Advertisement

Macroscopic Thermal Rectification Device Using Vanadium Dioxide Thin Film

  • Isae Kim
  • Manil Kang
  • Sok Won KimEmail author
Article
Part of the following topical collections:
  1. Special Issue: Advances in Thermophysical Properties

Abstract

A thermal rectifier is a device in which heat flows in the forward direction but very little can flow in the opposite direction. Because the heat current can be controlled, the device is promising for future practical applications. In this study, the experiments were performed to investigate temperature-gated thermal rectification using macroscopic vanadium dioxide \((\hbox {VO}_{2})\) thin films deposited on an asymmetric substrate. The \(\hbox {VO}_{2}\) phase transition, occurred near 340 K, changed both the electrical and thermal properties. Therefore, we used these properties to investigate the thermal rectification. The \(\hbox {VO}_{2}\) thin films were prepared on cover glass substrates by RF sputtering with a \(\hbox {VO}_{2}\) disk target at \(500~{^{\circ }}\hbox {C}\). The morphology of the thin films was investigated. Silver paste and a copper band were used to connect the films with a heater and temperature controller. We observed thermal rectification in the temperature range of T = 310 K–370 K in several film samples obtained with different degrees of asymmetry, deposition times, and post-annealing times. It is found that \(60{^{\circ }}\) triangular-shaped samples have a rectification coefficient of 1.14, and the rectification coefficient is increased with the increasing of the angle. In addition, the two rectangular-shaped samples have the coefficient of 1.06, which could also be enhanced by increasing the ratio of width.

Keywords

Thermal conductivity Thermal rectification Thin film Vanadium dioxide 

Notes

Acknowledgements

This work was supported by the Priority Research Centers Program through the National Research Foundation of Korea (NRF) with funding from the Ministry of Education (2009-0093818).

References

  1. 1.
    W. Kobayashi, Y. Teraoka, I. Terasaki, J. Electron. Mater. 39, 1488 (2010)ADSCrossRefGoogle Scholar
  2. 2.
    W. Kobayashi, D. Sawaki, T. Omura, T. Katsufuji, Y. Moritomo, I. Terasaki, Appl. Phys. Express 5, 027302 (2012)ADSCrossRefGoogle Scholar
  3. 3.
    J.H. Park, J.M. Cory, T.S. Kasirga, C. Huang, Z. Fei, S. Hunter, D.H. Cobden, Sci. Lett. 500, 12425 (2013)Google Scholar
  4. 4.
    D. Li, A.A. Sharma, D.K. Gala, N. Shukla, H. Paik, S. Datta, D.G. Scholm, J.A. Bain, M. Skowronski, A.C.S. Appl, Mater. Interfaces 8, 12908 (2016)CrossRefGoogle Scholar
  5. 5.
    H. Tian, D. xie, Y. Yang, T.L. ren, G. Zhang, Y.F. Wang, C.J. Zhou, P.G. Peng, L.G. Wang, L.T. Liu, Sci. Rep. 2, 523 (2012)CrossRefGoogle Scholar
  6. 6.
    J. Zhu, K. Hippalgaonkar, S. Shen, K. Wang, Y. Abate, S. Lee, J. Wu, X. Yin, A. Majumdar, X. Zhang, ACS Nano Lett. 14, 4867 (2014)ADSCrossRefGoogle Scholar
  7. 7.
    M. Yang, Y. Yang, B. Hong, L. Wang, K. Hu, Y. Dong, H. xu, H. Huang, J. Zhao, L. song, H. Ju, J. Zhu, J. Bao, X. Li, Y. Gu, T. Yang, X. Gao, Z. Luo, C. Gao, Sci. Rep. 6, 23119 (2016)ADSCrossRefGoogle Scholar
  8. 8.
    I.N. Goncharuk, A.V. Ilinskiy, O.E. Kvashenkina, E.B. Shadrin, Phys. Solid State 55, 164 (2013)ADSCrossRefGoogle Scholar
  9. 9.
    H. Kizuka, T. Yagi, J. Jia, Y. Yamashita, S. Nakamura, N. Taketoshi, Y. Shigesato, Jpn. J. Appl. Phys. 54, 053201 (2015)ADSCrossRefGoogle Scholar
  10. 10.
    M. Kang, W. Oh, I. Kim, S.W. Kim, J.W. Ryu, Y.G. Kim, Curr. Appl. Phys. 12, 1567 (2011)Google Scholar
  11. 11.
    H. Fujiwara, Spectroscopic Ellipsometry (Willey, Hoboken, NJ, 2007)Google Scholar

Copyright information

© Springer Science+Business Media, LLC 2017

Authors and Affiliations

  1. 1.Department of PhysicsUniversity of UlsanUlsanRepublic of Korea

Personalised recommendations