Advertisement

Treatment of composting leachate using electro-Fenton process with scrap iron plates as electrodes

  • G. Khajouei
  • S. Mortazavian
  • A. Saber
  • N. Zamani Meymian
  • H. Hasheminejad
Original Paper
  • 17 Downloads

Abstract

Composting process of municipal solid waste is associated with the formation of a large volume of leachate containing hazardous and bio-refractory organic compounds and toxic heavy metals. This signifies the necessity for treating composting leachates. This study investigates the effectiveness of the electro-Fenton (E-Fenton) process for the treatment of a real composting leachate. The effects of various experimental parameters including reaction time, electrical current density, pH, hydrogen peroxide (H2O2) concentration, and the distance between the electrodes on the reduction in chemical oxygen demand (COD) were examined. The E-Fenton process was optimized based on the D-optimal algorithm using response surface methodology. Under optimized treatment conditions (reaction time = 100 min, initial pH = 3.0, H2O2 concentration = 0.25 M, and electrical current = 3.0 A), 63.4% of COD, 78.7% of BOD, and 99.3% of PO4–P were reduced. During the treatment process, NO3–N concentration increased from 24.12 to 40.03 mg/L. The experiments showed that the distance between the electrodes in the studied range had no significant effects on the treatment efficiency. A reduction in the biodegradability index of BOD5/COD from 0.60 to 0.31 indicated that most of the organic matter in composting leachate were biodegradable and were oxidized by the E-Fenton process. Conducting a separate set of experiments using the standard Fenton process on the same leachate resulted in 68.4% COD removal, demonstrating that the E-Fenton method could be considered as a promising and inexpensive alternative for the conventional Fenton process to treat composting leachates.

Keywords

Advanced oxidation processes (AOPs) Biodegradability index Response surface methodology (RSM) Landfill leachate Hydroxyl radical scavenger Municipal solid waste (MSW) 

Notes

Acknowledgements

This research was fully supported by Isfahan University of Technology (6-1391). The authors are thankful to Mrs. B. Harandizadeh for helpful discussions and technical assistance.

Compliance with ethical standards

Conflict of interest

The authors declare that they have no conflict of interest.

References

  1. Atmaca E (2009) Treatment of landfill leachate by using electro-Fenton method. J Hazard Mater 163:109–114.  https://doi.org/10.1016/J.JHAZMAT.2008.06.067 CrossRefGoogle Scholar
  2. Bakhshoodeh R, Alavi N, Majlesi M, Paydary P (2017) Compost leachate treatment by a pilot-scale subsurface horizontal flow constructed wetland. Ecol Eng 105:7–14.  https://doi.org/10.1016/j.ecoleng.2017.04.058 CrossRefGoogle Scholar
  3. Bokare AD, Choi W (2014) Review of iron-free Fenton-like systems for activating H2O2 in advanced oxidation processes. J Hazard Mater 275:121–135.  https://doi.org/10.1016/j.jhazmat.2014.04.054 CrossRefGoogle Scholar
  4. Brown K, Ghoshdastidar AJ, Hanmore J et al (2013) Membrane bioreactor technology: a novel approach to the treatment of compost leachate. Waste Manag 33:2188–2194.  https://doi.org/10.1016/J.WASMAN.2013.04.006 CrossRefGoogle Scholar
  5. Chou S, Huang Y-H, Lee S-N et al (1999) Treatment of high strength hexamine-containing wastewater by electro-Fenton method. Water Res 33:751–759.  https://doi.org/10.1016/S0043-1354(98)00276-0 CrossRefGoogle Scholar
  6. Clesceri LS, American Public Health Association (2005) Standard methods for the examination of water and wastewater. In: Eaton AD, Clesceri LS, Franson MAH, Greenberg AE, Rice EW, vol 21. American Public Health Association, WashingtonGoogle Scholar
  7. Deng Y, Englehardt JD (2006) Treatment of landfill leachate by the Fenton process. Water Res 40:3683–3694.  https://doi.org/10.1016/J.WATRES.2006.08.009 CrossRefGoogle Scholar
  8. Eslami H, Hashemi H, Fallahzadeh RA et al (2018) Effect of organic loading rates on biogas production and anaerobic biodegradation of composting leachate in the anaerobic series bioreactors. Ecol Eng 110:165–171.  https://doi.org/10.1016/j.ecoleng.2017.11.007 CrossRefGoogle Scholar
  9. Ghanbarzadeh Lak M, Sabour MR, Amiri A, Rabbani O (2012) Application of quadratic regression model for Fenton treatment of municipal landfill leachate. Waste Manag 32:1895–1902.  https://doi.org/10.1016/J.WASMAN.2012.05.020 CrossRefGoogle Scholar
  10. Ghosh P, Samanta AN, Ray S (2011) Reduction of COD and removal of Zn2+ from rayon industry wastewater by combined electro-Fenton treatment and chemical precipitation. Desalination 266:213–217.  https://doi.org/10.1016/J.DESAL.2010.08.029 CrossRefGoogle Scholar
  11. Khoufi S, Aloui F, Sayadi S (2006) Treatment of olive oil mill wastewater by combined process electro-Fenton reaction and anaerobic digestion. Water Res 40:2007–2016.  https://doi.org/10.1016/J.WATRES.2006.03.023 CrossRefGoogle Scholar
  12. Klauck CR, Giacobbo A, Altenhofen CG et al (2017) Toxicity elimination of landfill leachate by hybrid processing of advanced oxidation process and adsorption. Environ Technol Innov 8:246–255.  https://doi.org/10.1016/j.eti.2017.07.006 CrossRefGoogle Scholar
  13. Kurt U, Apaydin O, Gonullu MT (2007) Reduction of COD in wastewater from an organized tannery industrial region by electro-Fenton process. J Hazard Mater 143:33–40.  https://doi.org/10.1016/J.JHAZMAT.2006.08.065 CrossRefGoogle Scholar
  14. Lin SH, Chang CC (2000) Treatment of landfill leachate by combined electro-Fenton oxidation and sequencing batch reactor method. Water Res 34:4243–4249.  https://doi.org/10.1016/S0043-1354(00)00185-8 CrossRefGoogle Scholar
  15. Lopez A, Pagano M, Volpe A, Claudio Di Pinto A (2004) Fenton’s pre-treatment of mature landfill leachate. Chemosphere 54:1005–1010.  https://doi.org/10.1016/J.CHEMOSPHERE.2003.09.015 CrossRefGoogle Scholar
  16. Mahdad F, Younesi H, Bahramifar N, Hadavifar M (2016) Optimization of Fenton and photo-Fenton-based advanced oxidation processes for post-treatment of composting leachate of municipal solid waste by an activated sludge process. KSCE J Civ Eng 20:2177–2188.  https://doi.org/10.1007/s12205-015-1045-1 CrossRefGoogle Scholar
  17. Maleki A, Zazouli MA, Izanloo H, Rezaee R (2009) Composting plant leachate treatment by coagulation-flocculation process. Am J Agric Environ Sci 5:638–643Google Scholar
  18. Mohajeri S, Aziz HA, Isa MH et al (2010) Statistical optimization of process parameters for landfill leachate treatment using electro-Fenton technique. J Hazard Mater 176:749–758.  https://doi.org/10.1016/J.JHAZMAT.2009.11.099 CrossRefGoogle Scholar
  19. Morgan B, Lahav O (2007) The effect of pH on the kinetics of spontaneous Fe(II) oxidation by O2 in aqueous solution—basic principles and a simple heuristic description. Chemosphere 68:2080–2084.  https://doi.org/10.1016/j.chemosphere.2007.02.015 CrossRefGoogle Scholar
  20. Nidheesh PV, Gandhimathi R (2012) Trends in electro-Fenton process for water and wastewater treatment: an overview. Desalination 299:1–15.  https://doi.org/10.1016/J.DESAL.2012.05.011 CrossRefGoogle Scholar
  21. Parsa N, Khajouei G, Masigol M, Hasheminejad H (2018) Application of electrodialysis process for reduction of electrical conductivity and COD of water contaminated by composting leachate. Civ Eng J 4:1034–1045CrossRefGoogle Scholar
  22. Pignatello JJ, Oliveros E, MacKay A (2006) Advanced oxidation processes for organic contaminant destruction based on the Fenton reaction and related chemistry. Crit Rev Environ Sci Technol 36:1–84.  https://doi.org/10.1080/10643380500326564 CrossRefGoogle Scholar
  23. Priambodo R, Shih YJ, Huang YJ, Huang YH (2011) Treatment of real wastewater using semi batch (photo)-electro-Fenton method. Sustain Environ Res 21:389–393Google Scholar
  24. Rajabi S, Vafajoo L (2012) Investigating the treatability of a compost leachate in a hybrid anaerobic reactor: an experimental study. World Acad Sci Eng Technol 61:1175–1177Google Scholar
  25. Rosales E, Pazos M, Longo MA, Sanromán MA (2009) Electro-Fenton decoloration of dyes in a continuous reactor: a promising technology in colored wastewater treatment. Chem Eng J 155:62–67.  https://doi.org/10.1016/J.CEJ.2009.06.028 CrossRefGoogle Scholar
  26. Saber A, Hasheminejad H, Taebi A, Ghaffari G (2014) Optimization of Fenton-based treatment of petroleum refinery wastewater with scrap iron using response surface methodology. Appl Water Sci 4:283–290.  https://doi.org/10.1007/s13201-013-0144-8 CrossRefGoogle Scholar
  27. Saber A, Mortazavian S, James DE, Hasheminejad H (2017) Optimization of collaborative photo-Fenton oxidation and coagulation for the treatment of petroleum refinery wastewater with scrap iron. Water Air Soil Pollut.  https://doi.org/10.1007/s11270-017-3494-2 CrossRefGoogle Scholar
  28. Shu Z, Lü Y, Huang J, Zhang W (2016) Treatment of compost leachate by the combination of coagulation and membrane process. Chin J Chem Eng 24:1369–1374.  https://doi.org/10.1016/j.cjche.2016.05.022 CrossRefGoogle Scholar
  29. Tabatabaei SH, Najafi P, Mirzaei SMJ et al (2012) Compost’ leachate recycling through land treatment and application of natural zeolite. Int J Recycl Org Waste Agric 1:1–7.  https://doi.org/10.1186/2251-7715-1-2 CrossRefGoogle Scholar
  30. Trujillo D, Font X, Sánchez A (2006) Use of Fenton reaction for the treatment of leachate from composting of different wastes. J Hazard Mater 138:201–204.  https://doi.org/10.1016/J.JHAZMAT.2006.05.053 CrossRefGoogle Scholar
  31. Tyrrel SF, Seymour I, Harris JA (2008) Bioremediation of leachate from a green waste composting facility using waste-derived filter media. Bioresour Technol 99:7657–7664.  https://doi.org/10.1016/J.BIORTECH.2008.01.079 CrossRefGoogle Scholar
  32. Umar M, Aziz HA, Yusoff MS (2010) Trends in the use of Fenton, electro-Fenton and photo-Fenton for the treatment of landfill leachate. Waste Manag 30:2113–2121.  https://doi.org/10.1016/J.WASMAN.2010.07.003 CrossRefGoogle Scholar
  33. Wang Y, Li X, Zhen L et al (2012) Electro-Fenton treatment of concentrates generated in nanofiltration of biologically pretreated landfill leachate. J Hazard Mater 229–230:115–121.  https://doi.org/10.1016/J.JHAZMAT.2012.05.108 CrossRefGoogle Scholar
  34. Zhang H, Zhang D, Zhou J (2006) Removal of COD from landfill leachate by electro-Fenton method. J Hazard Mater 135:106–111.  https://doi.org/10.1016/J.JHAZMAT.2005.11.025 CrossRefGoogle Scholar
  35. Zhang H, Ran X, Wu X (2012) Electro-Fenton treatment of mature landfill leachate in a continuous flow reactor. J Hazard Mater 241–242:259–266.  https://doi.org/10.1016/J.JHAZMAT.2012.09.040 CrossRefGoogle Scholar
  36. Zhu X, Tian J, Liu R, Chen L (2011) Optimization of Fenton and electro-Fenton oxidation of biologically treated coking wastewater using response surface methodology. Sep Purif Technol 81:444–450.  https://doi.org/10.1016/J.SEPPUR.2011.08.023 CrossRefGoogle Scholar

Copyright information

© Islamic Azad University (IAU) 2018

Authors and Affiliations

  1. 1.Department of Civil and Environmental EngineeringWest Virginia UniversityMorgantownUSA
  2. 2.Department of Mechanical EngineeringUniversity of Nevada, Las VegasLas VegasUSA
  3. 3.Department of Civil and Environmental Engineering and ConstructionUniversity of Nevada, Las VegasLas VegasUSA
  4. 4.Department of Mechanical and Aerospace EngineeringWest Virginia UniversityMorgantownUSA
  5. 5.Department of Civil and Environmental EngineeringIsfahan University of TechnologyIsfahanIran

Personalised recommendations