Skip to main content
Log in

An Efficacy Evaluation of Water Mist Protection Against Solid Combustible Fires in Open Environment

  • Published:
Fire Technology Aims and scope Submit manuscript

Abstract

CEN and NFPA standards have accepted water mist for protecting solid combustible fires more challenging than light hazard fires in open environment, but with little data in the public domain to support such applications. Therefore, a series of exploratory experiments was conducted to evaluate the efficacy of fire suppression in open environment by water mist sprays for a rack storage of corrugated cardboard cartons on wood pallets (Fire A), and for a palletized storage of cartoned plastics stacked on wood pallets (Fire B). Both are in the accepted hazard categories by both standards. Representative water mist sprays were employed to provide water application densities of 4.1 mm/min and 6.1 mm/min for Fire A, and 8.1 mm/min for Fire B. These sprays had downward thrust forces ranging from 18 N to 73 N per spray, and volume median droplet diameters from 75 µm to 345 µm. A standard ½-in. pendent sprinkler was also employed to provide the suppression performance references for these two fire hazards. In each experiment, four open sprinklers or nozzles were centered 1.7 m above the fuel array with nozzle spacing ranging from 2.6 × 2.6 m to 3 × 3 m. All experiments were conducted under a 20-MW calorimeter with no ceiling presence. Water discharge in each experiment was started at a designated fire convective heat release rate of 1000 kW. The experiments indicated that, for the same application density, not all water mist sprays having different characteristics would lead to a comparable fire suppression result. Therefore, each water mist system should be tested individually for the same intended protection. Furthermore, the results showed that when water mist protection was effective, it required application densities comparable to those of sprinkler protection to provide comparable fire suppression results in open environment under the present experimental conditions.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Figure 1
Figure 2
Figure 3
Figure 4
Figure 5
Figure 6

Similar content being viewed by others

References

  1. IMO A.800(19) (1995) Revised Guidelines for Approvals of Sprinkler Systems Equivalent to That Referred to SOLAS Regulation II-2/12, International Maritime Organization, London, UK

  2. Bill RG, Ural EA (1999) Water mist protection of combustion turbine enclosures. In: Proceedings of the 6th international symposium on fire safety science, pp 458–468

  3. Wu PK, Alpert RL (1998) Recent advances in fine water spray technology: protection of an open semiconductor wet bench. 14th Meeting of the UJNR Panel on Fire Research and Safety, Tokyo, Japan

  4. Liu Z, Carpenter DW, Kim AK (2005) Application of water mist to extinguish large oil pool fires for industrial cooker protection. In: Proceedings of the 8th international symposium on fire safety science, pp 741–752

  5. Vuorisalo M (2008) Implementation of water mist systems in road tunnels—project case studies. In: 3rd international symposium on tunnel safety and security, Stockholm, Sweden

  6. Liu Z, Kim AK (2001) A review of water mist fire suppression technology: part II—application studies. J Fire Prot Eng 11: 16–42

    Article  Google Scholar 

  7. Arvidson M (2014) Large-scale water spray and water mist fire suppression system tests for the protection of ro-ro cargo decks on ships. Fire Technol 50: 589–610

    Article  Google Scholar 

  8. CEN/TS 14972 (2011) Fixed firefighting systems—watermist systems—design and installation. European Committee for Standardization, Brussels

  9. NFPA 750 (2014) Standard on water mist fire protection systems. National Fire Protection Association, Quincy, MA, USA

  10. NFPA 13 (2016) Standard for the installation of sprinkler systems. National Fire Protection Association, Quincy, MA, USA

  11. Yu H-Z, Lee JL, Kung H-C (1994) Suppression of rack-storage fires by water. In: Proceedings of the 4th international symposium on fire safety science, pp 901–912

  12. You H-Z, Kung H-C (1984) Strong buoyant plumes of growing rack storage fires. In: Proceedings of the 20th symposium (international) on combustion. The Combustion Institute, pp 1547–1554

  13. Heskestad G (1986) Fire plume entrainment according to two competing assumptions. In: Proceedings of the 21st symposium (international) on combustion, The Combustion Institute, pp 111–120

  14. Stockham JD, Fochtman EG (1977) Particle size analysis. Ann Arbor Science Publishers, Ann Arbor

    Google Scholar 

  15. Schlichting H (1968) Boundary layer theory. McGraw-Hill Book Company, New York

    MATH  Google Scholar 

  16. Ertesvag IS, Magnussen BF (2000) The eddy dissipation turbulence energy cascade model. Combust Sci Technol 159: 213–235

    Article  Google Scholar 

  17. Wagnanski I, Fiedler H (1969) Some measurements in the self-preserving jet. J Fluid Mech 38(3): 577–612

    Article  Google Scholar 

  18. Tewarson A, Chaos M, Khan MM (2016) Combustion characteristics of materials and generation of fire products. In: Hurley M (ed) SFPE handbook of fire protection engineering. Springer, New York, Chap. 36

  19. Croce PA (1976) A Method for improved measurement of gas concentration histories in rapidly developing fires. Combust Sci Technol 14: 221–228

    Article  Google Scholar 

  20. Nam S (1996) Development of a computational model simulating the interaction between a fire plume and a sprinkler spray. Fire Saf J 26: 1–33

    Article  Google Scholar 

  21. Rasbash DJ (1962) The extinction of fires by water sprays. Fire Res Abstr Rev 4: 28–53

    Google Scholar 

Download references

Acknowledgements

The helpful comments and suggestions provided by Drs. Sergey Dorofeev and Franco Tamanini of FM Global on this article are greatly appreciated.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Hong-Zeng Yu.

Additional information

Publisher's Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Yu, HZ., Liu, X. An Efficacy Evaluation of Water Mist Protection Against Solid Combustible Fires in Open Environment. Fire Technol 55, 343–361 (2019). https://doi.org/10.1007/s10694-018-0793-0

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10694-018-0793-0

Keywords

Navigation