Advertisement

Synthesis of CuO–GO/TiO2 visible light photocatalyst for 2-chlorophenol degradation, pretreatment of dairy wastewater and aerobic digestion

  • Z. O. Alafif
  • Muzammil Anjum
  • Rajeev Kumar
  • S. M. Abdelbasir
  • M. A. Barakat
Original Article
  • 16 Downloads

Abstract

In the present study, photocatalysts such as copper oxide (CuO) and titanium dioxide (TiO2) were coupled with graphene oxide (GO) for the synthesis of visible light active CuO–GO/TiO2 composite photocatalyst for the decomposition of 2-chlorophenol (2-CP) and complex aromatics in the real dairy wastewater. Photocatalytically decomposed dairy wastewater was further purified by aerobic digestion. The results revealed that composite material shows improved 2-CP degradation, as 86% removal was achieved with k = 0.0101 min−1 at pH 5.0. The effect of pollutant concentration showed that the decomposition of 2-CP increases with the increase in the irradiation time and decreases with the increase in the 2-CP concentration in the solution. The reusability test showed the high stability of CuO–GO/TiO2 composite where the 2-CP degradation was achieved 85.8% after the third run. For real dairy wastewater degradation, photocatalysis increases the solubilization of the organic matters and a 24% higher sCOD (from 5764 to 7536 mg/L after 6 h) was observed compared to photolysis (without catalyst) pretreatment. This improves the aerobic digestibility of dairy wastewater where tCOD was significantly lowered from 12747 to 134.8 mg/L within 27 days of the process. Overall, the present study revealed that the CuO–GO/TiO2 composite material could be an efficient catalyst for removal of toxic organic pollutants and treatment of dairy effluent, thus it can be applied in wastewater treatment plants with a dependency of extensively available visible light.

Keywords

Dairy wastewater 2-Chlorophenol Pretreatment Photocatalysis Graphene oxide Aerobic digestion 

Abbreviations

tCOD

Total chemical oxygen demand

sCOD

Soluble chemical oxygen demand

2-CP

2-Chlorophenol

CuO

Copper oxide

TiO2

Titanium dioxide

GO

Graphene oxide

A-PC

Aerobic photocatalytic

A-PL

Aerobic photolytic

A-RD

Aerobic untreated

XRD

X-ray diffraction

TEM

Transmission electron microscope

PLS

Photoluminescence spectroscopy

OH˚

Hydroxyl radical

e

Electrons

h+

Holes

Notes

References

  1. Adane B, Siraj K, Meka N (2015) Kinetic, equilibrium and thermodynamic study of 2-chlorophenol adsorption onto Ricinus communis pericarp activated carbon from aqueous solutions. Green Chem Lett Rev 8:1–12CrossRefGoogle Scholar
  2. Adulkar TV, Rathod VK (2014) Ultrasound-assisted enzymatic pre-treatment of high-fat content dairy wastewater. Ultrason Sonochem 21(3):1083–1089CrossRefGoogle Scholar
  3. Alamelu K, Ali J (2018) TiO2–Pt composite photocatalyst for photodegradation and chemical reduction of recalcitrant organic pollutants. J Environ Chem Eng 6(5):5720–5731CrossRefGoogle Scholar
  4. Anjum M, Al-Makishah NH, Barakat MA (2016) Wastewater sludge stabilization using pre-treatment methods. Process Saf Environ Prot 102:615–632CrossRefGoogle Scholar
  5. Anjum M, Kumar R, Barakat MA (2017a) Visible light driven photocatalytic degradation of organic pollutants in wastewater and real sludge using ZnO–ZnS/Ag2O–Ag2S nanocomposite. J Taiwan Inst Chem Eng 77:227–235CrossRefGoogle Scholar
  6. Anjum M, Oves M, Kumar R, Barakat MA (2017b) Fabrication of ZnO–ZnS@polyaniline nanohybrid for enhanced photocatalytic degradation of 2-chlorophenol and microbial contaminants in wastewater. Int Biodeterior Biodegrad 119:66–77CrossRefGoogle Scholar
  7. Anjum M, Al-Talhi HA, Mohamed SA, Kumar R, Barakat MA (2018a) Visible light photocatalytic disintegration of waste activated sludge for enhancing biogas production. J Environ Manag 216:120–127CrossRefGoogle Scholar
  8. Anjum M, Kumar R, Barakat MA (2018b) Synthesis of Cr2O3/C3N4 composite for enhancement of visible light photocatalysis and anaerobic digestion of wastewater sludge. J Environ Manag 212:65–76CrossRefGoogle Scholar
  9. Anjum M, Kumar R, Abdelbasir SM, Barakat MA (2018c) Carbon nitride/titania nanotubes composite for photocatalytic degradation of organics in water and sludge: pre-treatment of sludge, anaerobic digestion and biogas production. J Environ Manag 223:495–502CrossRefGoogle Scholar
  10. Babu SG, Karthik P, John MC, Lakhera SK, Ashokkumar M, Khim J, Neppolian B (2019) Synergistic effect of sono-photocatalytic process for the degradation of organic pollutants using CuO–TiO2/rGO. Ultrason Sonochem 50:218–223CrossRefGoogle Scholar
  11. Cammarota M, Freire D (2006) A review on hydrolytic enzymes in the treatment of wastewater with high oil and grease content. Bioresour Technol 97:2195–2210CrossRefGoogle Scholar
  12. Davarnejad R, Nikseresht M (2016) Dairy wastewater treatment using an electrochemical method: Experimental and statistical study. J Electroanal Chem 775:364–373CrossRefGoogle Scholar
  13. Feizpoor S, Habibi-Yangjeh A, Yubuta K (2018) Integration of carbon dots and polyaniline with TiO2 nanoparticles: Substantially enhanced photocatalytic activity to removal various pollutants under visible light. J Photochem Photobiol A 367:94–104CrossRefGoogle Scholar
  14. Gisella R, Samanamud L, Loures CC, Souza AL, Salazar RF, Oliveira IS, Silva MB, Izário Filho HJ (2012) Heterogeneous photocatalytic degradation of dairy wastewater using immobilized ZnO. ISRN Chem Eng 2012:1–8Google Scholar
  15. Gnanaprakasam A, Sivakumar VM, Thirumarimurugan M (2015) Influencing parameters in the photocatalytic degradation of organic effluent via nanometal oxide catalyst: a review. Indian J Mater Sci 2015:1–16CrossRefGoogle Scholar
  16. Goblos S, Portöro P, Bordás D, Kálmán M, Kiss I (2008) Comparison of the effectivities of two-phase and single-phase anaerobic sequencing batch reactors during dairy wastewater treatment. Renew Energy 33(5):960–965CrossRefGoogle Scholar
  17. Hsieh C-T, Fan W-S, Chen W-Y, Lin JY (2009) Adsorption and visible-light-derived photocatalytic kinetics of organic dye on Co-doped titania nanotubes prepared by hydrothermal synthesis. Sep Purif Technol 67:312–318CrossRefGoogle Scholar
  18. Igbinosa EO, Odjadjare EE, Chigor VN, Igbinosa IH, Emoghene AO, Ekhaise FO, Igiehon NO, Idemudia OG (2013) Toxicological profile of chlorophenols and their derivatives in the environment: the public health perspective. Sci World J 2013:11.  https://doi.org/10.1155/2013/460215 (Article ID 460215) CrossRefGoogle Scholar
  19. In SI, Vaughn DD, Schaak RE (2012) Hybrid CuO–TiO2–xNx hollow nanocubes for photocatalytic conversion of CO2 into methane under solar irradiation. Angew Chem Int Ed 51(16):3915–3918CrossRefGoogle Scholar
  20. Ivanciuc T, Ivanciuc O, Klein DJ (2006) Prediction of environmental properties for chlorophenols with posetic quantitative super-structure/property relationships (QSSPR). Int J Mol Sci 7:358–374CrossRefGoogle Scholar
  21. Janczukowicz W, Zieliński M, Debowski M (2008) Biodegradability evaluation of dairy effluents originated in selected sections of dairy production. Bioresour Technol 99(10):4199–4205CrossRefGoogle Scholar
  22. Kuśmierek K, Swikatkowski A (2015) Influence of pH on adsorption kinetics of monochlorophenols from aqueous solutions on granular activated carbon/Wp{ł}yw Ph Na Kinetyk{\k{e}} Adsorpcji Monochlorofenoli Z Roztwor{ó}w Wodnych Na Granulowanym W{\k{e}}glu Aktywnym. Ecol Chem Eng S 22:95–105Google Scholar
  23. Lee SS, Bai H, Liu Z, Sun DD (2013) Novel-structured electrospun TiO2/CuO composite nanofibers for high efficient photocatalytic cogeneration of clean water and energy from dye wastewater. Water Res 47:4059–4073CrossRefGoogle Scholar
  24. Lei M, Wang N, Zhu L, Zhou Q, Nie G, Tang H (2016) Photocatalytic reductive degradation of polybrominated diphenyl ethers on CuO/TiO2 nanocomposites: a mechanism based on the switching of photocatalytic reduction potential being controlled by the valence state of copper. Appl Catal B 182:414–423CrossRefGoogle Scholar
  25. Li Y, Li S, Jin L, Murowchick JB, Peng Z (2013) Carbon nanoparticles as an interfacial layer between TiO2-coated ZnO nanorod arrays and conjugated polymers for high-photocurrent hybrid solar cells. RSC Adv 3:16308–16312CrossRefGoogle Scholar
  26. Li C, Wang J, Guo H, Ding S (2015a) Low-temperature synthesis of polyaniline–crystalline TiO2–halloysite composite nanotubes with enhanced visible light photocatalytic activity. J Colloid Interface Sci 458:1–13CrossRefGoogle Scholar
  27. Li J, Xiao Q, Li L, Shen J, Hu D (2015b) Novel ternary composites: preparation, performance and application of ZnFe2O4/TiO2/polyaniline. Appl Surf Sci 331:108–114CrossRefGoogle Scholar
  28. Li B, Hao Y, Zhang B, Shao X, Hu L (2017) A multifunctional noble-metal-free catalyst of CuO/TiO2 hybrid nanofibers. Appl Catal A 531:1–12CrossRefGoogle Scholar
  29. Li X, Shen R, Ma S, Chen X, Xie J (2018) Graphene-based heterojunction photocatalysts. Appl Surf Sci 430:53–107CrossRefGoogle Scholar
  30. Liao CJ, Chung TL, Chen WL, Kuo SL (2007) Treatment of pentachlorophenol contaminated soil using a nano-scale zero-valent iron with hydrogen peroxide. J Mol Catal A Chem 265:189–194CrossRefGoogle Scholar
  31. Logar M, Bračko I, Potočnik A, Jančar B (2014) Cu and CuO/titanate nanobelt based network assemblies for enhanced visible light photocatalysis. Langmuir 30(16):4852–4862CrossRefGoogle Scholar
  32. Lu Z, Chen G, Hao W, Sun G, Li Z (2015) Mechanism of UV-assisted TiO 2/reduced graphene oxide composites with variable photodegradation of methyl orange. RSC Adv 5(89):72916–72922CrossRefGoogle Scholar
  33. Luna AL, Valenzuela MA, Colbeau-Justin C, Vázquez P, Rodriguez JL, Avendano JR, Alfaro S, Tirado S, Garduño A, José M (2016) Photocatalytic degradation of gallic acid over CuO–TiO2 composites under UV/Vis LEDs irradiation. Appl Catal A 521:140–148CrossRefGoogle Scholar
  34. Misra M, Singh N, Gupta RK (2017) Enhanced visible-light-driven photocatalytic activity of Au@ Ag core–shell bimetallic nanoparticles immobilized on electrospun TiO2 nanofibers for degradation of organic compounds. Catal Sci Technol 7(3):570–580CrossRefGoogle Scholar
  35. Mahmoud HR (2014) Highly dispersed Cr2O3–ZrO2 binary oxide nanomaterials as novel catalysts forethanol conversion. J Mol Catal A Chem 392:216–222CrossRefGoogle Scholar
  36. Mohamed RM, Ismail AA, Kadi MW, Bahnemann DW (2018) A comparative study on mesoporous and commercial TiO2 photocatalysts for photodegradation of organic pollutants. J Photochem Photobiol A 367:66–73CrossRefGoogle Scholar
  37. Mondal I, Pal U (2016) Synthesis of MOF templated Cu/CuO@TiO2 nanocomposites for synergistic hydrogen production. Phys Chem Chem Phys 18(6):4780–4788CrossRefGoogle Scholar
  38. Niu J, Dai P, Zhang Q, Yao B, Yu X (2018) Microwave-assisted solvothermal synthesis of novel hierarchical BiOI/rGO composites for efficient photocatalytic degradation of organic pollutants. Appl Surf Sci 430:165–175CrossRefGoogle Scholar
  39. Pedrosa M, Pastrana-Martínez LM, Pereira MFR, Faria JL, Figueiredo JL, Silva AM (2018) N/S-doped graphene derivatives and TiO2 for catalytic ozonation and photocatalysis of water pollutants. Chem Eng J 348:888–897CrossRefGoogle Scholar
  40. Pirila M, Saouabe M, Ojala S, Rathnayake B, Drault F, Valtanen A, Huuthanen M, Brahmi R, Keiski LR (2015) Photocatalytic degradation of organic pollutants in wastewater. Top Catal 14:1085–1099CrossRefGoogle Scholar
  41. Prakash J, Sun S, Swart HC, Gupta RK (2018) Noble metals-TiO2 nanocomposites: from fundamental mechanisms to photocatalysis, surface enhanced Raman scattering and antibacterial applications. Appl Mater Today 11:82–135CrossRefGoogle Scholar
  42. Qamar MT, Aslam M, Ismail IM, Salah N, Hameed A (2015) Synthesis, characterization, and sunlight mediated photocatalytic activity of CuO coated ZnO for the removal of nitrophenols. ACS Appl Mater Interfaces 7(16):8757–8769CrossRefGoogle Scholar
  43. Qamsari E, Karmanshahi R, Nosrati M, Amani T (2012) Enzymatic pre-hydrolysis of high-fat content dairy wastewater as a pretreatment for anaerobic digestion. Int J Environ Res 6(2):475–480Google Scholar
  44. Qiu X, Miyauchi M, Sunada K, Minoshima M, Liu M, Lu Y, Li D, Shimodaira Y, Hosogi Y, Kuroda Y, Hashimoto K (2012) Hybrid CuxO/TiO2 nanocomposites as risk-reduction materials in indoor environments. ACS Nano 6(2):1609–1618CrossRefGoogle Scholar
  45. Qiu J, Feng Y, Zhang X, Zhang X, Jia M, Yao J (2017) Facile stir-dried preparation of gC3N4/TiO2 homogeneous composites with enhanced photocatalytic activity. RSC Adv 7:10668–10674CrossRefGoogle Scholar
  46. Rashid J, Barakat MA, Salah N, Habib SS (2014) Ag/ZnO nanoparticles thin films as visible light photocatalysts. RSC Adv 4:56892–56899CrossRefGoogle Scholar
  47. Sadollahkhani A, Nur O, Willander M, Kazeminezhad I, Khranovskyy V, Eriksson MO, Yakimova R, Holtz PO (2015) A detailed optical investigation of ZnO@ ZnS core-shell nanoparticles and their photocatalytic activity at different pH values. Ceram Int 41:7174–7184CrossRefGoogle Scholar
  48. Scuderi V, Amiard G, Sanz R, Boninelli S, Impellizzeri G, Privitera V (2017) TiO2 coated CuO nanowire array: ultrathin p–n heterojunction to modulate cationic/anionic dye photo-degradation in water. Appl Surf Sci 416:885–890CrossRefGoogle Scholar
  49. Sin J-C, Lam S-M, Mohamed AR, Lee K-T (2011) Degrading endocrine disrupting chemicals from wastewater by TiO2 photocatalysis: a review. Int J Photoenergy 2012:1–23CrossRefGoogle Scholar
  50. Singh N, Prakash J, Gupta RK (2017a) Design and engineering of high-performance photocatalytic systems based on metal oxide–graphene–noble metal nanocomposites. Mol Syst Des Eng 2(4):422–439CrossRefGoogle Scholar
  51. Singh N, Prakash J, Misra M, Sharma A, Gupta RK (2017b) Dual functional Ta-doped electrospun TiO2 nanofibers with enhanced photocatalysis and SERS detection for organic compounds. ACS Appl Mater Interfaces 9(34):28495–28507CrossRefGoogle Scholar
  52. Sohail M, Xue H, Jiao Q, Li H, Khan K, Wang S, Zhao Y (2017) Synthesis of well-dispersed TiO 2@ reduced graphene oxide (rGO) nanocomposites and their photocatalytic properties. Mater Res Bull 90:125–130CrossRefGoogle Scholar
  53. Su W, Jin L, Qu X, Huo D, Yang L (2016) Defect passivation induced strong photoluminescence enhancement of rhombic monolayer MoS2. Phys Chem Chem Phys 18(20):14001–14006CrossRefGoogle Scholar
  54. Ubani C, Ibrahim MA, Teridi MAM, Sopian K, Ali J, Chaudhary K (2016) Application of graphene in dye and quantum dots sensitized solar cell. Sol Energy 137:531–550CrossRefGoogle Scholar
  55. Walter MG, Warren EL, McKone JR, Boettcher SW, Mi Q, A.Santori E, Lewis NS (2010) Solar water-splitting cells. Chem Rev 110:6446–6473CrossRefGoogle Scholar
  56. Wang H, Zhang L, Chen Z, Hu J, Li S, Wang Z, Liu J, Wang X (2014) Semiconductor heterojunction photocatalysts: design construction, and photocatalytic performances. Chem Soc Rev 43:5234–5244CrossRefGoogle Scholar
  57. Xu H, Ding M, Chen W, Li Y, Wang K (2018) Nitrogen-doped GO/TiO2 nanocomposite ultrafiltration membranes for improved photocatalytic performance. Sep Purif Technol 195:70–82CrossRefGoogle Scholar
  58. Yu L, Chen W, Li D, Wang J, Shao Y, He M, Wang P, Zheng X (2015) Inhibition of photocorrosion and photoactivity enhancement for ZnO via specific hollow ZnO core/ZnS shell structure. Appl Catal B Environ 164:453–461CrossRefGoogle Scholar
  59. Zhang X, Chen Z (2015) The enhanced photoactivity of hydrogenated TiO2@ reduced graphene oxide with p–n junctions. RSC Adv 5(33):26328–26334CrossRefGoogle Scholar
  60. Zhang W, Guo H, Sun H, Zeng RC (2016) Hydrothermal synthesis and photoelectrochemical performance enhancement of TiO2/graphene composite in photo-generated cathodic protection. Appl Surf Sci 382:128–134CrossRefGoogle Scholar

Copyright information

© King Abdulaziz City for Science and Technology 2018

Authors and Affiliations

  1. 1.Department of Environmental Sciences, Faculty of Meteorology, Environment and Arid Land AgricultureKing Abdulaziz UniversityJiddaSaudi Arabia
  2. 2.Department of Environmental SciencesPMAS Arid Agriculture UniversityRawalpindiPakistan
  3. 3.Central Metallurgical R & D InstituteHelwanEgypt

Personalised recommendations