Abstract
The green sheet of an alumina filler/glass matrix, which is a glass–ceramic based on an anorthite and diopside composite, is a low-fired substrate material for microelectronic packaging. In this study, alumina/glass sheets were prepared using a tape-casting process. The mechanical and dielectric properties of the sintered bodies were examined as a function of the sintering temperature. The volume of the crystalline phases was considered with the peak area of the XRD intensity for evaluating the alumina/glass composite. The flexural strength and dielectric properties of the sintered alumina/glass composites were 167.2 ± 13.1 MPa for the four-point bending test, 5.51 for the dielectric constant and 2,078 MHz for the quality factor, respectively. The dielectric constant was dependent on the volume of crystalline phases present.
Similar content being viewed by others
References
Tummala RR (1991) J Am Ceram Soc 74:895
Sprague JL (1990) IEEE Trans Comp Hybrids Manuf Technol 13:390
Hwang S, Kim H (2007) Thermochim Acta 455:119
Hwang SJ, Kim YJ, Kim HS (2007) J Electroceram 18:121
Lo CL, Duh JG (2003) J Mater Sci 38:693. doi:https://doi.org/10.1023/A:1021836326089
Lo CL, Duh JG (2002) J Am Ceram Soc 85:2230
Shimada Y, Yamashita Y, Takamizawa H (1988) IEEE Trans Comp Hybrids Manuf Technol 11:163
Marques VMF, Tulyaganov DU, Agathopoulos S, Gataullin VK, Kothiyal GP, Ferreira JMF (2006) J Eur Ceram Soc 26:2503
Zhang Q, Luo X, Li W, Zhuang H, Yan D (2003) J Mater Sci 38:1781. doi:https://doi.org/10.1023/A:1023292113547
Hayashi K, Nishoka Y, Okamto Y (1990) J Ceram Soc Jpn 95:801
Karamanov A, Arrizza L, Matekovits I, Pelino M (2004) Ceram Int 30:2129
Chen GH, Liu XY (2007) J Mater Process Technol 190:77
Kim J, Hwang S, Kim H (in press) J Electroceram. doi:https://doi.org/10.1007/s10832-007-9395-9
Kim HS, Rawlings RD, Rogers PS (1989) Br Ceram Proc 42:59
Kingery WD, Bowen HK, Uhlman DR (1976) Introduction to ceramics. Wiley, New York, p 793
Rice RW (1998) Porosity of ceramics. Marcel Dekker, Inc., New York, p 10
Gdula RA (1971) Ceram Bull 50:555
MatWeb, Material Property Data, (Automation Creations, Inc., 1996) (https://doi.org/www.matweb.com)
Molla J, Gonzalez M, Vila R, Ibarra A (1998) J Appl Phys 85:1727
Valant M, Suvorov D (2003) Mater Chem Phys 79:104
Penn SJ, Aiford NM, Templeton A, Wang X, Xu M, Reece M, Schrapel K (1997) J Am Ceram Soc 80:1885
Acknowledgements
This work was supported by the IT R&D program of MIC/IITA [2006-s055-02, Ceramic Material and Process for High Integrated Module], the Ministry of Education and Human Resources Development (MOE), the Ministry of Commerce, Industry and Energy (MOCIE) and the Ministry of Labor (MOLAB) through the fostering project of the Lab of Excellency.
Author information
Authors and Affiliations
Corresponding author
Additional information
Jinho Kim and Seongjin Hwang equally contributed to the article.
Rights and permissions
About this article
Cite this article
Kim, J., Hwang, S., Sung, W. et al. Effect of anorthite and diopside on dielectric properties of Al2O3/glass composite based on high strength of LTCC substrate. J Mater Sci 43, 4009–4015 (2008). https://doi.org/10.1007/s10853-007-2231-4
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10853-007-2231-4