Advertisement

Journal of Materials Science: Materials in Electronics

, Volume 29, Issue 17, pp 14960–14970 | Cite as

Erbium-doped nanoparticles/films for enhancing percentage photodegradation of direct red-31 dye

  • Sonik Bhatia
  • Neha Verma
Article
  • 32 Downloads

Abstract

Nowadays, the demand for synthetic dyes has grown manifold as there are being widely used in leather, textile, food industries. This paper reports Erbium doped ZnO nanostructured films were deposited on to the glass substrate by a sol–gel spin coating technique. Atomic weight percentage of Erbium was varied from 2.0, 2.5, 3.0, and 3.5 at.wt% namely EZ-1, EZ-2, EZ-3 and EZ-4 and the film characterization were carried out by means of X-Ray diffraction, FESEM, UV–Vis spectrophotometer, Raman spectroscopy, LCR and photoluminescence measurements. XRD result revealed the existence of Er2O3 and ZnO phases for varied Er concentration. FESEM reveals rod-shaped morphology of the film of the order of the size of 40–75 nm. Absorbance and optical band gap was obtained from UV–Vis spectrophotometer. This revealed optical band gap widening with a molar ratio in the range of 3.26–3.32 eV. Raman spectroscopy indicates the tensile stress in Er-doped ZnO films. Photoluminescence intensity near 594 nm indicates more oxygen vacancies which led to high photocatalytic performance. The prepared films were used for photodegradation of DR-31 dye. From the photocatalytic experiment, the degradation percentage was increased with increase in Er concentration up to a molar ratio of 3.0 at.wt%. Thus the optimum molar ratio of the prepared films (3.0 at.wt%) exhibits almost complete degradation of DR-31 dye only in 48 min under UV illumination. The kinetic study reveals the rate constant of nanospheres like particles is 0.07428 min−1. The Er-doped films with different molar ratio result in almost same photocatalytic performance after regular interval of the time. The comparative study of nanoparticles with the film will make for photodegradation of DR-31 dye under same experimental conditions. Despite kinetic study of prepared films were better as compared to bulk form (powder) but the percentage degradation of nanoparticles was found to be better than films.

Notes

Acknowledgements

Authors are grateful to U.G.C, New Delhi for providing financial assistance for carrying out the project (F.No. 42–770/2013). Panjab University Chandigarh for providing SEM and XRD facility, IKGPTU Kapurthala for Research Cooperations.

References

  1. 1.
    P. Mongkolserm, S. Pabchanda, Influence of tin doping on the photocatalytic activity of zinc oxide thin films under UV light. J. Chem. Chem. Eng. 6, 631–637 (2012)Google Scholar
  2. 2.
    A. Khataee, R. Darvishi Cheshmeh Soltani, Y. Hanifehpour, M. Safarpour, H. Gholipour Ranjbar, S.W. Joo, Synthesis and characterization of dysprosium doped ZnO nanoparticles for photocatalysis of a textile dye under visible light irradiation. Ind. Eng. Chem. Res. (2014)  https://doi.org/10.1021/ie402743u Google Scholar
  3. 3.
    D.S. Dhawale, D.P. Dubal, A.M. More, T.P. Gujar, C.D. Lokhande, Room temperature liquefied petroleum gas (LPG) sensor. Sens. Actuators B 147, 488–494 (2010).  https://doi.org/10.1016/j.snb.2010.02.063 CrossRefGoogle Scholar
  4. 4.
    S. Ito, T.N. Murakami, P. Comte, P. Liska, C. Grätzel, M.K. Nazeeruddin, M. Grätzel, Fabrication of thin film dye sensitized solar cells with solar to electric power conversion efficiency over 10%. Thin Solid Films 516, 4613–4619 (2008).  https://doi.org/10.1016/j.tsf.2007.05.090 CrossRefGoogle Scholar
  5. 5.
    C. Lee, Fabrication methods and luminescent properties of ZnO materials for light-emitting diodes. Materials 3, 2218–2259. (2010).  https://doi.org/10.3390/ma3042218 CrossRefGoogle Scholar
  6. 6.
    L. Guo, H. Zhang, D. Zhao, B. Li, Z. Zhang, M. Jiang, D. Shen, High responsivity ZnO nanowires based UV detector fabricated by the dielectrophoresis method. Sens. Actuators B. 166–167, 12–16. (2012).  https://doi.org/10.1016/j.snb.2011.08.049 CrossRefGoogle Scholar
  7. 7.
    F. Li, L. Orosz, O. Kamoun, S. Bouchoule, C. Brimont, P. Disseix, T. Guillet, X. Lafosse, M. Leroux, J. Leymarie, M. Mexis, M. Mihailovic, F. Réveret, D. Solnyshkov, J. Zuniga-Perez, G. Malpuech, ZnO-based polariton laser operating at room temperature: from excitonic to photonic condensate. Condens. Matter (2012).  https://doi.org/10.1103/PhysRevLett.110.196406 Google Scholar
  8. 8.
    P. Hemalatha, S.N. Karthick, K.V. Hemalatha, M. Yi, H.-J. Kim, M. Alagar, La-doped ZnO nanoflower as a photocatalyst for methylene blue dye degradation under UV irradiation. J. Mater. Sci. Mater. Electron. 27, 2367–2378 (2016).  https://doi.org/10.1007/s10854-015-4034-8 CrossRefGoogle Scholar
  9. 9.
    H. Gómez-Pozos, E. Arredondo, A. Maldonado Álvarez, R. Biswal, Y. Kudriavtsev, J. Pérez, Y. Casallas-Moreno, M. Olvera Amador, Cu-doped ZnO thin films deposited by a sol-gel process using two copper precursors: gas-sensing performance in a propane atmosphere. Materials (Basel) 9, 87 (2016).  https://doi.org/10.3390/ma9020087 CrossRefGoogle Scholar
  10. 10.
    M. Xu, Q. Li, Y. Ma, H. Fan, Sensors, B. Actuators, Chemical Ni-doped ZnO nanorods gas sensor: enhanced gas-sensing properties, AC and DC electrical behaviors. Sens. Actuators B. 199, 403–409 (2014).  https://doi.org/10.1016/j.snb.2014.03.108 CrossRefGoogle Scholar
  11. 11.
    L. Yu, S. Liu, B. Yang, J. Wei, M. Lei, X. Fan, Sn-Ga co-doped ZnO nanobelts fabricated by thermal evaporation and application to ethanol gas sensors. Mater. Lett. 141, 79–82 (2015).  https://doi.org/10.1016/j.matlet.2014.11.049 CrossRefGoogle Scholar
  12. 12.
    R. Bel-hadj-Tahar, A.B. Mohamed, Sol-gel processed indium-doped zinc oxide thin films and their electrical and optical properties. New J. Glass Ceram. 4, 55–65 (2014).  https://doi.org/10.4236/njgc.2014.44008 CrossRefGoogle Scholar
  13. 13.
    S. Bhatia, N. Verma, R.K. Bedi, Optical application of Er-doped ZnO nanoparticles for photodegradation of direct red-31 dye. Opt. Mater. (Amst). 62, 392–398 (2016).  https://doi.org/10.1016/j.optmat.2016.10.013 CrossRefGoogle Scholar
  14. 14.
    N.K. Divya, P.U. Aparna, P.P. Pradyumnan, Dielectric properties of Er3+ doped ZnO nanocrystals. Adv. Mater. Phys. Chem. 5, e287–e294 (2015)CrossRefGoogle Scholar
  15. 15.
    R. Kumar, A. Umar, G. Kumar, M.S. Akhtar, Y. Wang, S.H. Kim, Ce-doped ZnO nanoparticles for efficient photocatalytic degradation of direct red-23 dye. Ceram. Int. 41, 7773–7782 (2015).  https://doi.org/10.1016/j.ceramint.2015.02.110 CrossRefGoogle Scholar
  16. 16.
    J. Zhang, S.J. Deng, S.Y. Liu, J.M. Chen, B.Q. Han, Y. Wang, Y.D. Wang, S.J. Deng, S.Y. Liu, J.M. Chen, B.Q. Han, Y. Wang, Y.D. Wang, J. Zhang, S.J. Deng, S.Y. Liu, J.M. Chen, B.Q. Han, Y. Wang, Y.D. Wang, Preparation and photocatalytic activity of Nd-doped ZnO nanoparticles. Mater. Technol. (2016).  https://doi.org/10.1179/1753555713Y.0000000122 Google Scholar
  17. 17.
    P. Hemalatha, S.N. Karthick, K.V. Hemalatha, M. Yi, H.-J. Kim, M. Alagar, La-doped ZnO nanoflower as photocatalyst for methylene blue dye degradation under UV irradiation. J. Mater. Sci. Mater. Electron. 27, 2367–2378 (2016).  https://doi.org/10.1007/s10854-015-4034-8 CrossRefGoogle Scholar
  18. 18.
    S. Illican, Structural, optical and electrical properties of Erbium-doped ZnO thin films prepared by spin coating method. J. Nanoelectron. Optoelectron. 11, 465–471 (2016)CrossRefGoogle Scholar
  19. 19.
    S.D. Senol, Hydrothermal derived nanostructure rare earth (Er, Yb)-doped ZnO: structural, optical and electrical properties. J. Mater. Sci. 27, 7767–7775 (2016).  https://doi.org/10.1007/s10854-016-4765-1 Google Scholar
  20. 20.
    P. Pandey, R. Kurchania, F.Z. Haque, Rare earth ion (La, Ce, and Eu) doped ZnO nanoparticles synthesized via sol-gel method: application in dye-sensitized solar cells. Opt. Spectrosc. 119, 666–671 (2015).  https://doi.org/10.1134/S0030400X15100215 CrossRefGoogle Scholar
  21. 21.
    K. Yu, J. Shi, Z. Zhang, Y. Liang, W. Liu, ZnO and Er-doped ZnO. J. Nanoparticles 2013, 1–6 (2013)Google Scholar
  22. 22.
    C. Jayachandraiah, K. Sivakumar, A. Divya, G. Krishnaiah, Erbium induced magnetic properties of Er/ZnO nanoparticles. 50116, 50116. (2016).  https://doi.org/10.1063/1.4947770
  23. 23.
    S. Bhatia, R.K. Bedi, Morphological, electrical and optical properties of zinc oxide films grown on different substrates by spray pyrolysis technique, in Nanostructured Thin Films III, vol. 7766, p. 776610. International Society for Optics and Photonics. (2010).  https://doi.org/10.1117/12.863878
  24. 24.
    P.M. Aneesh, K.A. Vanaja, M.K. Jayaraj, Synthesis of ZnO nanoparticles by hydrothermal method, in Nanophotonic Materials IV 66390J–66390J–9. (2017)  https://doi.org/10.1117/12.730364
  25. 25.
    N. Srinatha, Y.S. No, V.B. Kamble, S. Chakravarty, N. Suriyamurthy, B. Angadi, A.M. Umarji, W.K. Choi, Effect of RF power on the structural, optical and gas sensing properties of RF-sputtered Al-doped ZnO thin films. RSC Adv. 6, 9779–9788 (2016).  https://doi.org/10.1039/C5RA22795J CrossRefGoogle Scholar
  26. 26.
    S. Bhatia, N. Verma, R.K. Bedi, Ethanol gas sensor based upon ZnO nanoparticles prepared by different techniques. Results Phys. (2017).  https://doi.org/10.1016/j.rinp.2017.02.008 Google Scholar
  27. 27.
    A. El Manouni, F.J. Manjn, M. Perales, M. Mollar, B. Mar, M.C. Lopez, J.R. Ramos, Barrado, Effect of thermal annealing on ZnO: Al thin films grown by spray pyrolysis. Superlattices Microstruct. 42, 134–139 (2007).  https://doi.org/10.1016/j.spmi.2007.04.005 CrossRefGoogle Scholar
  28. 28.
    N. Verma, S. Bhatia, R.K. Bedi, Effect of annealing temperature on ZnO nanoparticles and its applications for photocatalytic degradation of DR-31 dye, 13, 118–122 (2017)Google Scholar
  29. 29.
    N. Verma, S. Bhatia, Role of pH on electrical, optical and photocatalytic properties of ZnO based nanoparticles. J. Mater. Sci. Mater. Electron. 0, 0 (2017).  https://doi.org/10.1007/s10854-017-6732-x Google Scholar
  30. 30.
    S. Bhatia, N. Verma, R.K. Bedi, Effect of aging time on gas sensing properties and photocatalytic efficiency of dye on In-Sn co-doped ZnO nanoparticles, Mater. Res. Bull. (2016).  https://doi.org/10.1016/j.materresbull.2016.12.011 Google Scholar
  31. 31.
    M. Marie, S. Mandal, O. Manasreh, An electrochemical glucose sensor based on zinc oxide nanorods. Sensors 15, 18714–18723 (2015).  https://doi.org/10.3390/s150818714 CrossRefGoogle Scholar
  32. 32.
    M. Hussain, H. Sun, S. Karim, A. Nisar, M. Khan, H. Munawar, I. Mashkoor, Noble metal nanoparticle-functionalized ZnO nanoflowers for photocatalytic degradation of RhB dye and electrochemical sensing of hydrogen peroxide. J. Nanoparticle Res. (2016).  https://doi.org/10.1007/s11051-016-3397-y Google Scholar
  33. 33.
    S. Bhatia, N. Verma, R.K. Bedi, Sn-doped ZnO nanopetal networks for efficient photocatalytic degradation of dye and gas sensing applications. Appl. Surf. Sci. 407C, 495–502 (2017)CrossRefGoogle Scholar
  34. 34.
    K. Ravichandran, E. Sindhuja, R. Uma, T. Arun, Photocatalytic efficacy of ZnO films—light intensity and thickness effects. Surf. Eng. 0, 1–9 (2017).  https://doi.org/10.1080/02670844.2016.1270797 Google Scholar
  35. 35.
    L. Saikia, D. Bhuyan, M. Saikia, B. Malakar, D.K. Dutta, P. Sengupta, Photocatalytic performance of ZnO nanomaterials for self-sensitized degradation of malachite green dye under solar light. Appl. Catal. A 490, 42–49 (2015).  https://doi.org/10.1016/j.apcata.2014.10.053 CrossRefGoogle Scholar
  36. 36.
    H. Sutanto, S. Wibowo, I. Nurhasanah, E. Hidayanto, H. Hadiyanto, Ag doped ZnO thin films synthesized by spray coating technique for methylene blue photodegradation under UV irradiation. (2016).  https://doi.org/10.1155/2016/6195326
  37. 37.
    P. Pradhan, J.C. Alonso, M. Bizarro, The photocatalytic performance of ZnO: Al films under different light sources. Int. J. Photoenergy. (2012).  https://doi.org/10.1155/2012/780462 Google Scholar
  38. 38.
    B. Debnath, G. Halder, S. Bhattacharyya, One-step synthesis, structural and optical characterization of self-assembled ZnO nanoparticle clusters with quench-induced defects. Sci. Adv. Mater. 6, 1160e1169 (2014)CrossRefGoogle Scholar
  39. 39.
    L. Shi, F. Wang, Y. Wang, D. Wang, B. Zhao, L. Zhang, D. Zhao, D. Shen, Photoluminescence and photocatalytic properties of rhombohedral CuGaO2 nanoplates. Sci. Rep. 6, 21135 (2016).  https://doi.org/10.1038/srep21135 CrossRefGoogle Scholar
  40. 40.
    N. Sobana, K. Thirumalai, Kinetics of solar light assisted degradation of direct red 23 on activated carbon-loaded zinc oxide and influence of operational parameters. Can. Chem. Trans. 4, 77–89 (2016).  https://doi.org/10.13179/canchemtrans.2016.04.01.0258 Google Scholar
  41. 41.
    P. Bezdic, P. Dzik, J. Rathousky, J. Demel, High photocatalytic activity of transparent films composed of ZnO nanosheets. Langmuir 30, 380–386 (2014)CrossRefGoogle Scholar
  42. 42.
    S. Bhatia, N. Verma, R. Kumar, Morphologically-dependent photocatalytic and gas sensing application of Dy-doped ZnO nanoparticles. J. Alloys Compd. 726, 1274–1285 (2017).  https://doi.org/10.1016/j.jallcom.2017.08.048 CrossRefGoogle Scholar

Copyright information

© Springer Science+Business Media, LLC, part of Springer Nature 2018

Authors and Affiliations

  1. 1.PG Department of PhysicsKanya Maha VidyalayaJalandharIndia
  2. 2.IKG Punjab Technical UniversityKapurthalaIndia

Personalised recommendations