Advertisement

Co-vermicomposting of Wastewater Treatment Plant Sludge and Yard Waste: Investigation of Operation Parameters

  • Roda Gokce Yilmaz CincinEmail author
  • Osman Nuri Agdag
Original Paper
  • 19 Downloads

Abstract

Million tons of domestic wastewater treatment plant sludge is produced in each year. Since it increases the volume of the landfill area, the treatment of sludge with vermicomposting is an attractive approach. Vermicomposting of domestic wastewater treatment plant sludge with yard waste was carried out using Eisenia Fetida for 60 days. The effects of Bio-One™ (liquid microbial fertilizer), additives (different mature vermicomposts), recirculation and ventilation on decomposition rate of composting were investigated for composting mixtures. Temperature, moisture content (MC), organic matter (OM), pH, electrical conductivity (EC), total carbon (TOC) and total kjeldahl nitrogen (TKN) were monitored during the composting process. In addition, phototoxicity level and worm number changes of the mixtures were determined. C/N and OM value decreases ranged between 27.56–63.77% and 15.15–43.12%, respectively. It was concluded that vermicomposting process was faster than traditional composting process in terms of decomposition of organic matter. The result C/N ratio was more suitable to use it as soil remedial material in vermicomposting process. It has been shown that Bio-One™ addition has a positive effect on the acceleration of the process. It has been found that the process of recirculation some of the leachate formed during the vermicomposting process is an advantageous. It has been determined that mature vermicompost addition is an effective method. The final worm numbers were higher (except ventilation conditions) than the initial. The positive results of the plant growth tests on the final products in all cases may indicate that the products will not cause any toxic effect in the use as soil conditioning material.

Graphic Abstract

Keywords

Bio-One™ Recirculation Sewage sludge Ventilation Vermicomposting 

Notes

References

  1. 1.
    Liu, W., Huo, R., Xu, J., Liang, S., Li, J., Zhao, T., Wang, S.: Effects of biochar on nitrogen transformation and heavy metals in sludge composting. Bioresour. Technol. 235, 43–49 (2017)CrossRefGoogle Scholar
  2. 2.
    Muscolo, A., Papalia, T., Settineri, G., Mallamaci, C., Jeske-Kaczanowska, A.: Are raw materials or composting conditions and time that most influence the maturity and/or quality of composts? Comparison of obtained composts on soil properties. J. Clean. Prod. 195, 93–101 (2018)CrossRefGoogle Scholar
  3. 3.
    Sinha, R.K., Agarwal, S., Chauhan, K., Chandran, V., Soni, B.K.: Vermiculture technology: reviving the dreams of Sir Charles Darwin for scientific use of earthworms in sustainable development programs. Technol. Invest. 01, 155–172 (2010)CrossRefGoogle Scholar
  4. 4.
    Suthar, S.: Vermicomposting potential of Perionyx sansibaricus (Perrier) in different waste materials. Bioresour. Technol. 98, 1231–1237 (2007)CrossRefGoogle Scholar
  5. 5.
    Khwairakpam, M., Bhargava, R.: Vermitechnology for sewage sludge recycling. J. Hazard. Mater. 161, 948–954 (2009)CrossRefGoogle Scholar
  6. 6.
    Mowla, D., Tran, H.N., Allen, D.G.: A review of the properties of biosludge and its relevance to enhanced dewatering processes. Biomass Bioenerg. 58, 365–378 (2013)CrossRefGoogle Scholar
  7. 7.
    Najjari, F., Ghasemi, S.: Changes in chemical properties of sawdust and blood powder mixture during vermicomposting and the effects on the growth and chemical composition of cucumber. Sci. Hortic. 232, 250–255 (2018)CrossRefGoogle Scholar
  8. 8.
    Azizi, A.B., Lim, M.P.M., Noor, Z.M., Abdullah, N.: Vermiremoval of heavy metal in sewage sludge by utilising Lumbricus rubellus. Ecotoxicol. Environ. Saf. 90, 13–20 (2013)CrossRefGoogle Scholar
  9. 9.
    Rodrigues, A.S.L., Mesak, C., Silva, M.L.G., Silva, G.S., Leandro, W.M., Malafaia, G.: Organic waste vermicomposting through the addition of rock dust inoculated with domestic sewage wastewater. J. Environ. Manag. 196, 651–658 (2017)CrossRefGoogle Scholar
  10. 10.
    Wang, L., Zhang, Y., Lian, J., Chao, J., Gao, Y., Yang, F., Zhang, L.: Impact of fly ash and phosphatic rock on metal stabilization and bioavailability during sewage sludge vermicomposting. Bioresour. Technol. 136, 281–287 (2013)CrossRefGoogle Scholar
  11. 11.
    Malińska, K., Golańska, M., Caceres, R., Rorat, A., Weisser, P., Ślęzak, E.: Biochar amendment for integrated composting and vermicomposting of sewage sludge—The effect of biochar on the activity of Eisenia fetida and the obtained vermicompost. Bioresour. Technol. 225, 206–214 (2017)CrossRefGoogle Scholar
  12. 12.
    Li, S., Li, D., Li, J., Li, G., Zhang, B.: Evaluation of humic substances during co-composting of sewage sludge and corn stalk under different aeration rates. Bioresour. Technol. 245, 1299–1302 (2017)CrossRefGoogle Scholar
  13. 13.
    Suthar, S.: Vermistabilization of municipal sewage sludge amended with sugarcane trash using epigeic Eisenia fetida (Oligochaeta). J. Hazard. Mater. 163, 199–206 (2009)CrossRefGoogle Scholar
  14. 14.
    Soobhany, N.: Remediation potential of metalliferous soil by using extracts of composts and vermicomposts from Municipal Solid Waste. Process Saf. Environ. Prot. 118, 285–295 (2018)CrossRefGoogle Scholar
  15. 15.
    Soobhany, N.: Preliminary evaluation of pathogenic bacteria loading on organic municipal solid waste compost and vermicompost. J. Environ. Manag. 206, 763–767 (2018)CrossRefGoogle Scholar
  16. 16.
    Suleiman, H., Rorat, A., Grobelak, A., Grosser, A., Milczarek, M., Płytycz, B., Kacprzak, M., Vandenbulcke, F.: Determination of the performance of vermicomposting process applied to sewage sludge by monitoring of the compost quality and immune responses in three earthworm species: Eisenia fetida, Eisenia andrei and Dendrobaena veneta. Bioresour. Technol. 241, 103–112 (2017)CrossRefGoogle Scholar
  17. 17.
    Munroe, G.: Manual of on-farm vermicomposting and vermiculture. Org. Agric. Centre Canada 39, 40 (2007)Google Scholar
  18. 18.
    Dominiguez, J., Edwards, C.A.: Effects of stocking rate and moisture content on the growth and maturation of Eisenia andrei (Oligochaeta) in pig manure. Soil Biol. Biochem. 29, 743–746 (1997)CrossRefGoogle Scholar
  19. 19.
    Sponza, D.T., Aǧdaǧ, O.N.: Impact of leachate recirculation and recirculation volume on stabilization of municipal solid wastes in simulated anaerobic bioreactors. Process Biochem. 39, 2157–2165 (2004)CrossRefGoogle Scholar
  20. 20.
    Hait, S., Tare, V.: Optimizing vermistabilization of waste activated sludge using vermicompost as bulking material. Waste Manag. 31, 502–511 (2011)CrossRefGoogle Scholar
  21. 21.
    Hait, S., Tare, V.: Vermistabilization of primary sewage sludge. Bioresour. Technol. 102, 2812–2820 (2011)CrossRefGoogle Scholar
  22. 22.
    Kaushik, P., Garg, V.K.: Vermicomposting of mixed solid textile mill sludge and cow dung with the epigeic earthworm Eisenia foetida. Bioresour. Technol. 90, 311–316 (2003)CrossRefGoogle Scholar
  23. 23.
    Malińska, K., Zabochnicka-Światek, M., Cáceres, R., Marfà, O.: The effect of precomposted sewage sludge mixture amended with biochar on the growth and reproduction of Eisenia fetida during laboratory vermicomposting. Ecol. Eng. 90, 35–41 (2016)CrossRefGoogle Scholar
  24. 24.
    Lalander, C.H., Komakech, A.J., Vinnerås, B.: Vermicomposting as manure management strategy for urban small-holder animal farms—Kampala case study. Waste Manag. 39, 96–103 (2015)CrossRefGoogle Scholar
  25. 25.
    Jackson, M.L.: Soil Chemical Analysis. Prentice Hall of India Private Limited, New Delhi (1973)Google Scholar
  26. 26.
    Rynk, R.: On-farm composting handbook. NRAES-54 Natural Resource Agriculture and Engineering Service, New York (1992)Google Scholar
  27. 27.
    Varank, G.: Aerobik Olarak Stabilize Edilmiş Kati Atiklar ile Kompost Ürününün Karşilaştirilmasi (2006)Google Scholar
  28. 28.
    Graves, R.E., Hattemer, G.M.: Chapter 2 Composting. In: Pierce, W. (ed.) Part 637 Environmental Engineering National Engineering Handbook. United States Department of Agriculture Natural Resources Conservation Service, Washington (2010)Google Scholar
  29. 29.
    Arumugam, K., Renganathan, S., Babalola, O.O., Muthunarayanan, V.: Investigation on paper cup waste degradation by bacterial consortium and Eudrillus eugeinea through vermicomposting. Waste Manag. 74, 185–193 (2018)CrossRefGoogle Scholar
  30. 30.
    Lazcano, C., Gómez-Brandón, M., Domínguez, J.: Comparison of the effectiveness of composting and vermicomposting for the biological stabilization of cattle manure. Chemosphere 72, 1013–1019 (2008)CrossRefGoogle Scholar
  31. 31.
    Kaur, A., Singh, J., Vig, A.P., Dhaliwal, S.S., Rup, P.J.: Cocomposting with and without eisenia fetida for conversion of toxic paper mill sludge to a soil conditioner. Bioresour. Technol. 101, 8192–8198 (2010)CrossRefGoogle Scholar
  32. 32.
    Molina, M.J., Soriano, M.D., Ingelmo, F., Llinares, J.: Stabilisation of sewage sludge and vinasse bio-wastes by vermicomposting with rabbit manure using Eisenia fetida. Bioresour. Technol. 137, 88–97 (2013)CrossRefGoogle Scholar
  33. 33.
    Kougias, P.G., Kotsopoulos, T.A., Martzopoulos, G.G.: Effect of feedstock composition and organic loading rate during the mesophilic co-digestion of olive mill wastewater and swine manure. Renew. Energy 69, 202–207 (2014)CrossRefGoogle Scholar
  34. 34.
    Suthar, S., Mutiyar, P.K., Singh, S.: Vermicomposting of milk processing industry sludge spiked with plant wastes. Bioresour. Technol. 116, 214–219 (2012)CrossRefGoogle Scholar
  35. 35.
    Kebibeche, H., Khelil, O., Kacem, M., Kaid Harche, M.: Addition of wood sawdust during the co-composting of sewage sludge and wheat straw influences seeds germination. Ecotoxicol. Environ. Saf. 168, 423–430 (2019)CrossRefGoogle Scholar
  36. 36.
    Meng, L., Zhang, S., Gong, H., Zhang, X., Wu, C., Li, W.: Improving sewage sludge composting by addition of spent mushroom substrate and sucrose. Bioresour. Technol. 253, 197–203 (2018)CrossRefGoogle Scholar
  37. 37.
    Garcia, C., Hernández, T., Costa, F., Ayuso, M.: Evaluation of the maturity of municipal waste compost using simple chemical parameters. Commun. Soil Sci. Plant Anal. 23, 1501–1512 (1992)CrossRefGoogle Scholar
  38. 38.
    Senesi, N.: Composted materials as organic fertilizers. Sci. Total Environ. 81–82, 521–542 (1989)CrossRefGoogle Scholar
  39. 39.
    Sangwan, P., Kaushik, C.P., Garg, V.K.: Vermiconversion of industrial sludge for recycling the nutrients. Bioresour. Technol. 99, 8699–8704 (2008)CrossRefGoogle Scholar
  40. 40.
    Gupta, R., Garg, V.K.: Stabilization of primary sewage sludge during vermicomposting. J. Hazard. Mater. 153, 1023–1030 (2008)CrossRefGoogle Scholar
  41. 41.
    Morais, F.M.C., Queda, C.A.C.: Study of storage influence on evolution of stability and maturity properties of MSW composts. In: Proceedings of the fourth International Conference of ORBIT association on Biological Processing of Organics: Advances for a sustainable Society Part II, Perth, Australia (2003)Google Scholar
  42. 42.
    Mupambwa, H.A., Ravindran, B., Mnkeni, P.N.S.: Potential of effective micro-organisms and Eisenia fetida in enhancing vermi-degradation and nutrient release of fly ash incorporated into cow dung-paper waste mixture. Waste Manag. 48, 165–173 (2016)CrossRefGoogle Scholar
  43. 43.
    Negi, R., Suthar, S.: Degradation of paper mill wastewater sludge and cow dung by brown-rot fungi Oligoporus placenta and earthworm (Eisenia fetida) during vermicomposting. J. Clean. Prod. 201, 842–852 (2018)CrossRefGoogle Scholar
  44. 44.
    Eklind, Y., Kirchmann, H.: Composting and storage of organic household waste with different litter amendments. II: nitrogen turnover and losses. Bioresour. Technol. 74(2), 125–133 (2000)CrossRefGoogle Scholar
  45. 45.
    Vig, A.P., Singh, J., Wani, S.H., Dhaliwal, S.S.: Vermicomposting of tannery sludge mixed with cattle dung into valuable manure using earthworm Eisenia fetida (Savigny). Bioresour. Technol. 102, 7941–7945 (2011)CrossRefGoogle Scholar
  46. 46.
    Gong, X., Li, S., Carson, M.A., Chang, S.X., Wu, Q., Wang, L., An, Z., Sun, X.: Spent mushroom substrate and cattle manure amendments enhance the transformation of garden waste into vermicomposts using the earthworm Eisenia fetida. J. Environ. Manag. 248, 109263 (2019)CrossRefGoogle Scholar
  47. 47.
    Yadav, A., Garg, V.K.: Biotransformation of bakery industry sludge into valuable product using vermicomposting. Bioresour. Technol. 274, 512–517 (2019)CrossRefGoogle Scholar
  48. 48.
    Mahaly, M., Senthilkumar, A.K., Arumugam, S., Kaliyaperumal, C., Karupannan, N.: Vermicomposting of distillery sludge waste with tea leaf residues. Sustain. Environ. Res. 28(5), 223–227 (2018)CrossRefGoogle Scholar
  49. 49.
    Taeporamaysamai, O., Ratanatamskul, C.: Co-composting of various organic substrates from municipal solid waste using an on-site prototype vermicomposting reactor. Int. Biodeterior. Biodegrad. 113, 357–366 (2016)CrossRefGoogle Scholar
  50. 50.
    ADAS: Assessment of options and requirements for stability and maturity testing of composts. The Waste and Resources Action Programme, Banbury (2005)Google Scholar
  51. 51.
    Brinton, W.F.: Compost quality standards & guidelines. (2000)Google Scholar
  52. 52.
    Wu, D., Yu, X., Chu, S., Jacobs, D.F., Wei, X., Wang, C., Long, F., Chen, X., Zeng, S.: Alleviation of heavy metal phytotoxicity in sewage sludge by vermicomposting with additive urban plant litter. Sci. Total Environ. 633, 71–80 (2018)CrossRefGoogle Scholar
  53. 53.
    Alavi, N., Daneshpajou, M., Shirmardi, M., Goudarzi, G., Neisi, A., Babaei, A.A.: Investigating the efficiency of co-composting and vermicomposting of vinasse with the mixture of cow manure wastes, bagasse, and natural zeolite. Waste Manag. 69, 117–126 (2017)CrossRefGoogle Scholar
  54. 54.
    Bhat, S.A., Singh, J., Vig, A.P.: Effect on growth of earthworm and chemical parameters during vermicomposting of pressmud sludge mixed with cattle dung mixture. Proced. Environ. Sci. 35, 425–434 (2016)CrossRefGoogle Scholar
  55. 55.
    Dey, M.D., Das, S., Kumar, R., Doley, R., Bhattacharya, S.S., Mukhopadhyay, R.: Vermiremoval of methylene blue using Eisenia fetida: A potential strategy for bioremediation of synthetic dye-containing effluents. Ecol. Eng. 1006, 200–208 (2017)CrossRefGoogle Scholar

Copyright information

© Springer Nature B.V. 2019

Authors and Affiliations

  1. 1.Department of Environmental EngineeringPamukkale UniversityPamukkaleTurkey

Personalised recommendations