Abstract
This paper presents a new multilayer arrangement structure based on the dielectric polymer, which allows an effective absorption of magnetic wave radiation, and a selective reflection of desired wavelengths of the shield composite in the low frequency range that is not widely used in general cases. This is caused by the impedance mismatch between conductive films and air, and between conductive films and dielectric polymer layer. The structure is built from alternating conductive films and dielectric polymer layers, in a way that dielectric polymer layers are sandwiched between conductive films symmetrically in both directions. The simulation results of both the absorption and the total shielding effectiveness from the developing analytical model are in good agreement with experimental characterization, and could be further extended to the design of systems operating in other frequency ranges.
Similar content being viewed by others
References
Z. Qu, S. Liu, Q. Wang, Y. Wang, Y. Lei, Electromagnetic shielding properties of multilayered composites containing multiple inclusions with various spatial distributions. Mater. Lett. 109, 42–45 (2013)
A. Frikha, M. Bensetti, F. Duval, N. Benjelloun, F. Lafon, L. Pichon, A new methodology to predict the magnetic shielding effectiveness of enclosures at low frequency in the near field. IEEE Trans. Magn. 51(3), 1–4 (2015)
J. Huo, L. Wang, H. Yu, Polymeric nanocomposites for electromagnetic wave absorption. J. Mater. Sci. 44, 3917–3927 (2009)
M. Najim, P. Smitha, V. Agarwala, D. Singh, Design of light weight multi-layered coating of zinc oxide-iron-graphite nano-composites for ultra-wide bandwidth microwave absorption. J. Mater. Sci. Mater. Electron. 26, 7367–7377 (2015)
E. Tan, Y. Kagawa, A.F. Dericioglu, Electromagnetic wave absorption potential of SiC-based ceramic woven fabrics in the GHz range. J. Mater. Sci. 44, 1172–1179 (2009)
Y. Danlée, C. Bailly, I. Huynen, Thin and flexible multilayer polymer composite structures for effective control of microwave electromagnetic absorption. Compos. Sci. Technol. 100, 182–188 (2014)
Y. Danlée, I. Huynen, C. Bailly, Frequency-selective multilayer electromagnetic bandgap structure combining carbon nanotubes with polymeric or ceramic substrates. Appl. Phy. Lett. 105, 123118 (2014)
H. Wang, D. Zhu, W. Zhou, F. Luo, Synthesis and microwave absorbing properties of Ni–Cu ferrite/ MWCNTs composites. J. Mater. Sci. Mater. Electron. 26, 7698–7704 (2015)
G. Shuchao, D. Yuping, D. Peng, W. Song, Q. Guoping, L. Yuzhe, Investigation of the absorption properties of the alloys Fe–Ni and Fe–Ni–Cr prepared by mechanical alloying. J. Electron. Mater. 44(7), 2331 (2015)
E. Pellicer, A. Varea, K.M. Sivaraman, S. Pané, S. Surinach, M.D. Baró, J. Nogués, B.J. Nelson, J. Sort, Grain boundary segregation and interdiffusion effects in nickel–copper alloys: an effective means to improve the thermal stability of nanocrystalline nickel. ACS Appl. Mater. Interfaces 3, 2265–2274 (2011)
K. Ji, H. Zhao, J. Zhang, J. Chen, Z. Dai, Fabrication and electromagnetic interference shielding performance of open-cell foam of a Cu–Ni alloy integrated with CNTs. Appl. Surf. Sci. 311, 351–356 (2014)
G. Shi, W. Li, Y. Lu, Fe-based surface activator for electroless nickel deposition on polyester: application to electromagnetic shielding. Surf. Coat. Technol. 253, 221–226 (2014)
R.R. Bonaldi, E. Siores, T. Shah, Characterization of electromagnetic shielding fabrics obtained from carbon nanotube composite coatings. Synth. Met. 187, 1–8 (2014)
J.M. Thomassin, C. Jérome, T. Pardoen, C. Bailly, I. Huynen, C. Detrembleur, Polymer/carbon based composites as electromagnetic interference (EMI) shielding materials. Mater. Sci. Eng. R 74, 211–232 (2013)
M.H. Al-Saleh, W.H. Saadeh, U. Sundararaj, EMI shielding effectiveness of carbon based nanostructured polymeric materials: a comparative study. Carbon 60, 146–156 (2013)
Y. Liu, D. Song, C. Wu, J. Leng, EMI shielding performance of nanocomposites with MWCNTs, nanosized Fe3O4 and Fe. Compos. B 63, 34–40 (2014)
B. Zhao, G. Shao, B. Fan, W. Zhao, R. Zhang, Enhanced microwave absorption capabilities of Ni microspheres after coating with SnO2 nanoparticles. J. Mater. Sci. Mater. Electron. 26, 5393–5399 (2015)
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Nedjem, Z., Seghier, T. & Hadjadj, A. New multilayer arrangement of dielectric layers for enhancement of the magnetic shielding absorption at low frequency in the near field. J Mater Sci: Mater Electron 27, 3202–3208 (2016). https://doi.org/10.1007/s10854-015-4145-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10854-015-4145-2