Advertisement

Application of progressive freezing on forward osmosis draw solute recovery

  • Huy Quang Le
  • Thi Xuan Quynh Nguyen
  • Shiao-Shing ChenEmail author
  • Chinh Cong Duong
  • Thanh Ngoc-Dan Cao
  • Hau-Ming Chang
  • Saikat Sinha Ray
  • Nguyen Cong Nguyen
Water Environmental Pollution and State of the Art Treatment Technologies
  • 67 Downloads

Abstract

Progressive freezing is a solvent purification technology with low energy requirements and high concentration efficiency. Although these advantages make it a promising technology, the technique has never been explored for draw solution recovery for forward osmosis (FO). Hence, in this study, the progressive freezing process was used to concentrate three common diluted draw solutions: NaCl, MgCl2, and EDTA-2Na with different ice front speeds, stirring rates, and initial draw solution concentrations. Effective partition and intrinsic partition constants were also evaluated. The results reveal that the freezing process can achieve a draw solution recovery rate of 99.73%, 99.06%, and 98.65% with NaCl, MgCl2, and EDTA-2Na, respectively, using an ice front speed of 0.5 cm/h, a stirring rate of 2.62 m/s, and 30% of percentage of ice phase. Higher concentration efficiency for NaCl and MgCl2 was achieved due to the high solubility of NaCl and MgCl2 increased solute diffusion into the liquid phase solutions. The concentration factors for all three draw solutions exceeded 1.9, indicating that the draw solutes could be reused for the FO process. In addition, the two mass transfer coefficients depended on the ice front speed and the stirring rates were also obtained for scaling up the experiment in the future.

Keywords

Forward osmosis Draw solution recovery Progressive freeze concentration Partition constant 

Notes

Supplementary material

11356_2019_6079_MOESM1_ESM.docx (767 kb)
ESM 1 (DOCX 767 kb)

References

  1. Achilli A, Cath TY, Childress AE (2009a) Power generation with pressure retarded osmosis: an experimental and theoretical investigation. J Membr Sci 343:42–52.  https://doi.org/10.1016/j.memsci.2009.07.006 CrossRefGoogle Scholar
  2. Achilli A, Cath TY, Childress AE (2010) Selection of inorganic-based draw solutions for forward osmosis applications. J Membr Sci 364:233–241.  https://doi.org/10.1016/j.memsci.2010.08.010 CrossRefGoogle Scholar
  3. Achilli A, Cath TY, Marchand EA, Childress AE (2009b) The forward osmosis membrane bioreactor: a low fouling alternative to MBR processes. Desalination 239:10–21.  https://doi.org/10.1016/j.desal.2008.02.022 CrossRefGoogle Scholar
  4. Alnaizy R, Aidan A, Qasim M (2013) Draw solute recovery by metathesis precipitation in forward osmosis desalination. Desalin Water Treat 51:5516–5525.  https://doi.org/10.1080/19443994.2013.770238 CrossRefGoogle Scholar
  5. Attia AAA (2010) New proposed system for freeze water desalination using auto reversed R-22 vapor compression heat pump. Desalination 254:179–184.  https://doi.org/10.1016/j.desal.2009.11.030 CrossRefGoogle Scholar
  6. Auleda JM, Raventós M, Sánchez J, Hernández E (2011) Estimation of the freezing point of concentrated fruit juices for application in freeze concentration. J Food Eng 105:289–294.  https://doi.org/10.1016/j.jfoodeng.2011.02.035 CrossRefGoogle Scholar
  7. Bai H, Liu Z, Sun DD (2011) Highly water soluble and recovered dextran coated Fe3O4 magnetic nanoparticles for brackish water desalination. Sep Purif Technol 81:392–399.  https://doi.org/10.1016/j.seppur.2011.08.007 CrossRefGoogle Scholar
  8. Dabaghian Z, Rahimpour A, Jahanshahi M (2016) Highly porous cellulosic nanocomposite membranes with enhanced performance for forward osmosis desalination. Desalination 381:117–125.  https://doi.org/10.1016/j.desal.2015.12.006 CrossRefGoogle Scholar
  9. Erlbeck L et al (2017) Investigation of the depletion of ions through freeze desalination. Desalination 407:93–102.  https://doi.org/10.1016/j.desal.2016.12.009 CrossRefGoogle Scholar
  10. Farah Hanim AH, Norfatiha AR, Ngadi N, Zakaria ZY, Mazura J (2015) Effect of coolant temperature on desalination process via progressive freeze concentration. Appl Mech Mater 695:443–446.  https://doi.org/10.4028/www.scientific.net/AMM.695.443 CrossRefGoogle Scholar
  11. Fujioka R, Wang LP, Dodbiba G, Fujita T (2013) Application of progressive freeze-concentration for desalination. Desalination 319:33–37.  https://doi.org/10.1016/j.desal.2013.04.005 CrossRefGoogle Scholar
  12. Gao W, Shao Y (2009) Freeze concentration for removal of pharmaceutically active compounds in water. Desalination 249:398–402.  https://doi.org/10.1016/j.desal.2008.12.065 CrossRefGoogle Scholar
  13. Gu X, Suzuki T, Miyawaki O (2006) Limiting partition coefficient in progressive freeze-concentration. J Food Sci 70:E546–E551.  https://doi.org/10.1111/j.1365-2621.2005.tb08317.x CrossRefGoogle Scholar
  14. Hau NT, Chen S-S, Nguyen NC, Huang KZ, Ngo HH, Guo W (2014) Exploration of EDTA sodium salt as novel draw solution in forward osmosis process for dewatering of high nutrient sludge. J Membr Sci 455:305–311.  https://doi.org/10.1016/j.memsci.2013.12.068 CrossRefGoogle Scholar
  15. Hernández E, Raventós M, Auleda JM, Ibarz A (2010) Freeze concentration of must in a pilot plant falling film cryoconcentrator. Innov Food Sci Emerg Technol 11:130–136CrossRefGoogle Scholar
  16. Jin X, Tang CY, Gu Y, She Q, Qi S (2011) Boric acid permeation in forward osmosis membrane processes: modeling, experiments, and implications. Environ Sci Technol 45:2323–2330.  https://doi.org/10.1021/es103771a CrossRefGoogle Scholar
  17. Kepner RE, Van Straten S, Weurman C (1969) Freeze concentration of volatile components in dilute aqueous solutions. J Agric Food Chem 17:1123–1127.  https://doi.org/10.1021/jf60165a023 CrossRefGoogle Scholar
  18. Kravath RE, Davis JA (1975) Desalination of sea water by direct osmosis. Desalination 16:151–155.  https://doi.org/10.1016/S0011-9164(00)82089-5 CrossRefGoogle Scholar
  19. Lemmer S, Klomp R, Ruemekorf R, Scholz R (2001) Preconcentration of wastewater through the niro freeze concentration process. Chem Eng Technol 24:485–488.  https://doi.org/10.1002/1521-4125(200105)24:5<485::AID-CEAT485>3.0.CO;2-H CrossRefGoogle Scholar
  20. Li D, Zhang X, Yao J, Simon GP, Wang H (2011) Stimuli-responsive polymer hydrogels as a new class of draw agent for forward osmosis desalination. Chem Commun 47:1710–1712CrossRefGoogle Scholar
  21. Ling MM, Chung T-S (2011) Desalination process using super hydrophilic nanoparticles via forward osmosis integrated with ultrafiltration regeneration. Desalination 278:194–202.  https://doi.org/10.1016/j.desal.2011.05.019 CrossRefGoogle Scholar
  22. Ling MM, Wang KY, Chung T-S (2010) Highly water-soluble magnetic nanoparticles as novel draw solutes in forward osmosis for water reuse. Ind Eng Chem Res 49:5869–5876.  https://doi.org/10.1021/ie100438x CrossRefGoogle Scholar
  23. Liu L, Miyawaki O, Nakamura K (1997) Progressive freeze-concentration of model liquid food. Food Sci Technol Int Tokyo 3:348–352.  https://doi.org/10.3136/fsti9596t9798.3.348 CrossRefGoogle Scholar
  24. Luo H, Wang Q, Zhang TC, Tao T, Zhou A, Chen L, Bie X (2014) A review on the recovery methods of draw solutes in forward osmosis. J Water Process Eng 4:212–223.  https://doi.org/10.1016/j.jwpe.2014.10.006 CrossRefGoogle Scholar
  25. Luo W, Phan HV, Xie M, Hai FI, Price WE, Elimelech M, Nghiem LD (2017) Osmotic versus conventional membrane bioreactors integrated with reverse osmosis for water reuse: biological stability, membrane fouling, and contaminant removal. Water Res 109:122–134.  https://doi.org/10.1016/j.watres.2016.11.036 CrossRefGoogle Scholar
  26. McGinnis RL, McCutcheon JR, Elimelech M (2007) A novel ammonia–carbon dioxide osmotic heat engine for power generation. J Membr Sci 305:13–19.  https://doi.org/10.1016/j.memsci.2007.08.027 CrossRefGoogle Scholar
  27. Melak F, Du Laing G, Ambelu A, Alemayehu E (2016) Application of freeze desalination for chromium (VI) removal from water. Desalination 377:23–27.  https://doi.org/10.1016/j.desal.2015.09.003 CrossRefGoogle Scholar
  28. Miyawaki O, Liu L, Nakamura K (2007) Effective partition constant of solute between ice and liquid phases in progressive freeze-concentration. J Food Sci 63:756–758.  https://doi.org/10.1111/j.1365-2621.1998.tb17893.x CrossRefGoogle Scholar
  29. Munshi FM, Church J, McLean R, Maier N, Sadmani AHMA, Duranceau SJ, Lee WH (2018) Dewatering algae using an aquaporin-based polyethersulfone forward osmosis membrane. Sep Purif Technol 204:154–161.  https://doi.org/10.1016/j.seppur.2018.04.077 CrossRefGoogle Scholar
  30. Nawaz MS, Gadelha G, Khan SJ, Hankins N (2013) Microbial toxicity effects of reverse transported draw solute in the forward osmosis membrane bioreactor (FO-MBR). J Membr Sci 429:323–329.  https://doi.org/10.1016/j.memsci.2012.11.057 CrossRefGoogle Scholar
  31. Nguyen HT, Nguyen NC, Chen S-S, Li C-W, Hsu H-T, Wu S-Y (2015) Innovation in draw solute for practical zero salt reverse in forward osmosis desalination. Ind Eng Chem Res 54:6067–6074CrossRefGoogle Scholar
  32. Nguyen NC et al (2018a) Optimising the recovery of EDTA-2Na draw solution in forward osmosis through direct contact membrane distillation. Sep Purif Technol 198:108–112.  https://doi.org/10.1016/j.seppur.2017.02.001 CrossRefGoogle Scholar
  33. Nguyen NC et al (2018b) Applicability of an integrated moving sponge biocarrier-osmotic membrane bioreactor MD system for saline wastewater treatment using highly salt-tolerant microorganisms. Sep Purif Technol 198:93–99.  https://doi.org/10.1016/j.seppur.2017.01.011 CrossRefGoogle Scholar
  34. Nguyen NC et al (2016a) A novel osmosis membrane bioreactor-membrane distillation hybrid system for wastewater treatment and reuse. Bioresour Technol 209:8–15.  https://doi.org/10.1016/j.biortech.2016.02.102 CrossRefGoogle Scholar
  35. Nguyen NC et al (2016b) Exploring high charge of phosphate as new draw solute in a forward osmosis–membrane distillation hybrid system for concentrating high-nutrient sludge. Sci Total Environ 557:44–50CrossRefGoogle Scholar
  36. Pradistsuwana C, Theprugsa P, Miyawaki O (2003) Measurement of limiting partition coefficient in progressive freeze-concentration. Food Sci Technol Res 9:190–192.  https://doi.org/10.3136/fstr.9.190 CrossRefGoogle Scholar
  37. Rahardianto A, Shih W-Y, Lee R-W, Cohen Y (2006) Diagnostic characterization of gypsum scale formation and control in RO membrane desalination of brackish water. J Membr Sci 279:655–668.  https://doi.org/10.1016/j.memsci.2005.12.059 CrossRefGoogle Scholar
  38. Rahman MS, Ahmed M, Chen XD (2006) Freezing-melting process and desalination: I Review of the state-of-the-art. Sep Purif Rev 35:59–96.  https://doi.org/10.1080/15422110600671734 CrossRefGoogle Scholar
  39. Rastogi NK (2016) Opportunities and challenges in application of forward osmosis in food processing. Crit Rev Food Sci Nutr 56:266–291.  https://doi.org/10.1080/10408398.2012.724734 CrossRefGoogle Scholar
  40. Ray SS, Chen S-S, Nguyen NC, Nguyen HT, Li C-W, Wang J, Yan B (2016) Forward osmosis desalination by utilizing chlorhexidine gluconate based mouthwash as a reusable draw solute. Chem Eng J 304:962–969CrossRefGoogle Scholar
  41. Ray SS, Chen S-S, Sangeetha D, Chang H-M, Thanh CND, Le QH, Ku H-M (2018a) Developments in forward osmosis and membrane distillation for desalination of waters. Environ Chem Lett 16:1247–1265CrossRefGoogle Scholar
  42. Ray SS, Chen SS, Nguyen NC, Nguyen HT, Dan NP, Thanh BX (2018b) Exploration of polyelectrolyte incorporated with Triton-X 114 surfactant based osmotic agent for forward osmosis desalination. J Environ Manag 209:346–353CrossRefGoogle Scholar
  43. Razmjou A, Barati MR, Simon GP, Suzuki K, Wang H (2013) Fast deswelling of nanocomposite polymer hydrogels via magnetic field-induced heating for emerging fo desalination. Environ Sci Technol 47:6297–6305.  https://doi.org/10.1021/es4005152 CrossRefGoogle Scholar
  44. Saito K, Irie M, Zaitsu S, Sakai H, Hayashi H, Tanioka A (2012) Power generation with salinity gradient by pressure retarded osmosis using concentrated brine from SWRO system and treated sewage as pure water. Desalin Water Treat 41:114–121.  https://doi.org/10.1080/19443994.2012.664696 CrossRefGoogle Scholar
  45. Sánchez J, Ruiz Y, Raventós M, Auleda JM, Hernández E (2010) Progressive freeze concentration of orange juice in a pilot plant falling film. Innov Food Sci Emerg Technol 11:644–651.  https://doi.org/10.1016/j.ifset.2010.06.006 CrossRefGoogle Scholar
  46. Sant’Anna V, Gurak PD, Vargas NSD, da Silva MK, Marczak LDF, Tessaro IC (2016) Jaboticaba (Myrciaria jaboticaba) juice concentration by forward osmosis. Sep Sci Technol 51:1708–1715.  https://doi.org/10.1080/01496395.2016.1168845 CrossRefGoogle Scholar
  47. Shaffer DL, Yip NY, Gilron J, Elimelech M (2012) Seawater desalination for agriculture by integrated forward and reverse osmosis: improved product water quality for potentially less energy. J Membr Sci 415-416:1–8.  https://doi.org/10.1016/j.memsci.2012.05.016 CrossRefGoogle Scholar
  48. Stache K (1989) Apparatus for transforming sea water, brackish water, polluted water or the like into a nutrious drink by means of osmosis. Google Patents,Google Scholar
  49. Su J, Yang Q, Teo JF, Chung T-S (2010) Cellulose acetate nanofiltration hollow fiber membranes for forward osmosis processes. J Membr Sci 355:36–44.  https://doi.org/10.1016/j.memsci.2010.03.003 CrossRefGoogle Scholar
  50. Tiraferri A, Yip NY, Phillip WA, Schiffman JD, Elimelech M (2011) Relating performance of thin-film composite forward osmosis membranes to support layer formation and structure. J Membr Sci 367:340–352.  https://doi.org/10.1016/j.memsci.2010.11.014 CrossRefGoogle Scholar
  51. Valladares Linares R, Li Z, Sarp S, Bucs SS, Amy G, Vrouwenvelder JS (2014) Forward osmosis niches in seawater desalination and wastewater reuse. Water Res 66:122–139.  https://doi.org/10.1016/j.watres.2014.08.021 CrossRefGoogle Scholar
  52. Wan CF, Chung T-S (2015) Osmotic power generation by pressure retarded osmosis using seawater brine as the draw solution and wastewater retentate as the feed. J Membr Sci 479:148–158.  https://doi.org/10.1016/j.memsci.2014.12.036 CrossRefGoogle Scholar
  53. Wang KY, Yang Q, Chung T-S, Rajagopalan R (2009) Enhanced forward osmosis from chemically modified polybenzimidazole (PBI) nanofiltration hollow fiber membranes with a thin wall. Chem Eng Sci 64:1577–1584.  https://doi.org/10.1016/j.ces.2008.12.032 CrossRefGoogle Scholar
  54. Wang R, Shi L, Tang CY, Chou S, Qiu C, Fane AG (2010) Characterization of novel forward osmosis hollow fiber membranes. J Membr Sci 355:158–167.  https://doi.org/10.1016/j.memsci.2010.03.017 CrossRefGoogle Scholar
  55. Williams PM, Ahmad M, Connolly BS, Oatley-Radcliffe DL (2015) Technology for freeze concentration in the desalination industry. Desalination 356:314–327.  https://doi.org/10.1016/j.desal.2014.10.023 CrossRefGoogle Scholar
  56. Xie M, Nghiem LD, Price WE, Elimelech M (2014) Toward resource recovery from wastewater: extraction of phosphorus from digested sludge using a hybrid forward osmosis–membrane distillation. Proc Environ Sci Technol Lett 1:191–195.  https://doi.org/10.1021/ez400189z CrossRefGoogle Scholar
  57. Yang Q, Wang KY, Chung T-S (2009) Dual-layer hollow fibers with enhanced flux as novel forward osmosis membranes for water production. Environ Sci Technol 43:2800–2805.  https://doi.org/10.1021/es803360t CrossRefGoogle Scholar
  58. Yangali-Quintanilla V, Li Z, Valladares R, Li Q, Amy G (2011) Indirect desalination of Red Sea water with forward osmosis and low pressure reverse osmosis for water reuse. Desalination 280:160–166.  https://doi.org/10.1016/j.desal.2011.06.066 CrossRefGoogle Scholar
  59. Yip NY, Tiraferri A, Phillip WA, Schiffman JD, Elimelech M (2010) High performance thin-film composite forward osmosis membrane. Environ Sci Technol 44:3812–3818.  https://doi.org/10.1021/es1002555 CrossRefGoogle Scholar
  60. Zhang Y, Pinoy L, Meesschaert B, Van der Bruggen B (2013) A natural driven membrane Process for brackish and wastewater treatment: photovoltaic powered ED and FO hybrid system. Environ Sci Technol 47:10548–10555.  https://doi.org/10.1021/es402534m CrossRefGoogle Scholar
  61. Zhao Q, Chen N, Zhao D, Lu X (2013) Thermoresponsive magnetic nanoparticles for seawater desalination. ACS Appl Mater Interfaces 5:11453–11461.  https://doi.org/10.1021/am403719s CrossRefGoogle Scholar
  62. Zhao Y, Ren Y, Wang X, Xiao P, Tian E, Wang X, Li J (2016) An initial study of EDTA complex based draw solutes in forward osmosis process. Desalination 378:28–36.  https://doi.org/10.1016/j.desal.2015.09.006 CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2019

Authors and Affiliations

  • Huy Quang Le
    • 1
    • 2
  • Thi Xuan Quynh Nguyen
    • 1
  • Shiao-Shing Chen
    • 1
    Email author
  • Chinh Cong Duong
    • 1
    • 3
  • Thanh Ngoc-Dan Cao
    • 1
    • 4
  • Hau-Ming Chang
    • 1
  • Saikat Sinha Ray
    • 1
  • Nguyen Cong Nguyen
    • 2
  1. 1.Institute of Environmental Engineering and ManagementNational Taipei University of TechnologyTaipeiTaiwan
  2. 2.Faculty of Environment and Natural ResourcesDalat UniversityDa Lat CityVietnam
  3. 3.Southern Institute of Water Resources ResearchHo Chi Minh CityVietnam
  4. 4.Nguyen Tat Thanh UniversityHo Chi Minh CityVietnam

Personalised recommendations