Abstract
In order to investigate the effect of the thickness on the electrical conductivity of yttria-stabilized zirconia (YSZ) film, the nanocrystalline columnar-structured YSZ film with thickness of 0.67-2.52 μm was prepared by magnetron sputtering through controlling the deposition time. All the sputtered films with different thicknesses consist of the main phase of cubic YSZ as well as a small amount of monoclinic YSZ. The thicker films exhibit a typical columnar grain structure based on the fractured cross-sectional SEM observations. The average diameters of columnar grains increase from about 40 nm to 100 nm with the film thickness from 0.67 μm to 2.52 μm according to TEM analysis. The thinnest YSZ film with 0.67 μm thickness shows the highest apparent electrical conductivity in the four films in 400–800 °C due to the contribution from the highly conductive film/substrate interfacial region. On the other hand, the real electrical conductivities of YSZ films increase with film thickness from 0.67 μm to 2.52 μm after eliminating the contribution of the film/substrate interface. The increasing film thickness leads to the grain growth as well as the decrement in the volumetric fraction of the resistive columnar grain boundary and a consequent higher real electrical conductivity.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Han MF, Tang XL, Shao W. The Properties of YSZ Electrolyte Sintering at 1300 °C[J]. J. Wuhan Univ. Technol.–Mater. Sci. Ed., 2008, 23 (6): 775–778
Guo X, Waser R. Electrical Properties of the Grain Boundaries of Oxygen Ion Conductors: Acceptor–doped Zirconia and Ceria[J]. Prog. Mater. Sci., 2006, 51: 151–210
Han MF, Li BT, Peng SP. Manufacture Process of 8Y2O3 Stabilized ZrO2 from Nano Powders[J]. J. Wuhan Univ. Technol.–Mater. Sci. Ed., 2004, 19 (3): 10–13
Joo JH, Choi GM. Electrical Conductivity of YSZ Film Grown by Pulsed Laser Deposition[J]. Solid State Ionics, 2006, 177: 1 053–1 057
Solovyev AA, Sochugov NS, Rabotkin SV. Application of PVD Methods to Solid Oxide Fuel Cells[J]. Appl. Surf. Sci., 2014, 310: 272–277
Infortuna A, Harvey AS, Gauckler LJ. Microstructures of CGO and YSZ Thin Films by Pulsed Laser Deposition[J]. Adv. Funct. Mater., 2008, 18: 127–135
Li CJ, Li CX, Xing YZ, et al. Influence of YSZ Electrolyte Thickness on the Characteristics of Plasma–sprayed Cermet Supported Tubular SOFC. Solid State Ionics, 2006, 177: 2 065–2 069
Zhao W, Kim IJ, Gong J. Influence of Thickness on the Electrical Conductivity of YSZ Electrolytes[J]. J. Ceram. Soc. Jpn., 2010, 118: 550–554
Maier J. Defect Chemistry and Ion Transport in Nanostructured Materials: Part II. Aspects of Nanoionics[J]. Solid State Ionics, 2003, 157: 327–334
Sillassen M, Eklund P, Pryds N, et al. Low–Temperature Superionic Conductivity in Strained Yttria–Stabilized Zirconia[J]. Adv. Funct. Mater., 2010, 20: 2 071–2 076
Mondal P, Klein A, Jaegermann W, et al. Enhanced Specific Grain Boundary Conductivity in Nanocrystalline Y2O3–Stabilized Zirconia[J]. Solid State Ionics, 1999, 118: 331–339
Kosacki I, Rouleau CM, Becher PF, et al. Nanoscale Effects on the Ionic Conductivity in Highly Textured YSZ Thin Films[J]. Solid State Ionics, 2005, 176: 1 319–1 326
Guo X, Vasco E, Mi SB, et al. Ionic Conduction in Zirconia Films of Nanometer Thickness[J]. Acta Mater., 2005, 53: 5 161–5 166
Schichtel N, Korte C, Hesse D, et al. Elastic Strain at Interfaces and Its Influence on Ionic Conductivity in Nanoscaled Solid Electrolyte Thin Films–theoretical Considerations and Experimental Studies[J]. Phys. Chem. Chem. Phys., 2009, 11: 3 043–3 048
Korte C, Schichtel N, Hesse D, et al. Influence of Interface Structure on Mass Transport in Phase Boundaries between Different Ionic Materials [J]. Monatsh. Chem., 2009, 140: 1 069–1 080
Jiang J, Hu XC, Shen WD, et al. Improved Ionic Conductivity in Strained Yttria–stabilized Zirconia Thin Films[J]. Appl. Phys. Lett., 2013, 102: 143 901–143 904
Guo X, Zhang Z. Grain Size Dependent Grain Boundary Defect Structure: Case of Doped Zirconia[J]. Acta Mater., 2003, 51: 2 539–2 547
Schlupp MVF, Scherrer B, Ma H, et al. Influence of Microstructure on the Cross–plane Oxygen Ion Conductivity of Yttria Stabilized Zirconia Thin Films[J]. Phys. Status Solidi A, 2012, 209 (8): 1 414–1 422
Avila–Paredes HJ, Kim S. The Effect of Segregated Transition Metal Ions on the Grain Boundary Resistivity of Gadolinium Doped Ceria: Alteration of the Space Charge Potential[J]. Solid State Ionics, 2006, 177: 3 075–3 080
Gerstl M, Navickas E, Friedbacher G, et al. The Separation of Grain and Grain Boundary Impedance in Thin Yttria Stabilized Zirconia (YSZ) Layers[J]. Solid State Ionics, 2011, 185: 32–41
Kosacki I, Suzuki T, Petrovsky V, et al. Electrical Conductivity of Nanocrystalline Ceria and Zirconia Thin Films[J]. Solid State Ionics, 2000, 136: 1 225–1 233
Kosacki I, Rouleau CM, Becher PF, et al. Surface/Interface–Related Conductivity in Nanometer Thick YSZ Films[J]. Electrochem. and Solid–State Lett., 2004, 7 (12): A459–A461
Uvarov NF. Estimation of Composites Conductivity Using a General Mixing Rule[J]. Solid State Ionics, 2000, 136–137: 1 267–1 272
Guo X. Can We Achieve Significantly Higher Ionic Conductivity in Nanostructured Zirconia[J]. Scr. Mater., 2011, 65: 96–101
De Souza RA, Pietrowski MJ, Anselmi–Tamburini U, et al. Oxygen Diffusion in Nanocrystalline Yttria–stabilized Zirconia: The Effect of Grain Boundaries[J]. Phys. Chem. Chem. Phys., 2008, 10: 2 067–2 072
Author information
Authors and Affiliations
Corresponding author
Additional information
Funded by the National Natural Science Foundation of China (51462018)
Rights and permissions
About this article
Cite this article
Yang, Q., Lin, Z., Meng, B. et al. Effects of Thickness on the Electrical Conductivity of Sputtered YSZ Film with Nanocrystalline Columnar Microstructure. J. Wuhan Univ. Technol.-Mat. Sci. Edit. 33, 1344–1349 (2018). https://doi.org/10.1007/s11595-018-1972-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11595-018-1972-z