Advertisement

Journal of Superconductivity and Novel Magnetism

, Volume 26, Issue 9, pp 2969–2973 | Cite as

Influence of Tensile Force During Preparation on Internal Stress of Glass-Coated Microwires

  • Kaihuang Liu
  • Zhichao Lu
  • Tiancheng Liu
  • Deren Li
Original Paper
  • 108 Downloads

Abstract

The influence of drawing speed taken as the index of tensile force during preparation on the internal stress of glass-coated microwires with nominal composition Co68.2Fe4.3Cr3.5Si13B11 and Fe45Co20Ni10Si9B16 is presented. The obtained results show that drawing speed has influence on the critical length to observe magnetic bistability and the value of switching field. Further researches show that the internal tensile stress increases by 220–300 MPa when the drawing speed rises by 100 m/min. This study confirmed the existence and magnitude of internal stress induced by tensile force during preparation proposed by Chiriac et al.

Keywords

Internal stress Drawing speed Magnetic microwires Magnetostriction 

Notes

Acknowledgements

This work was financially supported by the National Natural Science Foundation of China under Grant No. 50771034.

References

  1. 1.
    Chiriac, H., Ovari, T.A.: Amorphous glass-covered magnetic wires: preparation, properties, applications. Prog. Mater. Sci. 40, 333–407 (1996) CrossRefGoogle Scholar
  2. 2.
    Zhukov, A.: Glass-coated magnetic microwires for technical applications. J. Magn. Magn. Mater. 242–245, 216–223 (2002) CrossRefGoogle Scholar
  3. 3.
    Vázquez, M., Chiriac, H., Zhukov, A., Panina, L., Uchiyama, T.: On the state-of-the-art in magnetic microwires and expected trends for scientific and technological studies. Phys. Status Solidi A 208, 493–501 (2011) ADSCrossRefGoogle Scholar
  4. 4.
    Rodionova, V., Ipatov, M., Ilyn, M., Zhukova, V., Perov, N., Gonzalez, J., Zhukov, A.: Tailoring of magnetic properties of magnetostatically-coupled glass-covered magnetic microwires. J. Supercond. Nov. Magn. 24, 541–547 (2011) CrossRefGoogle Scholar
  5. 5.
    Qin, F., Peng, H.X.: Ferromagnetic microwires enabled multifunctional composite materials. Prog. Mater. Sci. 58, 183 (2013) CrossRefGoogle Scholar
  6. 6.
    Aragoneses, P., Blanco, J.M., Cobeño, A.F., Dominguez, L., Gonzalez, J., Zhukov, A., Larin, V.: Stress dependence of the switching field in Co-rich amorphous microwires. J. Magn. Magn. Mater. 196–197, 248–250 (1999) CrossRefGoogle Scholar
  7. 7.
    Zuberek, R., Szymczak, H., Gutowski, M., Zhukov, A., Zhukova, V., Usov, N.A., Garcia, K., Vazquez, M.: Internal stress influence on FMR in amorphous glass-coated microwires. J. Magn. Magn. Mater. 316, e890–e892 (2007) ADSCrossRefGoogle Scholar
  8. 8.
    Baranov, S.A., Berzhanskii, V.N., Zotov, S.K.: Ferromagnetic resonance in amorphous magnetic wires. Fiz. Met. Metalloved. 67, 73–78 (1989) Google Scholar
  9. 9.
    Chiriac, H., Óvári, T.A., Pop, G.: Internal stress distribution in glass-covered amorphous magnetic wires. Phys. Rev. B 52, 10104–10113 (1995) ADSCrossRefGoogle Scholar
  10. 10.
    Chiriac, H., Óvári, T.A., Pop, G., Barariu, F.: Internal stresses in highly magnetostrictive glass-covered amorphous wires. J. Magn. Magn. Mater. 160, 237–238 (1996) ADSCrossRefGoogle Scholar
  11. 11.
    Zhukov, A., Zhukova, V.: Magnetic Properties and Applications of Ferromagnetic Microwires with Amorphous and Nanocrystalline Structure. Nova Science, New York (2009) Google Scholar
  12. 12.
    Narita, K., Yamasaki, J., Fukunaga, H.: Measurement of saturation magnetostriction of a thin amorphous ribbon by means of small-angle magnetization rotation. IEEE Trans. Magn. 16, 435–439 (1980) ADSCrossRefGoogle Scholar
  13. 13.
    Yamasaki, J., Ohkubo, Y., Humphrey, F.: Magnetostriction measurement of amorphous wires by means of small-angle magnetization rotation. J. Appl. Phys. 67, 5472 (1990) ADSCrossRefGoogle Scholar
  14. 14.
    Chiriac, H., Neagu, M., Vazquez, M., Ovari, T.A., Hristoforou, E.: Stress dependence of the saturation magnetostriction in Co68.15Fe4.35Si12.5B15 glass-covered amorphous wires. J. Magn. Magn. Mater. 249, 122–125 (2002) ADSCrossRefGoogle Scholar
  15. 15.
    Chiriac, H., Neagu, M., Vazquez, M., Hristoforou, E.: Saturation magnetostriction measurement in nearly zero magnetostrictive Co-rich glass-covered amorphous wires. J. Magn. Magn. Mater. 242–245, 251–253 (2002) CrossRefGoogle Scholar
  16. 16.
    Hernando, A., Vázquez, M., Madurga, V., Ascasibar, E., Liniers, M.: Influence of the anisotropy on the “SAMR” method for measuring magnetostriction in amorphous ribbons. J. Magn. Magn. Mater. 61, 39–47 (1986) ADSCrossRefGoogle Scholar
  17. 17.
    Barandiarán, J.M., Hernando, A., Madurga, V., Nielsen, O.V., Vázquez, M., Vázquez-López, M.: Temperature, stress, and structural-relaxation dependence of the magnetostriction in (Co0.94Fe0.06)75Si15B10 glasses. Phys. Rev. B 35, 5066–5071 (1987) ADSCrossRefGoogle Scholar
  18. 18.
    Liu, K.H., Lu, Z.C., Li, D.R., Liu, T.C., Zhou, S.X.: Domain structure and magnetization process in short glass-coated amorphous microwires with positive magnetostriction. Chin. Phys. Lett. 29, 107502 (2012) ADSCrossRefGoogle Scholar
  19. 19.
    Zhukova, V., Usov, N.A., Zhukov, A., Gonzalez, J.: Length effect in a Co-rich amorphous wire. Phys. Rev. B 65, 134407 (2002) ADSCrossRefGoogle Scholar
  20. 20.
    Kronmüller, H.: Theory of nucleation fields in inhomogeneous ferromagnets. Phys. Status Solidi B 144, 385–396 (1987) ADSCrossRefGoogle Scholar
  21. 21.
    Severino, A.M., Gómez-Polo, C., Marín, P., Vázquez, M.: Influence of the sample length on the switching process of magnetostrictive amorphous wire. J. Magn. Magn. Mater. 103, 117–125 (1992) ADSCrossRefGoogle Scholar
  22. 22.
    Vazquez, M., Hernando, A.: A soft magnetic wire for sensor applications. J. Phys. D, Appl. Phys. 29, 939 (1996) ADSCrossRefGoogle Scholar
  23. 23.
    Hernando, A., González, J., Blanco, J.M., Vázquez, M., Barandiarán, J.M., Rivero, G., Ascasibar, E.: Influence of the structural rearrangements on the stress sensitivity of magnetostriction in a Co-rich amorphous alloy. Phys. Rev. B 46, 3401–3404 (1992) ADSCrossRefGoogle Scholar
  24. 24.
    Marín, P., Hernando, A., Buschow, K.H.J., Robert, W.C., Merton, C.F., Bernard, I., Edward, J.K., Subhash, M., Patrick, V.: Magnetic microwires: manufacture, properties, and applications. In: Encyclopedia of Materials: Science and Technology, pp. 1–9. Elsevier, Oxford (2004) CrossRefGoogle Scholar

Copyright information

© Springer Science+Business Media New York 2013

Authors and Affiliations

  • Kaihuang Liu
    • 1
  • Zhichao Lu
    • 1
  • Tiancheng Liu
    • 1
  • Deren Li
    • 1
  1. 1.China Iron and Steel Research Institute GroupAdvanced Technology and Materials Co., Ltd.BeijingChina

Personalised recommendations