Partial Substitution of Margarine by Microencapsulated Chia Seeds Oil in the Formulation of Cookies
- 23 Downloads
Partial substitution of margarine by microencapsulated chia oil (rich in n-3 and n-6 fatty acids) in carnauba wax solid lipid microparticles was investigated, to obtain cookies containing omega-3 and omega-6. The microparticles were prepared by the hot homogenisation in which the lipid phase is molten and dispersed as small droplets in an aqueous phase followed by a cooling/solidification step. Cookies were produced using only margarine (control) and also with partial substitution of margarine by microencapsulated chia oil (15% and 30%wt). Texture profile analysis results of the cookie dough (pre-baking) were affected (p < 0.05) by partial substitution; however, the puncture force of the baked cookies was not impacted. The α-linolenic acid concentration increased 48.5 and 110.4%, respectively, when compared with the control sample, and the atherogenicity and·thrombogenicity indexes were significantly reduced. The thermal behaviour of the microparticles was similar before and after incorporation into the cookies (differential scanning calorimetry), despite melting during baking of the cookies. Cookies with 30%wt substitution exhibited the highest storage colour stability. Changes in the cookie moisture sorption were detected due to the presence of the microcapsules, which is probably an indication of water immobilisation by sodium caseinate used in the particle formulation. Sensory analysis demonstrated good acceptability for the sample with 15%wt margarine substitution.
KeywordsAtherogenicity Thrombogenicity Texture profile analysis Differential scanning calorimetry Moisture sorption isotherm Microstructure
Authors thank the CMCM (Centro Multiusuário de Caracterização de Materiais, UTFPR-Campus Curitiba, Brazil) for the SEM analysis.
This study was financially supported by CAPES.
Compliance with Ethical Standards
This work was approved by the Ethics Committee in Research of the Federal Technological University of Parana (UTFPR), Brazil, under protocol number 67425317.0.0000.5547.
- Collar, C., Andreu, P., & Martinez-Anaya, M. a. (1998). Interactive effects of flour, starter and enzyme on bread dough machinability. Zeitschrift Fur Lebensmittel-Untersuchung Und-Forschung a-Food Research and Technology, 207(2), 133–139. https://doi.org/10.1007/s002170050307.CrossRefGoogle Scholar
- Davidov-Pardo, G., Moreno, M., Arozarena, I., Marín-Arroyo, M. R., Bleibaum, R. N., & Bruhn, C. M. (2012). Sensory and consumer perception of the addition of grape seed extracts in cookies. Journal of Food Science, 77(12), S430–S438. https://doi.org/10.1111/j.1750-3841.2012.02991.x.CrossRefPubMedGoogle Scholar
- de Almeida, M. M. C., Francisco, C. R. L., de Oliveira, A., de Campos, S. S., Bilck, A. P., Fuchs, R. H. B., et al. (2018). Textural, color, hygroscopic, lipid oxidation, and sensory properties of cookies containing free and microencapsulated chia oil. Food and Bioprocess Technology, 11(5), 1–14. https://doi.org/10.1007/s11947-018-2057-x.CrossRefGoogle Scholar
- Fuchs, R. H. B., Ribeiro, R. P., Matsushita, M., Tanamati, A. A. C., Bona, E., & de Souza, A. H. P. (2013). Enhancement of the nutritional status of Nile tilapia (Oreochromis niloticus) croquettes by adding flaxseed flour. LWT - Food Science and Technology, 54(2), 440–446. https://doi.org/10.1016/j.lwt.2013.07.004.CrossRefGoogle Scholar
- Garsetti, M., Balentine, D. A., Zock, P. L., Blom, W. A. M., & Wanders, A. J. (2016). Fat composition of vegetable oil spreads and margarines in the USA in 2013: A national marketplace analysis. International Journal of Food Sciences and Nutrition, 67(4), 372–382. https://doi.org/10.3109/09637486.2016.1161012.CrossRefPubMedPubMedCentralGoogle Scholar
- Guimarães-Inácio, A., Francisco, C. R. L., Rojas, V. M., Leone, R. D. S., Valderrama, P., Bona, E., et al. (2018). Evaluation of the oxidative stability of chia oil-loaded microparticles by thermal, spectroscopic and chemometric methods. LWT - Food Science and Technology, 87, 498–506. https://doi.org/10.1016/j.lwt.2017.09.031.CrossRefGoogle Scholar
- Hartman, L., & Lago, R. C. (1973). Rapid preparation of fatty acid methyl esters from lipids. Laboratory practice, 22(6), 475–476.Google Scholar
- Lutz, I. A. (2008). Métodos químicos e físicos para análise de alimentos, 4. ed. São PauloGoogle Scholar
- Martin, J. M., Miranda, R. A., Barella, L. F., Palma-Rigo, K., Alves, V. S., Fabricio, G. S., et al. (2016). Maternal diet supplementation with n-6/n-3 essential fatty acids in a 1.2: 1.0 ratio attenuates metabolic dysfunction in MSG-induced obese mice. International Journal of Endocrinology, 2016, 1–10. https://doi.org/10.1155/2016/9242319.CrossRefGoogle Scholar
- Mcguire, R. G. (1992). Reporting of objective color measurements. HortScience, 27(12), 1254–1255.Google Scholar
- Milinsk, M. C., Matsushita, M., Visentainer, J. V., De Oliveira, C. C., & De Souza, N. E. (2008). Comparative analysis of eight esterification methods in the quantitative determination of vegetable oil fatty acid methyl esters (FAME). Journal of the Brazilian Chemical Society, 19(8), 1475–1483. https://doi.org/10.1590/S0103-50532008000800006.CrossRefGoogle Scholar
- Ng, S. H., Robert, S. D., Wan Ahmad, W. A. N., & Wan Ishak, W. R. (2017). Incorporation of dietary fibre-rich oyster mushroom (Pleurotus sajor-caju) powder improves postprandial glycaemic response by interfering with starch granule structure and starch digestibility of biscuit. Food Chemistry, 227, 358–368. https://doi.org/10.1016/j.foodchem.2017.01.108.CrossRefPubMedGoogle Scholar
- Nishibori, S., & Kawakishi, S. (1992). Effect of various sugars on the quality of baked cookies. Cereal Chemistry, 69(2), 160–163.Google Scholar
- O’Brien, C. M., Chapman, D., Neville, D. P., Keogh, M. K., & Arendt, E. K. (2003). Effect of varying the microencapsulation process on the functionality of hydrogenated vegetable fat in shortdough biscuits. Food Research International, 36(3), 215–221. https://doi.org/10.1016/S0963-9969(02)00139-4.CrossRefGoogle Scholar
- Rao, B. D., Anis, M., Kalpana, K., Sunooj, K. V., Patil, J. V., & Ganesh, T. (2016). Influence of milling methods and particle size on hydration properties of sorghum flour and quality of sorghum biscuits. LWT - Food Science and Technology, 67, 8–13. https://doi.org/10.1016/j.lwt.2015.11.033.CrossRefGoogle Scholar
- Rodrigues, M. G. G., Santos, E. F., Sanches, F. L. F. Z., Novello, D., Manhani, M. R., & Neumann, M. (2014). Desenvolvimento de cookies adicionados de farinha de yacon (Smallanthus sonchifolius): caracterização química e aceitabilidade sensorial entre portadores de Diabetes Mellitus. Revista do Instituto Adolfo Lutz, 73(2), 219–225. https://doi.org/10.18241/0073-98552014731608.CrossRefGoogle Scholar
- Santos-Silva, J., Bessa, R. J. B., & Santos-Silva, F. (2002). Effect of genotype, feeding system and slaughter weight on the quality of light lambs. II. Fatty acid composition of meat. Livestock Production Science, 77(2–3), 187–194. https://doi.org/10.1016/S0301-6226(02)00059-3.CrossRefGoogle Scholar
- Shimizu, F. M., Visentainer, J. V., & de Souza, N. E. (2011). Proximate composition and quantification of fatty acids in major Brazilian brands of margarine and vegetable creams marketed in Brazil. Ciência e Tecnologia de Alimentos, 31(2), 541–546. https://doi.org/10.1590/S0101-20612011000200040.CrossRefGoogle Scholar
- Škrbić, B., & Cvejanov, J. (2011). The enrichment of wheat cookies with high-oleic sunflower seed and hull-less barley flour: Impact on nutritional composition, content of heavy elements and physical properties. Food Chemistry, 124(4), 1416–1422. https://doi.org/10.1016/j.foodchem.2010.07.101.CrossRefGoogle Scholar
- Szczesniak, A. S. (2002). Texture is a sensory property, 13, 215–225.Google Scholar
- Ullah, R., Nadeem, M., Khalique, A., Imran, M., Mehmood, S., Javid, A., & Hussain, J. (2016). Nutritional and therapeutic perspectives of chia (Salvia hispanica L.): A review. Journal of Food Science and Technology, 53(4), 1750–1758. https://doi.org/10.1007/s13197-015-1967-0.CrossRefPubMedGoogle Scholar
- Umesha, S. S., Manohar, R. S., Indiramma, A. R., Akshitha, S., & Naidu, K. A. (2015). Enrichment of biscuits with microencapsulated omega-3 fatty acid (alpha-linolenic acid) rich garden cress (Lepidium sativum) seed oil: Physical, sensory and storage quality characteristics of biscuits. LWT - Food Science and Technology, 62(1), 654–661. https://doi.org/10.1016/j.lwt.2014.02.018.CrossRefGoogle Scholar
- Vrignaud, M. Y. (1977). Milk proteins, their properties and applications. CCB : Review for Chocolate, Confectionery and Bakery., 2, 11–13.Google Scholar