Advertisement

Journal of Materials Science

, Volume 55, Issue 1, pp 191–202 | Cite as

Preparation and performance of hydrophobic and conductive silica composite fiber membrane

  • Tianya Li
  • Yulong Xu
  • Kejian Wang
  • Jinghui Song
  • Hengwei Hu
  • Han Liu
  • Yueqi Liu
  • Yong LiuEmail author
  • Jing Wu
  • Haohong Pi
  • Seeram Ramakrishna
Composites & nanocomposites
  • 23 Downloads

Abstract

Electrospinning is an important way to prepare fibers. In this paper, hydrophobic and conductive composite fiber membranes were prepared by opposite electrospinning. The hydrophobic material was trimethylethoxysilane, the conductive material was graphene, and polyvinylpyrrolidone was introduced as the carrier material of graphene. It was found that the sol–gel time, the content of silane coupling agent and low-temperature storage of the solution have a certain influence on the hydrophobicity and spinnability of the fiber membrane. At the same time, the effect of graphene content on the spinnability and the electrical conductivity of composite fiber membrane were studied. The results showed that the composite fiber membrane has good hydrophobic properties and electrical conductivity. The water contact angle of the fiber membrane reaches 139.6°, and the conductivity reaches 1972.78 S cm−1.

Notes

Acknowledgements

This study was financially supported by the National Natural Science Foundation of China (21374008).

Compliance with ethical standards

Conflict of interest

The authors declare that they have no conflict of interests.

Supplementary material

10853_2019_4015_MOESM1_ESM.doc (1.7 mb)
Supplementary material 1 (DOC 1736 kb)

References

  1. 1.
    Lim HS, Baek JH, Park K, Shin HS, Kim J, Cho JH (2010) Multifunctional hybrid fabrics with thermally stable superhydrophobicity. Adv Mater 22(19):2138–2141CrossRefGoogle Scholar
  2. 2.
    Feng L, Li SH, Li YS, et al (2002) Super-hydrophobic surfaces: from natural to artificial. Adv Mater 14(24):1856–1860CrossRefGoogle Scholar
  3. 3.
    Xu B, Cai ZS (2008) Fabrication of a superhydrophobic ZnO nanorod array film on cotton fabrics via a wet chemical route and hydrophobic modification. Appl Surf Sci 18(6):5899–5904CrossRefGoogle Scholar
  4. 4.
    Trinh QH, Nguyen DB, Hossain MM, Mok YS (2019) Deposition of superhydrophobic coatings on glass substrates from hexamethyldisiloxane using a kHz-powered plasma jet. Surf Coat Technol 361:377–385CrossRefGoogle Scholar
  5. 5.
    Liu WY, Sun LY, Luo YT (2013) Fabrication of the superhydrophobic surface on aluminum alloy by anodizing and polymeric coating. Appl Surf Sci 264(7):872–878CrossRefGoogle Scholar
  6. 6.
    Greiner A, Wendorff JH (2007) Electrospinning: a fascinating method for the preparation of ultrathin fibres. Angew Chem Int Ed 46(30):5670–5703CrossRefGoogle Scholar
  7. 7.
    Li D, Wang YL, Xia YN (2003) Electrospinning of polymeric and ceramic nanofibers as uniaxially aligned arrays. Nano Lett 3(8):1168–1170CrossRefGoogle Scholar
  8. 8.
    Zhu MM, Xiong RH, Huang CB (2019) Bio-based and photocrosslinked electrospun antibacterial nanofibrous membranes for air filtration. Carbohydr Polym 205:1030–1035CrossRefGoogle Scholar
  9. 9.
    Yin CG, Ma Y, Liu ZJ, Fan JC, Shi PH, Xu QJ, Min YL (2019) Multifunctional boron nitride nanosheet/polymer composite nanofiber membranes. Polymer 162:100–107CrossRefGoogle Scholar
  10. 10.
    Zhang D, Jin XZ, Huang T, Zhang N (2019) Electrospun fibrous membranes with dual-scaled porous structure: super hydrophobicity, super lipophilicity, excellent water adhesion, and anti-icing for highly efficient oil adsorption/separation. ACS Appl Mater Interfaces 11(5):5073–5083CrossRefGoogle Scholar
  11. 11.
    Liao Y, Loh CH, Tian M, Wang R, Fane AG (2018) Progress in electrospun polymeric nanofibrous membranes for water treatment: fabrication, modification and applications. Prog Polym Sci 77:69–94CrossRefGoogle Scholar
  12. 12.
    Bai H, Zhao L, Lu CH, Li C (2009) Composite nanofibers of conducting polymers and hydrophobic insulating polymers: preparation and sensing application. Polymer 50(14):3292–3301CrossRefGoogle Scholar
  13. 13.
    Diaz JE, Barrero A, Marquez M, Loscertales IG (2006) Controlled encapsulation of hydrophobic liquids in hydrophilic polymer nanofibers by co-electrospinning. Adv Funct Mater 16(16):2110–2116CrossRefGoogle Scholar
  14. 14.
    Han DW, Steckl AJ, Andrew J (2009) Superhydrophobic and oleophobic fibers by coaxial electrospinning. Langmuir 25(16):9454–9462CrossRefGoogle Scholar
  15. 15.
    Kim CH, Khil MS, Kim HY, Lee HU, Jahng KY (2006) An improved hydrophilicity via electrospinning for enhanced cell attachment and proliferation. J Biomed Mater Res Part B Appl Biomater 78B(2):283–290CrossRefGoogle Scholar
  16. 16.
    Papadopoulou V, Evgenidis S, Eckersley RJ, et al (2011) Decompression induced bubble dynamics on ex vivo fat and muscle tissue surfaces with a new experimental set up. Colloids Surf B Biointerfaces 129(77):121–129Google Scholar
  17. 17.
    Menini R, Farzaneh M (2008) Production of superhydrophobic polymer fibers with embedded particles using the electrospinning technique. Polym Int 57(1):77–84CrossRefGoogle Scholar
  18. 18.
    Wang D, Li DW, Lv PF, Xu Y, Wei QF (2019) Deposition of polytetrafluoroethylene nanoparticles on graphene oxide/polyester fabrics for oil adsorption. Surf Eng 35(5):426–434CrossRefGoogle Scholar
  19. 19.
    Xu YL, Gao NX, Gong YJ, Huo SS, Mohideen MM, Hong S, Liu Y (2019) Controllable preparation of methyltriethoxysilane xerogel nanofibers. J Mater Sci 54:10130–10140.  https://doi.org/10.1007/s10853-019-03629-y CrossRefGoogle Scholar
  20. 20.
    Xu JQ, Jiao YP, Shao XH, Zhou CR (2011) Controlled dual release of hydrophobic and hydrophilic drugs from electrospun poly (l-lactic acid) fiber mats loaded with chitosan microspheres. Mater Lett 65(17–18):2800–2803CrossRefGoogle Scholar
  21. 21.
    Du A, Wang HQ, Zhou B, et al (2018) Multifunctional silica nanotube aerogels inspired by polar bear hair for light management and thermal insulation. Chem Mater 30(19):6849–6857CrossRefGoogle Scholar
  22. 22.
    Khayet M, Wang R (2018) Mixed matrix polytetrafluoroethylene/polysulfone electrospun nanofibrous membranes for water desalination by membrane distillation. ACS Appl Mater Interfaces 10(28):24275–24287CrossRefGoogle Scholar
  23. 23.
    Eykens L, Sitter D, Dotremont C, Pinoy L, Van der Bruggen B (2016) Characterization and performance evaluation of commercially available hydrophobic membranes for direct contact membrane distillation. Desalination 392(10):63–73CrossRefGoogle Scholar
  24. 24.
    Qing WH, Shi XN, Zhang WD, Wang JQ, Wu YF, Wang P, Tang CYY (2018) Solvent-thermal induced roughening: a novel and versatile method to prepare superhydrophobic membranes. J Membr Sci 564(10):465–472CrossRefGoogle Scholar
  25. 25.
    Kang WM, Zhao HH, Ju JG, Shi ZJ, Qiao CM, Cheng BW (2016) Electrospun poly(tetrafluoroethylene) nanofiber membranes from PTFE-PVA-BA-H2O gel-spinning solutions. Fibers Polym 17(9):1403–1413CrossRefGoogle Scholar
  26. 26.
    Wang KP, Hou DY, Wang J, Wang ZX, Tian BH, Liang P (2018) Hydrophilic surface coating on hydrophobic PTFE membrane for robust anti-oil-fouling membrane distillation. Appl Surf Sci 450:59–63Google Scholar
  27. 27.
    Dastjerdi R, Rouhollahi F, Beigi MH, Nasr-Esfahani MH (2018) Mechanism of formation of soft and elastic nanoflowers; a key major guideline. J Clean Prod 200:331–341CrossRefGoogle Scholar
  28. 28.
    Zong XH, Bien H, Chung CY, et al (2005) Electrospun fine-textured scaffolds for heart tissue constructs. Biomaterials 26(26):5337–5338CrossRefGoogle Scholar
  29. 29.
    Liu ZJ, Wang HY, Wang EQ, Zhang XG, Yuan RX, Zhu YJ (2016) Superhydrophobic poly(vinylidene fluoride) membranes with controllable structure and tunable wettability prepared by one-step electrospinning. Polymer 82:105–113CrossRefGoogle Scholar
  30. 30.
    Jia GB, Plentz J, Dellith J, Dellith A, Wahyuono RA, Andra G (2019) Large area graphene deposition on hydrophobic surfaces, flexible textiles, glass fibers and 3D structures. Coatings 9(3):1–10CrossRefGoogle Scholar

Copyright information

© Springer Science+Business Media, LLC, part of Springer Nature 2019

Authors and Affiliations

  1. 1.College of Mechanical and Electric EngineeringBeijing University of Chemical TechnologyBeijingChina
  2. 2.College of Materials Science and EngineeringBeijing University of Chemical TechnologyBeijingChina
  3. 3.College of Materials Science and EngineeringBeijing Institute of Fashion TechnologyBeijingChina
  4. 4.Nanoscience and Nanotechnology InitiativeNational University of SingaporeSingaporeSingapore

Personalised recommendations