Advertisement

Laboratory Study on Single Stone Columns Reinforced with Steel Bars and Discs

  • Mehdi Mohammad Rezaei
  • Seyed Hamid LajevardiEmail author
  • Hamidreza Saba
  • Abbas Ghalandarzadeh
  • Ehsanollah Zeighami
Original Paper
  • 17 Downloads

Abstract

Stone columns are widely used as an effective and environmental friendly improvement method for increasing the load-carrying capacity of soft clay soils. In very soft clay soils, reinforced stone columns are used because of the lack of the lateral confinement created by the surrounding soil. To provide lateral additional confinement, geosynthetics are usually used. This study intends to evaluate the use of vertical steel bars and horizontal steel discs as an alternative way to geosynthetics to investigate the effect of reinforcement on the footing load-carrying characteristics. Therefore, some large-scale laboratory tests were conducted on stone columns with diameters of 80 and 100 mm and a length to diameter of 5. The results show that changing the arrangement of the bars to a higher stiffness leads to increase in load-carrying capacity. Reinforcing the full-length of the stone columns with the bars in comparison to half-length reinforced has significant influence in capacity. However, in the case of horizontal discs, this increase is negligible. Also by decreasing the space of the discs, load-carrying capacity increases. Moreover, the performance of the vertical reinforced stone column seemed to be better than the horizontal reinforced stone column. The increase of load-carrying capacity in reinforced stone columns with vertical bars or horizontal discs is higher than geotextile reinforcement in the same conditions.

Keywords

Stone column Laboratory study Vertical reinforcing bars Horizontal reinforcing discs Improvement factor 

References

  1. 1.
    Greenwood DA (1970) Mechanical improvement of soils belowground surfaces. Proceedings of Conference on Ground Engineering, Institute of Civil Engineers, London, pp. 11–22Google Scholar
  2. 2.
    Vesic AS (1972) Expansion of cavities in infinite soil mass. J Soil Mech Found Div 98(SM3):265–290Google Scholar
  3. 3.
    Hughes JMO, Withers NJ (1974) Reinforcing of the soft cohesive soils with granular columns. Ground Eng 7(3):42–49Google Scholar
  4. 4.
    Aboshi H, Ichimoto E, Harada K, Emoki M (1979) The composer—a method to improve the characteristics of soft clays by inclusion of large diameter sand columns. Proceedings International Conference on Soil Reinforcement, Paris, pp. 211–216Google Scholar
  5. 5.
    Barksdale RD, Bachus RC (1983) Design and construction of stone columns. Report No. FHWA/RD-83/026, Office of Engineering and Highway Operations Research and Development. Federal Highway Administration, Washington, DCGoogle Scholar
  6. 6.
    Bergado DT, Anderson LR, Miura N, Balasubramaniam AS (1996) Soft ground improvement in lowland and other environments. ASCE, New YorkGoogle Scholar
  7. 7.
    Munfakh GA, Sarkar SK, Castelli RJ (1983) Performance of a test embankment founded on stone columns. Proceedings of the International Conference on Advances in Piling and Ground Treatment for Foundation, Thomas Telford, London, pp. 259–265Google Scholar
  8. 8.
    Han J, Ye SL (1992) Settlement analysis of buildings on the soft clays stabilized by stone columns. Proceedings International Conference on Soil Improvement and Pile Foundation, vol 118, pp. 446–451Google Scholar
  9. 9.
    Han J, Ye SL (2001) Simplified method for consolidation rate of stone column reinforced foundation. J Geotech Geoenviron Eng 127(7):597–603CrossRefGoogle Scholar
  10. 10.
    Castro J, Cimentada A, Costa A, Canizal J, Sagaseta C (2013) Consolidation and deformation around stone columns: comparison of theoretical and laboratory results. Comput Geotech 49:326–337.  https://doi.org/10.1016/j.compgeo.2012.09.004 CrossRefGoogle Scholar
  11. 11.
    Balaam NP, Booker JR (1985) Effect of stone column yield on settlement of rigid foundations in stabilized clay. Int J Numer Anal Meth Geomech 9(4):331–351CrossRefGoogle Scholar
  12. 12.
    Priebe HJ (1995) The design of vibro replacement. Ground Eng 28(10):31–37Google Scholar
  13. 13.
    Hughes JMO, Withers NJ, Greenwood DA (1975) Field trial of reinforcing effect of a stone column in soil. Geotechnique 25(1):31–44.  https://doi.org/10.1680/geot.1975.25.1.31 CrossRefGoogle Scholar
  14. 14.
    Madhav MR, Vitkar PP (1978) Strip footing on weak clay stabilized with a granular trench or pile. Can Geotech J 15(4):605–609.  https://doi.org/10.1139/t78-066 CrossRefGoogle Scholar
  15. 15.
    Madhav MR, Miura N (1994) Soil improvement. Panel report on stone columns. In: Proceedings of the 13th International Conference on Soil Mechanics and Foundation Engineering, New Delhi, India, vol 5, pp. 163–164Google Scholar
  16. 16.
    Van Impe WF (1989) Soil improvement techniques and their evolution. Balkema, RotterdamGoogle Scholar
  17. 17.
    Raithel M, Kempfert HG (2000) Calculation model for dam foundations with geotextile coated sand columns. In: International Conference on Geotechnical and Geological Engineering, Melbourne, AustraliaGoogle Scholar
  18. 18.
    Alexiew D, Brokemper D, Lothspeich S (2005) Geotextile encased columns (GEC): load capacity, geotextile selection and pre-design graphs. In: Geo-frontiers Conference, Austin, Texas 497–510.  https://doi.org/10.1061/40777(156)12
  19. 19.
    Murugesan S, Rajagopal K (2007) Model tests on geosynthetic-encased stone columns”. Geosynth Int 14(6):346–354.  https://doi.org/10.1680/gein.2007.14.6.346 CrossRefGoogle Scholar
  20. 20.
    Murugesan S, Rajagopal K (2010) Studies on the behavior of single and group of geosynthetic encased stone columns. J Geotech Geoenviron Eng 136(1):129–139.  https://doi.org/10.1061/(ASCE)GT.1943-5606.0000187 CrossRefGoogle Scholar
  21. 21.
    Lo SR, Zhang R, Mak J (2010) Geosynthetic-encased stone columns in soft clay: a numerical study. Geotext Geomembr 28(3):292–302.  https://doi.org/10.1016/j.geotexmem.2009.09.015 CrossRefGoogle Scholar
  22. 22.
    Ghazavi M, Afshar JN (2013) Bearing capacity of geosynthetic encased stone columns”. Geotext Geomembr 38:26–36.  https://doi.org/10.1016/j.geotexmem.2013.04.003 CrossRefGoogle Scholar
  23. 23.
    Hong YS, Wu CS, Yu YS (2016) Model tests on geotextile-encased granular columns under 1-g and undrained conditions. Geotext Geomembr 44(1):13–27.  https://doi.org/10.1016/j.geotexmem.2015.06.006 MathSciNetCrossRefGoogle Scholar
  24. 24.
    Miranda M, Costa AD (2016) Laboratory analysis of encased stone columns. Geotext Geomembr 44(3):269–277.  https://doi.org/10.1016/j.geotexmem.2015.12.001 CrossRefGoogle Scholar
  25. 25.
    Hasan M, Samadhiya NK (2016) Experimental and numerical analysis of geosynthetic-reinforced floating granular piles in soft clays. Int J Geosynth Ground Eng 2(22):1–3.  https://doi.org/10.1007/s40891-016-0062-6 CrossRefGoogle Scholar
  26. 26.
    Muzammil SP, Varghese RM, Joseph J (2018) Numerical simulation of the response of geosynthetic encased stone columns under oil storage tank. Int J Geosynth Ground Eng 4(4):1–12.  https://doi.org/10.1007/s40891-017-0122-6 CrossRefGoogle Scholar
  27. 27.
    Lajevardi SH, Enami S, Hamidi M, Shamsi HR (2018) Experimental study of single and groups of stone columns encased by geotextile. J Sci Technol.  https://doi.org/10.22060/CEEJ.2018.12789.5269 CrossRefGoogle Scholar
  28. 28.
    Lajevardi SH, Shamsi HR, Hamidi M, Enami S (2018) Numerical and experimental studies on single stone columns. Soil Mech Found Eng 55(5):340–345.  https://doi.org/10.1007/s11204-018-9546-9 CrossRefGoogle Scholar
  29. 29.
    Madhav MR, Alamghir M, Miura N (1994) Improving granular column capacity by geogrid reinforcement. In: Proceedings of the 5th International Conference on Geotextiles, Geomembranes and Related Products, Singapore, pp. 351–356Google Scholar
  30. 30.
    Malarvizhi SN, Ilamparuthi K (2007) Comparative study on the behavior of encased stone column and conventional stone column. Soils Found 47(5):873–885.  https://doi.org/10.3208/sandf.47.873 CrossRefGoogle Scholar
  31. 31.
    Gniel J, Bouazza A (2009) Improvement of soft soils using geogrid encased stone columns. Geotext Geomembr 27(3):167–175.  https://doi.org/10.1016/j.geotexmem.2008.11.001 CrossRefGoogle Scholar
  32. 32.
    Yoo C, Lee D (2012) Performance of geogrid-encased stone columns in soft ground: full-scale load tests. Geosynth Int 19(6):480–490.  https://doi.org/10.1680/gein.12.00033 CrossRefGoogle Scholar
  33. 33.
    Dash SK, Bora MC (2013) Influence of geosynthetic encasement on the performance of stone columns floating in soft clay. Can Geotech J 50:754–765.  https://doi.org/10.1139/cgj-2012-0437 CrossRefGoogle Scholar
  34. 34.
    Gu M, Zhao M, Zhang L, Han J (2016) Effects of geogrid encasement on lateral and vertical deformations of stone columns in model tests. Geosynth Int 23(2):100–112.  https://doi.org/10.1680/jgein.15.00035 CrossRefGoogle Scholar
  35. 35.
    Debnath P, Dey AK (2017) Bearing capacity of geogrid reinforced sand over encased stone columns in soft clay. Geotext Geomembr 45(6):653–664.  https://doi.org/10.1016/j.geotexmem.2017.08.006 CrossRefGoogle Scholar
  36. 36.
    Shivashankar R, Babu MRD, Nayak S, Manjunath R (2010) Stone columns with vertical circumferential nails: laboratory model study. Geotech Geol Eng 28(5):695–706.  https://doi.org/10.1007/s10706-010-9329-1 CrossRefGoogle Scholar
  37. 37.
    Shivashankar R, Babu MRD, Nayak S (2011) Performance of stone columns with circumferential nails. Proc Inst Civil Eng 164(2):97–106.  https://doi.org/10.1680/grim.2011.164.2.97 CrossRefGoogle Scholar
  38. 38.
    Madhav MR (1982) Recent development in the use and analysis of granular piles. In: Proceedings of Symposium on Recent Development in Ground Improvement Techniques, Bangkok, pp. 117–129Google Scholar
  39. 39.
    Sharma RS, Phani Khumar BR, Nagendra G (2004) Compressive load response of granular piles reinforced with geogrids. Can Geotech J 41(1):187–192.  https://doi.org/10.1139/t03-075 CrossRefGoogle Scholar
  40. 40.
    Samadhiya NK, Maheshwari P, Zsaki A, Basu P, Kundu A (2009) Strengthening of clay by geogrid reinforced granular pile. Int J Geotech Eng 3:377–386.  https://doi.org/10.3328/IJGE.2009.03.03.377-386 CrossRefGoogle Scholar
  41. 41.
    Hasan M, Samadhiya NK (2016) Soft soils improvement by granular piles reinforced with horizontal geogrid strips. Int J Geotech Eng 12(1):101–108.  https://doi.org/10.1680/grim.2011.164.2.97 CrossRefGoogle Scholar
  42. 42.
    Ghazavi M, Yamchi AE, Afshar JN (2018) Bearing capacity of horizontally layered geosynthetic reinforced stone. Geotext Geomembr 46:312–318.  https://doi.org/10.1016/j.geotexmem.2018.01.002 CrossRefGoogle Scholar
  43. 43.
    Ali K, Shahu JT, Sharma KG (2012) Model tests on geosynthetic-reinforced stone columns: a comparative study. Geosynth Int 19(4):292–305.  https://doi.org/10.1680/gein.12.00016 CrossRefGoogle Scholar
  44. 44.
    Ali K, Shahu JT, Sharma KG (2014) Model tests on single and groups of stone columns with different geosynthetic reinforcement arrangement. Geosynth Int 21(2):103–118.  https://doi.org/10.1680/gein.14.00002 CrossRefGoogle Scholar
  45. 45.
    Ayadat T, Hanna AM, Hamitouche A (2008) Soil improvement by internally reinforced stone columns. Proc Inst Civil Eng 161(2):55–63.  https://doi.org/10.1680/grim.2008.161.2.55 CrossRefGoogle Scholar
  46. 46.
    Wood DM, Hu W, Nash DFT (2000) Group effects in stone column foundations: model tests. Geotechnique 50(6):689–698.  https://doi.org/10.1680/geot.2000.50.6.689 CrossRefGoogle Scholar
  47. 47.
    Hamidi M, Lajevardi SH (2018) Experimental study on the load-carrying capacity of single stone columns. Int J Geosynth Ground Eng 4(26):1–10.  https://doi.org/10.1007/s40891-018-0142-x CrossRefGoogle Scholar

Copyright information

© Springer Nature Switzerland AG 2019

Authors and Affiliations

  1. 1.Department of Civil Engineering, Arak BranchIslamic Azad UniversityArakIran
  2. 2.College of Civil EngineeringAmirkabir University of TechnologyTehranIran
  3. 3.School of Civil Engineering, University College of EngineeringUniversity of TehranTehranIran

Personalised recommendations