Kinetics of the acid-catalyzed hydrolysis of tetraethoxysilane (TEOS) by 29Si NMR spectroscopy and mathematical modeling
- 38 Downloads
Tetraethoxysilane (TEOS) is widely used to synthesize siliceous material by the sol–gel process. However, there is still some disagreement about the nature of the limiting step in the hydrolysis and condensation reactions. The goal of this research was to measure the variation in the concentration of intermediates formed in the acid-catalyzed hydrolysis by 29Si NMR spectroscopy, to model the reactions, and to obtain the rate constants and the activation energy for the hydrolysis and early condensation steps. We studied the kinetics of TEOS between pH 3.8 and 4.4, and four temperature values in the range of 277.2–313.2 K, with a TEOS:ethanol:water molar ratio of 1:30:20. Both hydrolysis and the condensation rate speeded up with the temperature and the concentration of oxonium ions. The kinetic constants for hydrolysis reactions increased in each step kh1 < kh2 < kh3 < kh4, but the condensation rate was lower for dimer formation than for the formation of the fully hydrolyzed Si(OH)4. The system was described according to 13 parameters: six of them for the kinetic constants estimated at 298.2 K, six to the activation energies, and one to the equilibrium constant for the fourth hydrolysis. The mathematical model shows a steady increase in the activation energy from 34.5 kJ mol−1 for the first hydrolysis to 39.2 kJ mol−1 in the last step. The activation energy for the condensation reaction from Si(OH)4 was ca. 10 kJ mol−1 higher than the largest activation energy in the hydrolytic reactions. The decrease in the net positive charge on the Si atom contributes to the protonation of the ethoxy group and makes it a better leaving group.
KeywordsMathematical modeling kinetic constants TEOS 29Si NMR pH-independent rate constants Activation energy
This work was supported by “Ministerio de Economía, Industria y Competitividad” (MAT2016-78155-C2-2-R). PM is thankful to the “Departamento de Industria y Tecnología, Comercio y Trabajo” of Navarre Government for a fellowship.
Compliance with ethical standards
Conflict of interest
The authors declare that they have no conflict of interest.
- 2.Brinker CJ, Scherer GW (1990) Sol-Gel Science: The Physics and Chemistry of Sol-Gel Processing. Academic Press, New York, NY, USAGoogle Scholar
- 4.Wright JD, Sommerdijk NAJM (2001) Sol-Gel Materials: Chemistry and Applications, vol 4. Advanced Chemistry Texts. Taylor & Francis, London, UKGoogle Scholar
- 5.Estella J, Echeverria JC, Laguna M, Garrido JJ (2007) Silica xerogels of tailored porosity as support matrix for optical chemical sensors. Simultaneous effect of pH, ethanol: TEOS and water: TEOS molar ratios, and synthesis temperature on gelation time, and textural and structural properties. J Non-Cryst Solids 353(3):286–294. https://doi.org/10.1016/j.jnoncrysol.2006.12.006 CrossRefGoogle Scholar
- 12.Depla A, Lesthaeghe D, van Erp TS, Aerts A, Houthoofd K, Fan F, Li C, Van Speybroeck V, Waroquier M, Kirschhock CEA, Martens JA (2011) Si-29 NMR and UV-raman investigation of initial oligomerization reaction pathways in acid-catalyzed silica sol-gel chemistry. J Phys Chem C 115(9):3562–3571. https://doi.org/10.1021/jp109901v CrossRefGoogle Scholar
- 23.Houston PL (2001) Chemical Kinetics and Reaction Dynamics, 1st edn. McGraw-Hill, New York, NY, USAGoogle Scholar
- 24.Frisch MJ, Trucks GW, Schlegel HB, Scuseria GE, Robb MA, Cheeseman JR, Scalmani G, Barone V, Mennucci B, Petersson GA, Nakatsuji H, Caricato ML, X., Hratchian HP, Izmaylov AF, Bloino J, Zheng G, Sonnenberg JL, Hada M, Ehara M, Toyota K, Fukuda R, Hasegawa J, Ishida M, Nakajima T, Honda Y, Kitao O, Nakai H, Vreven T, Montgomery J, J. A., Peralta JE, Ogliaro F, Bearpark M, Heyd JJ, Brothers E, Kudin KN, Staroverov VN, Keith T, Kobayashi R, Normand J, Raghavachari K, Rendell A, Burant JC, Iyengar SS, Tomasi J, Cossi M, Rega N, Millam JM, Klene M, Knox JE, Cross JB, Bakken V, Adamo C, Jaramillo J, Gomperts R, Stratmann RE, Yazyev O, Austin AJ, Cammi R, Pomelli C, Ochterski JW, Martin RL, Morokuma K, Zakrzewski VG, Voth GA, Salvador P, Dannenberg JJ, Dapprich S, Daniels AD, Farkas O, Foresman JB, Ortiz JV, Cioslowski J, Fox DJ (2010) Gaussian 09. Revision C.01 edn., Wallingford CT, USAGoogle Scholar
- 34.Malier L, Devreux F, Chaput F, Boilot JP (1992) Silicon-29 nuclear magnetic resonance of sol-gel transformation in first steps and after gel time. In: Hench LL, West JK (eds) Chemical Processing of Advanced Materials. John Wiley and Sons, Inc, New York, pp 59–67Google Scholar
- 39.Devreux F, Boilot JP, Chaput F, Lecomte A (1990) Si-29 NMR-study of silicon alkoxides–from the condensation kinetics in solution to the determination of the fractal dimension in aerogels In: Brinker CJ, Zelinsky BJ, Ulrich DR, Clark DE (eds) Better Ceramics through Chemistry IV. Materials Research Society, San Francisco, pp 211–216Google Scholar