Advertisement

Environmental Science and Pollution Research

, Volume 26, Issue 11, pp 10727–10737 | Cite as

Oxygen transfer improvement in MBBR process

  • Maria Cristina Collivignarelli
  • Alessandro AbbàEmail author
  • Giorgio Bertanza
Research Article
  • 70 Downloads

Abstract

In the last years, the upgrading of wastewater treatment plants (WWTPs) could be required in order to comply with the more stringent regulation requirements. Nevertheless, the main issue is related to the surface availability. A proper solution could be represented by the attached biomass processes, in particular the moving bed biofilm reactors (MBBR), that have a significant footprint reduction with respect to conventional activated sludge (CAS). However, MBBR showed an important disadvantage: the poor aeration energy efficiency due to the use of coarse bubble diffusers, which guarantee high reliability and low maintenance costs with respect to fine bubble ones. Moreover, the presence of carriers inside the reactor emphasizes this aspect. The aim of this work is to verify the benefits achievable by installing a fine bubble aeration system inside a MBBR system. The comparison, in terms of oxygen transfer efficiency, between a medium bubble aeration system and a fine ceramic bubble diffuser was studied and the effect of biofilm growth on oxygen transfer was assessed. Several tests were carried out in order to test the operation of a coarse and a fine bubble side aeration at different air flow rates, both in clean water conditions, in order to evaluate the influence of carriers (Chip M type) on the aeration efficiency, both in wastewater conditions with the aim to assess the effect of bacteria growth on the carriers. The main results are the following: (i) the fine bubble system placed off-center ensured good mixing even without using the mixer; (ii) the fine bubble side aeration system compared to the coarse ones did not show significant advantages in terms of oxygen transfer efficiency; (iii) the increase in specific air flow rate negatively influenced the aeration efficiency; (iv) the presence of biomass had a positive effect on the oxygen transfer yield.

Keywords

Wastewater treatment Moving bed biofilm reactor Aeration efficiency Attached biomass Coarse bubble aeration Fine bubble aeration 

Notes

Acknowledgements

The authors wish to thank Veolia and AnoxKaldnes AB for giving the financial and technical support to the experimental research. A special thanks to Eng. Gianfranco Favali for his useful suggestions in writing this paper and to Eng. David Danesi that carried out the experimental activities during his Master Thesis.

References

  1. Andreottola G, Foladori P, Ragazzi M, Villa R (2002) Dairy wastewater treatment in a moving bed biofilm reactor. Water Sci Technol 45(12):321–328.  https://doi.org/10.2166/wst.2002.0441 CrossRefGoogle Scholar
  2. ASCE (1997) Standard guidelines for in-process oxygen transfer testing. ASCE 18-96, American Society of Civil Engineering, New York, NY ISBN: 0-7844-0114-4CrossRefGoogle Scholar
  3. ASCE (2007) Measurement of oxygen transfer in clean water. ASCE/EWRI 2-06, American Society of Civil Engineering, Reston, VA ISBN: 0-7844-0848-3CrossRefGoogle Scholar
  4. Barwal A, Chaudhary R (2015) Impact of carrier filling ratio on oxygen uptake & transfer rate, volumetric oxygen transfer coefficient and energy saving potential in a la-scale MBBR. J Water Process Eng 8:202–208.  https://doi.org/10.1016/j.jwpe.2015.10.008 CrossRefGoogle Scholar
  5. Brinkley J, Chandler HJ, Souza R (2007) Moving bed biofilm reactor technology—a full-scale installation for treatment of pharmaceutical wastewater. Proceedings of NC-AWWA-WE NC AWWA-WEA 87th Annual Conference, Charlotte, North Carolina, December 2–5Google Scholar
  6. Casas ME, Chhetri RK, Ooi G, Hansen KMS, Litty K, Christensson M, Kragelund C, Andersen HR, Bester K (2015) Biodegradation of pharmaceuticals in hospital wastewater by staged moving bed biofilm reactors (MBBR). Water Res 83:293–302.  https://doi.org/10.1016/j.watres.2015.06.042 CrossRefGoogle Scholar
  7. Casas ME, Nielsen TK, Kot W, Hansen LH, Johansen A, Bester K (2017) Degradation of mecoprop in polluted landfill leachate and waste water in a moving bed biofilm reactor. Water Res 121:213–220.  https://doi.org/10.1016/j.watres.2017.05.031 CrossRefGoogle Scholar
  8. Castro DF, Bassin JP, Dezotti M (2017) Treatment of a simulated textile wastewater containing the Reactive Orange 16 azo dye by a combination of ozonation and moving-bed biofilm reactor: evaluating the performance, toxicity, and oxidation by-products. Environ Sci Pollut Res 24:6307–6316.  https://doi.org/10.1007/s11356-016-7119-x CrossRefGoogle Scholar
  9. Daigger GT, Boltz JP (2018) Oxygen transfer in moving bed biofilm reactor and integrated fixed film activated sludge processes. Water Environ Res 90(7):615–622.  https://doi.org/10.2175/106143017X15054988926596 CrossRefGoogle Scholar
  10. Dias J, Bellingham M, Hassan J, Barrett M, Stephenson T, Soares A (2018) Impact of carrier media on oxygen transfer and wastewater hydrodynamics on a moving attached growth system. Chem Eng J 351:399–408.  https://doi.org/10.1016/j.cej.2018.06.028 CrossRefGoogle Scholar
  11. Jing JY, Feng J, Li WY, Xu Y (2009) Removal of COD from coking-plant wastewater in the moving-bed biofilm sequencing batch reactor. Korean J Chem Eng 26(2):564–568.  https://doi.org/10.1007/s11814-009-0096-8 CrossRefGoogle Scholar
  12. Johnson C, Boltz JP (2013) Aeration system design in integrated fixed-film activated sludge (IFAS) and moving bed biofilm reactors (MBBR) using stainless steel pipe diffusers, manifold, and down pipes. Proceedings of the Water Environment Federation, WEFTEC 2013: Session 47 through Session 53, 3781–3808(28)Google Scholar
  13. Kaiser R (1969) Comparison of aeration efficiency under process conditions. Advances in water pollution research. Proceedings of the 4th International Conference, PragueGoogle Scholar
  14. Kruszelnicka I, Kramarczyka DG, Poszwab P, Strękc T (2018) Influence of MBBR carriers’ geometry on its flow characteristics. Chem Eng Process 130:134–139.  https://doi.org/10.1016/j.cep.2018.06.009 CrossRefGoogle Scholar
  15. Leyva-Díaz JC, Martìn-Pascual J, Poyatos M (2017) Moving bed biofilm reactor to treat wastewater. Int J Environ Sci Technol 14:881–910.  https://doi.org/10.1007/s13762-016-1169-y CrossRefGoogle Scholar
  16. Libra JA, Schuschardt A, Sahlmann C, Handschag J, Weismann U, Gnirss R (2002) Comparison of the efficiency of large-scale ceramic and membrane aeration system with the dynamics off-gas method. Water Sci Technol 46(4–5):317–324.  https://doi.org/10.2166/wst.2002.0615 CrossRefGoogle Scholar
  17. Marquez JJ, Souza RR, Souza CS, Rocha ICC (2008) Attached biomass growth and substrate utilization rate in a moving bed biofilm reactor. Braz J Chem Eng 25(4):665–670.  https://doi.org/10.1590/S0104-66322008000400004 CrossRefGoogle Scholar
  18. McQuarrie JP, Boltz JP (2011) Moving bed biofilm reactor technology: process applications, design, and performance. Water Environ Res 83(6):560–575.  https://doi.org/10.2175/106143010X12851009156286 CrossRefGoogle Scholar
  19. Ødegaard H (1999) The moving bed biofilm reactor. In: Igarashi T, Watanabe Y, Asano T, Tambo N (eds) Water environmental engineering and reuse of water, Hokkaido Press, pp 205–305Google Scholar
  20. Ødegaard H (2006) Innovations in wastewater treatment: the moving bed biofilm. Water Sci Technol 53(9):17–33.  https://doi.org/10.2166/wst.2006.284 CrossRefGoogle Scholar
  21. Ødegaard H, Gisvold B, Strickland J (2000) The influence of carriers size and shape in the moving bed biofilm process. Water Sci Technol 41(4–5):383–392.  https://doi.org/10.2166/wst.2000.0470 CrossRefGoogle Scholar
  22. Rosso D, Stenstrom MK (2005) Comparative economic analysis of the impacts of mean cell retention time and denitrification on aeration system. Proceedings of the IWA Specialized Biological Nutrient Removal Conference, Krakow, Poland, OctoberGoogle Scholar
  23. Rosso D, Stenstrom MK (2006) Economic implications of fine pore diffusers aging. Water Environ Res 78:810–815.  https://doi.org/10.2175/106143006X101683 CrossRefGoogle Scholar
  24. Rosso D, Iranpour R, Stenstrom MK (2005) Fifteen years of off-gas transfer efficiency measurements on fine-pore aerators: key role of sludge age and normalized air flux. Water Environ Res 77(3):266–273.  https://doi.org/10.2175/106143005X41843 CrossRefGoogle Scholar
  25. Rusten B, Eikebrokk B, Ulgenes Y, Lygren E (2006) Design and operations of the Kaldnes moving bed biofilm reactors. Aquac Eng 34:322–331.  https://doi.org/10.1016/j.aquaeng.2005.04.002 CrossRefGoogle Scholar
  26. Sander S, Behnisch J, Wagner M (2017) Energy, cost and design aspects of coarse- and fine-bubble aeration systems in the MBBR IFAS process. Water Sci Technol 75(4):890–897.  https://doi.org/10.2166/wst.2016.571 CrossRefGoogle Scholar
  27. US EPA (1989) Fine pore (fine bubble) aeration systems. EPA/625/1-89/023, U.S. Environmental Protection Agency, Cincinnati, OHGoogle Scholar
  28. Wang XJ, Xia SQ, Chen L, Zhao JF, Renault NJ, Chovelon JM (2006) Nutrients removal from municipal wastewater by chemical precipitation in a moving bed biofilm reactor. Process Biochem 41:824–828.  https://doi.org/10.1016/j.procbio.2005.10.015 CrossRefGoogle Scholar
  29. Weiss JS, Alvarez M, Tang C-C, Horvath RW, Stahl JF (2005) Evaluation of moving bed biofilm reactor technology for enhancing nitrogen removal in a stabilization pond treatment plant. Proceedings of the Water Environment Federation, WEFTEC 2005: Session 21 through Session 30, 2085–2102Google Scholar
  30. Zafarzadeh A, Bina B, Nikaeen M, Movahedian Attar H, Hajian nejad M (2010) Performance of moving bed biofilm reactors for biological nitrogen compounds removal from wastewater by partial nitrification-denitrification process. Iranian J Environ Health Eng 7(4):353–364Google Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2019

Authors and Affiliations

  1. 1.Department of Civil Engineering and ArchitectureUniversity of PaviaPaviaItaly
  2. 2.Department of Civil, Environmental, Architectural Engineering and MathematicsUniversity of BresciaBresciaItaly

Personalised recommendations