuscript

Abstract

This paper presents the effect of adding biochar on the sand treated by a bio-inspired technique known as enzyme-induced carbonate precipitation (EICP). In EICP, free urease enzyme is used to accelerate the reaction between calcium chloride and urea to induce calcium carbonate precipitation in soil pores. A laboratory study was conducted to investigate the efficiency of three different biochars produced at different temperatures (300, 500, and 700 °C) and applied at 1% to the soil. The precipitation is expected to change the mechanical properties of the treated soil through binding particles and reducing the impact of the ammonia chloride. The outcome of this study illustrated that adding biochar will decrease the cementation bonding between particles, strength, due surface structure, and functional groups of biochar. Furthermore, lower pH was recorded at a lower pyrolysis temperature compared to a high pyrolysis temperature. However, the high pyrolysis temperature indicated that higher porosity would decrease the efficiency of precipitation. Unconfined compressive strength, scan electron microscopy, energy-dispersive X-ray spectroscopy, and X-ray diffractometer were illustrated, and the type of precipitation and crystal that form through this study was discussed.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5

Similar content being viewed by others

References

  • Ahmad M, Lee SS, Dou X, Mohan D, Sung JK, Yang JE, Ok YS (2012) Effects of pyrolysis temperature on soybean stover- and peanut shell-derived biochar properties and TCE adsorption in water. Bioresour Technol 118:536–544

    Article  Google Scholar 

  • Ahmad M, Ahmad M, Usman AR, Al-Faraj AS, Abduljabbar AS, Al-Wabel MI (2018) Biochar composites with nano zerovalent iron and eggshell powder for nitrate removal from aqueous solution with coexisting chloride ions. Environ Sci Pollut Res 25(26):25757–25771

    Article  Google Scholar 

  • Almajed AA (2017) Enzyme induced carbonate precipitation (EICP) for soil improvement. (Doctoral dissertation, Arizona State University)

  • Almajed A, Khodadadi Tirkolaei H, Kavazanjian E Jr (2018) Baseline investigation on enzyme-induced calcium carbonate precipitation. J Geotech Geoenviron 144(11):04018081

    Article  Google Scholar 

  • Almajed A, Tirkolaei HK, Kavazanjian E, Hamdan N (2019) Enzyme induced biocementated sand with high strength at low carbonate content. Sci Rep 9(1):1135

    Article  Google Scholar 

  • Al-Wabel MI, Al-Omran A, El-Naggar AH, Nadeem M, Usman AR (2013) Pyrolysis temperature induced changes in characteristics and chemical composition of biochar produced from conocarpus wastes. Bioresour Technol 131:374–379

    Article  Google Scholar 

  • Al-Wabel MI, Usman AR, El-Naggar AH, Aly AA, Ibrahim HM, Elmaghraby S, Al-Omran A (2015) Conocarpus biochar as a soil amendment for reducing heavy metal availability and uptake by maize plants. Saudi journal of biological sciences 22(4):503–511

    Article  Google Scholar 

  • Cataldo DA, Maroon M, Schrader LE, Youngs VL (1975) Rapid colorimetric determination of nitrate in plant tissue by nitration of salicylic acid. Commun Soil Sci Plant Anal 6(1):71–80

    Article  Google Scholar 

  • Chen B, Zhou D, Zhu L (2008) Transitional adsorption and partition of nonpolar and polar aromaric contaminants by biochars of pine needles with different pyrolytic temperatures. Environ Sci Technol 42:5137–5143

    Article  Google Scholar 

  • Das N, Kayastha AM, Srivastava PK (2002) Purification and haracterization of urease from dehuskedpigeonpea (Cajanuscajan L.) seeds. Phytochemistry 61(5)

  • Demirbas A (2004) Effects of temperature and particle size on biochar yield from pyrolysis of agricultural residues. J Anal Appl Pyrolysis 72(2):243–248

    Article  Google Scholar 

  • Dilrukshi RAN, Kawasaki S (2016) Effective use of plant-derived urease in the field of geoenvironmental. Geotechnical Engineering. J Civil Environ Eng (207)2

  • El-Naggar A, Lee SS, Awad YM, Yang X, Ryu C, Rizwan M et al (2018) Influence of soil properties and feedstocks on biochar potential for carbon mineralization and improvement of infertile soils. Geoderma 332:100–108

    Article  Google Scholar 

  • Enders A, Hanley K, Whitman T, Joseph S, Lehmann J (2012) Characterization of biochars to evaluate recalcitrance and agronomic performance. Bioresour Technol 114:644–653

    Article  Google Scholar 

  • Gai X, Wang H, Liu J, Zhai L, Liu S, Ren T, Liu H (2014) Effects of feedstock and pyrolysis temperature on biochar adsorption of ammonium and nitrate. PLoS One 9(12):e113888

    Article  Google Scholar 

  • Grossman JM, O’Neill BE, Tsai SM, Liang B, Neves E, Lehmann J, Thies JE (2010) Amazonian anthrosols support similar microbial communities that differ distinctly from those extant in adjacent, unmodified soils of the same mineralogy. Microb Ecol 60:192e205

    Article  Google Scholar 

  • Hamdan N Kavazanjian E (2016) Enzyme-induced carbonate mineral precipitation for fugitive dust control. Géotechnique 66(7):546–555

  • Hamdan N, Kavazanjian E, O’Donnell S (2013) Carbonate cementation via plant derived urease. 18th Int. Conf. on Soil Mechanics and Geotechnical Engineering, Paris, France

  • Inyang M, Gao B, Yao Y, Xue Y, Zimmerman AR, Pullammanappallil P, Cao X (2012) Removal of heavy metals from aqueous solution by biochars derived from anaerobically digested biomass. Bioresour Technol 110:50–56

    Article  Google Scholar 

  • Karol RH (2003) Chemical grouting and soil stabilization. Dekker, New York

    Book  Google Scholar 

  • Kavazanjian E, Almajed A, Hamdan N (2017) Bio-inspired soil improvement using EICP soil columns and soil nails. Geotechnical Special Publication (288 GSP):13–22

  • Kayastha AM, Das N (1999) A simple laboratory experiment for teaching enzyme immobilization with urease and its application in blood urea estimation. Biochemical Education 27(2):114–117

  • Kim J-S, Sparovek S, Longo RM, De Melo WJ, Crowley D (2007) Bacterial diversity of terra preta and pristine forest soil from the Western Amazon. Soil Biol Biochem 39:648e690

    Article  Google Scholar 

  • Lehmann J, Rillig MC, Thies J, Masiello CA, Hockaday WC, Crowley D (2011) Biochar effects on soil biota—a review. Soil Biol Biochem 43(9):1812–1836

    Article  Google Scholar 

  • Liang B, Lehmann J, Solomon D, Kinyangi J, Grossman J, O'Neill B, Skjemstad JO, Thies J, Luizao FJ, Petersen J, Neves EG (2006) Black carbon increases cation exchange capacity in soils. Soil Sci Soc Am J 70:1719–1730

    Article  Google Scholar 

  • Malik Z, Yutong Z, ShengGao L, Abassi GH, Ali S, Kamran M et al (2018) Effect of biochar and quicklime on growth of wheat and physicochemical properties of Ultisols. Arab J Geosci 11(17):496

    Article  Google Scholar 

  • Manikandan A, Subramanian KS (2013) Urea intercalated biochar—a slow release fertilizer production and characterisation. Indian J Sci Technol 6(12):5579–5584

    Google Scholar 

  • Mohamed EM, El-Naggar AH, Usman AR, Al-Wabel M (2015) Dynamics of CO2 emission and biochemical properties of a sandy calcareous soil amended with Conocarpus waste and biochar. Pedosphere 25(1):46–56

    Article  Google Scholar 

  • Neupane D, Yasuhara H, Kinoshita N, Ando Y (2015a) Distribution of mineralized carbonate and its quantification method in enzyme mediated calcite precipitation technique. Soils and Foundations 55(2):447–457

  • Neupane D, Yasuhara H, Kinoshita N, Putra H (2015b) Distribution of grout material within 1-m sand column in insitu calcite precipitation technique. Soils and Foundations 55(6):1512–1518

  • O’Neill B, Grossman J, Tsai MT, Gomes JE, Lehmann J, Peterson J, Neves E, Thies JE (2009) Bacterial community composition in Brazilian Anthrosols and adjacent soils characterized using culturing and molecular identification. Microb Ecol 58:23e35

    Article  Google Scholar 

  • Pietikäinen J, Kiikkilä O, Fritze H (2000) Charcoal as a habitat for microbes and its effects on the microbial community of the underlying humus. Oikos 89:231e242

    Article  Google Scholar 

  • Putra H, Yasuhara H, Kinoshita N, Neupane D, Lu C (2016) Effect of magnesium as substitute material in enzyme-mediated calcite precipitation for soil-improvement technique. Front Bioeng Biotechnol 4

  • Quilliam RS, Marsden KA, Gertler C, Rousk J, DeLuca TH, Jones DL (2012) Nutrient dynamics, microbial growth and weed emergence in biochar amended soil are influenced by time since application and reapplication rate. Agric Ecosyst Environ 158:192–199

    Article  Google Scholar 

  • Rehrah D, Bansode RR, Hassan O, Ahmedna M (2016) Physico-chemical characterization of biochars from solid municipal waste for use in soil amendment. J Anal Appl Pyrolysis 118:42–53

    Article  Google Scholar 

  • Sasongko A (2018) Ammonia determination in bottled water using spectrophotometer: comparison between Nessler and Berthelot methods. JST (Jurnal Sains dan Teknologi) 7(1):126–134

    Article  Google Scholar 

  • Tan X, Liu Y, Zeng G, Wang X, Hu X, Gu Y, Yang Z (2015) Application of biochar for the removal of pollutants from aqueous solutions. Chemosphere 125:70–85

    Article  Google Scholar 

  • Usman AR, Abduljabbar A, Vithanage M, Ok YS, Ahmad M, Ahmad M et al (2015) Biochar production from date palm waste: charring temperature induced changes in composition and surface chemistry. J Anal Appl Pyrolysis 115:392–400

    Article  Google Scholar 

  • Yasuhara H, Hayashi K, Okamura M (2011) Evolution in mechanical and hydraulic properties of calcite-cemented sand mediated by biocatalyst. Geo-Frontiers 2011: Advances in Geotechnical Engineering, ASCE 3984–3992

  • Yasuhara H, Neupane D, Hayashi K, Okamura M (2012) Experiments and predictions of physical properties of sand cemented by enzymatically-induced carbonate precipitation. Soils and Foundations 52(3):539–549

  • Yin B, Crowley D, Sparovek G, De Melo WJ, Borneman J (2000) Bacterial functional redundancy along a soil reclamation gradient. Appl Environ Microbiol 66:4361e4365

    Article  Google Scholar 

  • Yuan JH, Xu RK, Zhang H (2011) The forms of alkalis in the biochar produced from crop residues at different temperatures. Bioresour Technol 102(3):3488–3497

    Article  Google Scholar 

Download references

Funding

The authors acknowledge the College of Engineering Research Center and Deanship of Scientific Research at King Saud University in Riyadh, Saudi Arabia, for their financial support for the research work reported in this article.

Author information

Authors and Affiliations

  1. Department of Civil Engineering, King Saud University (KSU), Riyadh, 11421, Saudi Arabia

    A. Almajed

Authors
  1. A. Almajed
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to A. Almajed.

Additional information

This article is part of the Topical Collection on Implications of Biochar Application to Soil Environment under Arid Conditions

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Almajed, A. Enzyme induced cementation of biochar-intercalated soil: fabrication and characterization. Arab J Geosci 12, 403 (2019). https://doi.org/10.1007/s12517-019-4557-z

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1007/s12517-019-4557-z

Keywords

Search

Navigation