Abstract
A number of studies in the published literature deal with gas holdup in three-phase reactors. However, very few address the cases in which the solid density approaches that of the liquid phases and in which low gas velocities are involved. These conditions are commonly encountered in immobilized-cell bubble columns and in fluidized-bed bioreactors. This paper reports the effect of gas and liquid velocity upon gas holdup and bed expansion in fluidized-bed bioreactors.
For liquid-fluidization of low-density alginate beads in the absence of gas, the terminal sedimentation velocity (vT) of the particles is a constant, and expansion of the bed follows Richardson and Zaki’s correlation. In the presence of gas, however, the apparent terminal sedimentation velocity value is affected by the velocity of the gas and liquid phases. For gas velocities above a minimum value, the calculated value of vT depends on liquid velocity only, and a constant bed expansion was observed for a range of gas and liquid flow rates. For the gas-liquid interactions, a modified drift-flux model was found to be valid. For superficial gas velocities between 5 and 17 cm/min, the modified drift-flux velocity was observed to be a function of gas velocity, suggesting the prevalence of a coalescence regime.
Similar content being viewed by others
Abbreviations
- k:
-
ratio of fractions of wake and gas phases
- n:
-
exponent in Richardson and Zaki’s equation
- uB :
-
rise velocity of bubbles, cm/min
- uB∞:
-
terminal rise velocity of bubbles, cm/min
- ug :
-
superficial gas velocity, cm/min
- uL:
-
superficial liquid velocity, cm/min
- vg-L:
-
drift-flux velocity, cm/min
- vT:
-
sedimentation velocity of the solids, cm/min
- vT* :
-
a pseudo settling velocity
- X:
-
ratio of fractions of solids in the wake and in the liquid
- α:
-
exponent in the drift-flux model
- Eg :
-
gas holdup
- EL :
-
liquid holdup
- Es :
-
solid holdup
References
Godia, F., Casas, C., and Sola, C. (1987),Process Biochem. 22(2), 43.
Scott, C. D. (1983),Biotechnol. Bioeng. Symp. 13, 287.
Hamamci, H. and Ryu, D. D. Y. (1987),Biotechnol. Bioeng. 29, 994.
Donaldson, T. L.,et al. (1984),Environ. Prog. 3, 248.
Duss, I. J.,et al. (1983),Ann. NY Acad. Sci. 413, 168.
Deo, Y. M. and Gaucher, G. M. (1984),Biotechnol. Bioeng. 28, 73.
Kim, J. H.,et al. (1984),Biotechnol. Bioeng. 28, 1838.
Muroyama, K. and Fan. L. D. (1985),AlChE J. 31, 1–34.
Richardson, J. F. and Zaki, W. N. (1954),Trans. Instn. Chem. Engrs. 32, 35.
Epstein, N. (1983),Handbook of Fluids in Motion, Cheremisinoff, N. P. and Gupta, R., eds., Ann Arbor Sci., Ann Arbor, Michigan, p. 1165.
Darton, R. C. and Harrison, D. (1975),Chem. Eng. Sci. 30, 581.
El-Temtamy, S. A. and Epstein, N. (1978),Int. J. Multiphase Flow,4, 19.
Stewart, P. S. B. and Davidson, J. F. (1964),Chem. Eng. Sci.,19, 319.
Ostergaard, K. (1965),Chem. Eng. Sci.,20, 165.
Bhatia, V. K. and Epstein, N. (1974),Fluidization and its Applications, H, Angelinoet al., eds., p. 372.
Wallis, G. B. (1969),One Dimensional Two Phase Flow, McGraw-Hill, New York.
Sohn, P. U.-N. (1988), PhD thesis, Chemical Engineering Department, University of Missouri—Columbia.
Davison, B. H. (1989),Appl. Biochem. Biotechnol. 20/21, 449.
Davison, B.H. (1990), Proceedings of Biochemical Engineering VI,Ann. NY Acad. Sci., in press.
Begovich, J. M. (1978), Hydrodynamics of Three-Phase Fluidized Beds, ORNL/TM-6448, Oak Ridge National Laboratory, Oak Ridge, Tennessee.
Su, H. (1988), MS Thesis, Chemical Engineering Department, University of Missouri—Columbia.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Bajpai, R., Thompson, J.E. & Davison, B.H. Gas holdup in three-phase immobilized-cell bioreactors. Appl Biochem Biotechnol 24, 485–496 (1990). https://doi.org/10.1007/BF02920272
Issue Date:
DOI: https://doi.org/10.1007/BF02920272