Advertisement

Phosphorus recovery as calcium phosphate by a pellet reactor pre-treating domestic wastewater before entering a constructed wetland

  • A. M. RugaikaEmail author
  • R. Van Deun
  • K. N. Njau
  • B. Van der Bruggen
Original Paper
  • 8 Downloads

Abstract

Horizontal subsurface flow constructed wetlands poorly remove phosphorus from wastewater, resulting in phosphorus levels above the required limits in constructed wetland effluents. Since a pellet reactor can recover phosphorus through calcium phosphate precipitation/crystallization, using it as a pre-treatment system prior to horizontal subsurface flow constructed wetland could be a sustainable solution for phosphate scarcity. The operational conditions required for phosphate recovery in a pellet reactor were evaluated and compared with the Visual MINTEQ version 3.0 with the aim of checking its suitability to simulate the pellet reactor removal efficiencies. Such conditions include the initial phosphate concentration, pH, [Ca]/[P] molar ratio and hydraulic loading rate. The results showed an increase in phosphate removal efficiency with increased initial phosphate concentration, pH, [Ca]/[P] molar ratio and decreased hydraulic loading rate. However, the model calculation gave higher removal efficiencies than experimental results due to its inability to take into account the system kinetics which is an important component in pellet reactor operation and its assumption that precipitation reactions take place at constant pH. The effects of carbonate on phosphate precipitation were also investigated, and the removal efficiency of 61.9% without carbonate was improved to 63.2, 64.3 and 66.4% with a carbonate concentration of 0.25 mM, 0.5 mM and 2 mM, respectively, at pH 9, initial phosphate concentration of 1 mM, [Ca]/[P] molar ratio of 1.5 and hydraulic loading rate of 57 m/h. Thus, the presence of carbonates in domestic wastewater is advantageous as it promotes calcium phosphate precipitation in a pellet reactor.

Keywords

Horizontal subsurface flow constructed wetland Phosphorus Removal efficiency Saturation index Operational condition 

Notes

Acknowledgement

This work was supported by the Flemish Inter-university Council for University Development Cooperation (VLIR-UOS) through an Institutional University Cooperation (IUC) programme with the Nelson Mandela African Institution of Science and Technology (NM-AIST) with grant number ZIUS2016AP029.

Compliance with ethical standards

Conflict of interest

The authors declare that they have no conflict of interest.

References

  1. Aldaco R, Garea A, Irabien A (2007) Calcium fluoride recovery from fluoride wastewater in a fluidized bed reactor. Water Res 41:810–818CrossRefGoogle Scholar
  2. Baronne JP, Nancollas GH (1977) The seeded growth of calcium phosphates: the effect of solid/solution ratio in controlling the nature of growth phase. J Colloid Interface Sci 62(3):421–431CrossRefGoogle Scholar
  3. Boskey AL, Posner AS (1973) Conversion of amorphous calcium phosphate to microcrystalline hydroxyapatite. A pH-dependent, solution-mediated, solid–solid conversion. J Phys Chem 77(7):2313–2317CrossRefGoogle Scholar
  4. Brix H, Arias C, Del Bubba M (2001) Media selection for sustainable phosphorus removal in subsurface flow constructed wetlands. Water Sci Technol 44(11–12):47–54CrossRefGoogle Scholar
  5. Crutchik D, Morales N, Vazquez-Padin JR, Garrido JM (2017) Enhancement of struvite pellets crystallization in a full-scale plant using an industrial grade magnesium product. Water Sci Technol 75(3):609–618.  https://doi.org/10.2166/wst.2016.527 CrossRefGoogle Scholar
  6. De-Bashan LE, Bashan Y (2004) Recent advances in removing phosphorus from wastewater and its future use as fertilizer (1997–2003). Water Res 38:4222–4246.  https://doi.org/10.1016/j.watres.2004.07.014 CrossRefGoogle Scholar
  7. DHV Consulting Engineers (1991) Removing phosphate from municipal wastewater at Westerbork, The Netherlands. DHV Consulting Engineers, AmersfoortGoogle Scholar
  8. Drizo A, Frost CA, Grace J, Smith KA (1999) Physico-chemical screening of phosphate-removing substrates for use in constructed wetland systems. Water Res 33(17):3595–3602CrossRefGoogle Scholar
  9. Drizo A, Forget C, Chapuis R, Comeau Y (2006) Phosphorus removal by electric arc furnace steel slag and serpentinite. Water Res 40:1547–1554.  https://doi.org/10.1016/j.watres.2006.02.001 CrossRefGoogle Scholar
  10. Giesen A (1999) Crystallisation process enables environmental friendly phosphate removal at low costs. Environ Technol 20:769–775CrossRefGoogle Scholar
  11. Guillard D, Lewis AE (2001) Nickel carbonate precipitation in a fluidized-bed reactor. Ind Eng Chem Res 40(23):5564–5569CrossRefGoogle Scholar
  12. Kihila J, Mtei KM, Njau KN (2014) Wastewater treatment for reuse in urban agriculture; the case of Moshi. Phys Chem Earth 72–75:104–110.  https://doi.org/10.1016/j.pce.2014.10.004 CrossRefGoogle Scholar
  13. Li YM, Liu MY, Yuan ZW, Zou JT (2013) Struvite pellet crystallization in a high-strength nitrogen and phosphorus stream. Water Sci Technol 68(6):1300–1305CrossRefGoogle Scholar
  14. Mahvi AH, Shafiee F, Naddfi K (2005) Feasibility study of crystallization process for water softening in a pellet reactor. Int J Environ Sci Technol 1(4):301–304CrossRefGoogle Scholar
  15. Mekmene O, Quillard S, Rouillon T, Bouler JM, Piot M, Gaucheron F (2009) Effects of pH and Ca/P molar ratio on the quantity and crystalline structure of calcium phosphates obtained from aqueous solutions. Dairy Sci Technol 89:301–316.  https://doi.org/10.1051/dst/2009019 CrossRefGoogle Scholar
  16. Montastruc L, Azzaro-Pantel C, Biscans B, Cabassud M, Domenech S, Dibouleau L (2003) A general framework for pellet reactor modelling: application to P-recovery. Trans IChemE 81(9):1271–1278CrossRefGoogle Scholar
  17. Morse GK, Brett SW, Guy JA, Lester JN (1998) Review: phosphorus removal and recovery technologies. Sci Total Environ 212(1):69–81CrossRefGoogle Scholar
  18. Njau KN, Mwegoha WJS, Kimwaga RJ, Katima JHY (2011) Use of engineered wetlands for onsite treatment of wastewater by the local communities: experiences from Tanzania. Water Pract Technol.  https://doi.org/10.2166/wpt.2011.047 Google Scholar
  19. Seckler MM, Bransma OSC, Rosenden GM, van Ogh, JC, Delgage, J and Eggers E (1990) Phosphate removal by means of a full scale pellet reactor. In: 11th International Symposium on Industrial Crystallization, 18–20 September, Garmisch-Partenkirchen, GermanyGoogle Scholar
  20. Seckler MM, Bruinsma OSL, Van Rosmalen GM (1996) Calcium phosphate precipitation in a fluidized bed in relation to process conditions: a black box approach. Water Res 30(7):1677–1685CrossRefGoogle Scholar
  21. Seo D, Cho J, Lee H, Heo J (2005) Phosphorus retention capacity of filter media for estimating the longevity of constructed wetland. Water Res 39(11):2445–2457.  https://doi.org/10.1016/j.watres.2005.04.032 CrossRefGoogle Scholar
  22. Song Y, Hahn HH, Hoffmann E (2002) The effect of carbonate on the precipitation of calcium phosphate. Environ Technol 23:207–215CrossRefGoogle Scholar
  23. Song Y, Weidler PG, Berg U, Nuesch R, Donnert D (2006) Calcite-seeded crystallization of calcium phosphate for phosphorus recovery. Chemosphere 63:236–243CrossRefGoogle Scholar
  24. Song Y, Donnert D, Berg U, Weidler PG, Nueesch R (2007) Seed selections for crystallization of calcium phosphate for phosphorus recovery. J Environ Sci 19:591–595CrossRefGoogle Scholar
  25. Steen I (1998) Phosphorus availability in the 21st century: management of a non-renewable resource. Phosphorus Potassium 217:25–31Google Scholar
  26. Tran ATK, Zhang Y, De Corte D, Hannes J, Ye W, Mondal P, Jullock N, Meesschaert B, Pinoy L, Van der Bruggen B (2014) P-recovery as calcium phosphate from wastewater using an integrated selectrodialysis/crystallization process. J Clean Prod 77:140–151.  https://doi.org/10.1016/j.jclepro.2014.01.069 CrossRefGoogle Scholar
  27. Van Kemenade MJJM, de Bruyn PL (1987) A kinetic study of precipitation from supersaturated calcium phosphate solutions. J Colloid Interface Sci 118(2):564–585CrossRefGoogle Scholar
  28. Xuechu C, Hainan K, Deyi W, Xinze W, Yongyong L (2009) Phosphate removal and recovery through crystallization of hydroxyapatite using xonotlite as seed crystal. J Environ Sci 21:575–580.  https://doi.org/10.1016/S1001-0742(08)62310-4 CrossRefGoogle Scholar
  29. Zhou P, Huang J, Li AWF, Wei S (1999) Heavy metal removal from wastewater in fluidized bed reactor. Water Res 33(8):1918–1924CrossRefGoogle Scholar
  30. Zhu T, Jenssen PD, Maehlum T, Krogstad D (1997) Phosphorus sorption and chemical characteristics of lightweight aggregates (LWA)—potential filter media in treatment wetlands. Water Sci Technol 35(5):103–108CrossRefGoogle Scholar

Copyright information

© Islamic Azad University (IAU) 2019

Authors and Affiliations

  • A. M. Rugaika
    • 1
    • 2
    Email author
  • R. Van Deun
    • 3
  • K. N. Njau
    • 2
  • B. Van der Bruggen
    • 1
    • 4
  1. 1.Department of Chemical EngineeringKU LeuvenLeuvenBelgium
  2. 2.The Nelson Mandela African Institution of Science and TechnologyArushaTanzania
  3. 3.Thomas More University CollegeGeelBelgium
  4. 4.Faculty of Engineering and the Built EnvironmentTshwane University of TechnologyPretoriaSouth Africa

Personalised recommendations