Advertisement

Catalysis Letters

, Volume 149, Issue 1, pp 283–291 | Cite as

Production of 5-Hydroxymethylfurfural from Starch Through an Environmentally-Friendly Synthesis Pathway

  • Agneev Mukherjee
  • Marie-Josée DumontEmail author
  • Alice Cherestes
Article
  • 76 Downloads

Abstract

In this work, an environment-friendly and recyclable system was developed for converting waxy corn starch to HMF, with boric acid and choline chloride acting as co-catalysts, and a biphasic medium of water-MIBK or water-THF used as solvent. A central composite design based Response Surface Methodology was used to optimise the reaction parameters. The highest HMF yield obtained for water-MIBK was 35.9 mol%, while for water-THF, a maximum yield of 60.3 mol% was attained. However, the water-MIBK system was more recyclable, with minimal decrease in HMF yields observed even after ten rounds of reuse. Therefore, this system merits further investigation with other feedstock and on a larger scale.

Graphical Abstract

Keywords

5-Hydroxymethylfurfural Corn starch Biorefinery Hydrothermal conversion 

Notes

Acknowledgements

The financial support of McGill University, the National Science and Engineering Research Council of Canada (NSERC), and the Programme de bourses d’excellence pour étudiants étrangers (PBEEE) scholarship of the Fonds de Recherche du Québec-Nature et technologies (FRQNT) is gratefully acknowledged. We are grateful to Dr. Vijaya Raghavan for permitting the use of his laboratory equipment. We are also immensely thankful to Mr Yvan Gariépy for his support in our work.

Compliance with Ethical Standards

Conflict of interest

The authors declare no conflict of interest.

References

  1. 1.
    Cherubini F (2010) The biorefinery concept: using biomass instead of oil for producing energy and chemicals. Energ Convers Manage 51(7):1412–1421Google Scholar
  2. 2.
    Mukherjee A, Dumont M-J, Review RV (2015) Sustainable production of hydroxymethylfurfural and levulinic acid: challenges and opportunities. Biomass Bioenergy 72:143–183Google Scholar
  3. 3.
    Pagán-Torres YJ, Wang T, Gallo JMR et al (2012) Production of 5-hydroxymethylfurfural from glucose using a combination of Lewis and Brønsted acid catalysts in water in a biphasic reactor with an alkyl phenol solvent. ACS Catal 2(6):930–934Google Scholar
  4. 4.
    Liu F, Audemar M, De Oliveira Vigier K et al. (2013) Selectivity enhancement in the aqueous acid-catalyzed conversion of glucose to 5-hydroxymethylfurfural induced by choline chloride. Green Chem 15(11):3205–3213Google Scholar
  5. 5.
    Zhang Z, Wang Q, Xie H et al (2011) Catalytic conversion of carbohydrates into 5-hydroxymethylfurfural by germanium(IV) chloride in ionic liquids. ChemSusChem 4(1):131–138Google Scholar
  6. 6.
    Hu L, Sun Y, Lin L (2012) Efficient conversion of glucose into 5-hydroxymethylfurfural by chromium(III) chloride in inexpensive ionic liquid. Ind Eng Chem Res 51(3):1099–1104Google Scholar
  7. 7.
    De S, Dutta S, Saha B (2011) Microwave assisted conversion of carbohydrates and biopolymers to 5-hydroxymethylfurfural with aluminium chloride catalyst in water. Green Chem 13(10):2859Google Scholar
  8. 8.
    Roy Goswami S, Dumont M-J, Raghavan V (2016) Microwave assisted synthesis of 5-hydroxymethylfurfural from starch in AlCl3·6H2O/DMSO/[BMIM]Cl system. Ind Eng Chem Res 55(16):4473–4481Google Scholar
  9. 9.
    Tong X, Wang Y, Nie G et al (2015) Selective dehydration of fructose and sucrose to 5-hydroxymethyl-2-furfural with heterogeneous ge(IV) catalysts. Environ Prog Sustain Energy 34(1):207–210Google Scholar
  10. 10.
    Degirmenci V, Hensen EJM (2014) Development of a heterogeneous catalyst for lignocellulosic biomass conversion: glucose dehydration by metal chlorides in a silica-supported ionic liquid layer. Environ Prog Sustain Energy 33(2):657–662Google Scholar
  11. 11.
    Osatiashtiani A, Lee AF, Brown DR et al (2014) Bifunctional SO4/ZrO2 catalysts for 5-hydroxymethylfufural (5-HMF) production from glucose. Catal Sci Technol 4(2):333–342Google Scholar
  12. 12.
    Martínez JJ, Silva DF, Aguilera EX et al (2017) Dehydration of glucose to 5-hydroxymethylfurfural using LaOCl/Nb2O5 catalysts in hot compressed water conditions. Catal Lett 147(7):1765–1774Google Scholar
  13. 13.
    Gromov NV, Taran OP, Semeykina VS et al (2017) Solid acidic NbOx/ZrO2 catalysts for transformation of cellulose to glucose and 5-hydroxymethylfurfural in pure hot water. Catal Lett 147(6):1485–1495Google Scholar
  14. 14.
    Walia M, Sharma U, Agnihotri VK et al (2014) Silica-supported boric acid assisted conversion of mono- and poly-saccharides to 5-hydroxymethylfurfural in ionic liquid. RSC Adv 4(28):14414Google Scholar
  15. 15.
    Stahlberg T, Rodriguez-Rodriguez S, Fristrup P et al (2011) Metal-free dehydration of glucose to 5-(hydroxymethyl)furfural in ionic liquids with boric acid as a promoter. Chem Eur J 17(5):1456–1464Google Scholar
  16. 16.
    Román-Leshkov Y, Dumesic JA (2009) Solvent effects on fructose dehydration to 5-hydroxymethylfurfural in biphasic systems saturated with inorganic salts. Top Catal 52(3):297–303Google Scholar
  17. 17.
    Benoit M, Brissonnet Y, Guelou E et al (2010) Acid-catalyzed dehydration of fructose and inulin with glycerol or glycerol carbonate as renewably sourced co-solvent. ChemSusChem 3(11):1304–1309Google Scholar
  18. 18.
    Hansen TS, Mielby J, Riisager A (2011) Synergy of boric acid and added salts in the catalytic dehydration of hexoses to 5-hydroxymethylfurfural in water. Green Chem 13(1):109Google Scholar
  19. 19.
    McNeff CV, Nowlan DT, McNeff LC et al (2010) Continuous production of 5-hydroxymethylfurfural from simple and complex carbohydrates. Appl Catal A 384(1–2):65–69Google Scholar
  20. 20.
    Tong X, Yu L, Nie G et al (2015) Antimony-meditated efficient conversion of carbohydrates to 5-hydroxymethylfurfural in a simple THF-H2O binary solvent. Environ Prog Sustain Energy 34(4):1136–1141Google Scholar
  21. 21.
    Mukherjee A, Dumont M-J (2016) Influence of the starch structure in the synthesis and the yield of levulinic acid. Starch - Stärke 68:943–952Google Scholar
  22. 22.
    Mukherjee A, Dumont M-J (2016) Levulinic acid production from starch using microwave and oil bath heating: a kinetic modeling approach. Ind Eng Chem Res 55(33):8941–8949Google Scholar
  23. 23.
    Araujo PW, Brereton RG (1996) Experimental design I. Screening. Trends Anal Chem 15(1):26–31Google Scholar
  24. 24.
    AN55 Analytical Methods Committee (2013) Experimental design and optimisation (4) Plackett–Burman designs. Anal Methods 5(8):1901Google Scholar
  25. 25.
    Roy Goswami S, Mukherjee A, Dumont M-J et al (2016) One-pot conversion of corn starch into 5-hydroxymethylfurfural in water-[Bmim]Cl/MIBK biphasic media. Energy Fuel 30(10):8349–8356Google Scholar
  26. 26.
    Liu F, Sivoththaman S, Tan Z (2014) Solvent extraction of 5-HMF from simulated hydrothermal conversion product. Sustain Environ Res 24(2):149–157Google Scholar
  27. 27.
    Blumenthal LC, Jens CM, Ulbrich J et al (2016) Systematic identification of solvents optimal for the extraction of 5-hydroxymethylfurfural from aqueous reactive solutions. ACS Sustain Chem Eng 4(1):228–235Google Scholar
  28. 28.
    Weingarten R, Cho J, Xing R et al (2012) Kinetics and reaction engineering of levulinic acid production from aqueous glucose solutions. ChemSusChem 5(7):1280–1290Google Scholar
  29. 29.
    McKibbins WS (1962) Kinetics of the acid catalyzed conversion of glucose to 5-hydroxymethyl-2-furaldehyde and levulinic acid. Forest Prod J 12:17–23Google Scholar
  30. 30.
    Heimlich KR, Martin AN (1960) A kinetic study of glucose degradation in acid solution. J Am Pharm Assoc 49(9):592–597Google Scholar
  31. 31.
    Baugh KD, McCarty PL (1988) Thermochemical pretreatment of lignocellulose to enhance methane fermentation: I. Monosaccharide and furfurals hydrothermal decomposition and product formation rates. Biotechnol Bioeng 31(1):50–61Google Scholar
  32. 32.
    Paiva A, Craveiro R, Aroso I et al (2014) Natural deep eutectic solvents—solvents for the 21st century. ACS Sustain Chem Eng 2(5):1063–1071Google Scholar
  33. 33.
    Shekaari H, Zafarani-Moattar MT, Shayanfar A et al (2018) Effect of choline chloride/ethylene glycol or glycerol as deep eutectic solvents on the solubility and thermodynamic properties of acetaminophen. J Mol Liq 249:1222–1235Google Scholar
  34. 34.
    Azizi N, Dezfooli S, Khajeh M et al (2013) Efficient deep eutectic solvents catalyzed synthesis of pyran and benzopyran derivatives. J Mol Liq 186:76–80Google Scholar
  35. 35.
    Wu Z, Huang RR, Yu H et al (2017) Deep eutectic solvent synthesis of LiMnPO(4)/C nanorods as a cathode material for lithium ion batteries. Materials 10(2):134Google Scholar
  36. 36.
    Wagle DV, Deakyne CA, Baker GA (2016) Quantum chemical insight into the interactions and thermodynamics present in choline chloride based deep eutectic solvents. J Phys Chem B 120(27):6739–6746Google Scholar
  37. 37.
    Hiltunen J, Kuutti L, Rovio S et al (2016) Using a low melting solvent mixture to extract value from wood biomass. Sci Rep 6:32420Google Scholar
  38. 38.
    Locas CP, Yaylayan VA (2008) Isotope labeling studies on the formation of 5-(Hydroxymethyl)-2-furaldehyde (HMF) from sucrose by pyrolysis-GC/MS. J Agric Food Chem 56(15):6717–6723Google Scholar
  39. 39.
    Qian X (2012) Mechanisms and energetics for Brønsted acid-catalyzed glucose condensation, dehydration and isomerization reactions. Top Catal 55(3–4):218–226Google Scholar
  40. 40.
    Binder JB, Cefali AV, Blank JJ et al (2010) Mechanistic insights on the conversion of sugars into 5-hydroxymethylfurfural. Energy Environ Sci 3(6):765Google Scholar
  41. 41.
    Noma R, Nakajima K, Kamata K et al (2015) Formation of 5-(hydroxymethyl)furfural by stepwise dehydration over TiO2 with water-tolerant lewis acid sites. J Phys Chem C 119(30):17117–17125Google Scholar
  42. 42.
    Amiri H, Karimi K, Roodpeyma S (2010) Production of furans from rice straw by single-phase and biphasic systems. Carbohydr Res 345(15):2133–2138Google Scholar

Copyright information

© Springer Science+Business Media, LLC, part of Springer Nature 2018

Authors and Affiliations

  • Agneev Mukherjee
    • 1
  • Marie-Josée Dumont
    • 1
    Email author
  • Alice Cherestes
    • 1
  1. 1.Bioresource Engineering DepartmentMcGill UniversitySte-Anne-de-BellevueCanada

Personalised recommendations