Advertisement

Flow, Turbulence and Combustion

, Volume 102, Issue 2, pp 435–455 | Cite as

Effect of the Reynolds Number on the Performance of a NACA0012 Wing with Leading Edge Protuberance at Low Reynolds Numbers

  • Takahiro YasudaEmail author
  • Keita Fukui
  • Keiji Matsuo
  • Hisato Minagawa
  • Ryo Kurimoto
Article
  • 213 Downloads

Abstract

A study on the improvement of the NACA0012 wing performance in the low Reynolds number (Re) region of 10,000 ≤ Re ≤ 60,000 using a leading edge protuberance (LEP) was conducted. In this study, we focused on the effects of varying Re on the effectivity of the LEP. Wind tunnel tests and numerical simulations were performed to measure the wing performance and to visualize the flow structures around the airfoil. In the higher angle of attack region of α > 10, LEP causes the lift to increase independently of Re. Furthermore, in the lower angle of attack region, i.e., α ≤ 10, with Re ≤ 20,000, the lift coefficient also increases when using the LEP. The separation control is caused by the streamwise vortices generated by LEP which provides the momentum from the freestream flow into the separation region near the valley section, and the mechanism was basically the same at all Reynolds numbers and angle of attacks used in this study.

Keywords

Passive separation control Leading edge protuberance NACA0012 airfoil Low Reynolds number 

Notes

Compliance with Ethical Standards

Conflict of interests

The authors declare that they have no conflict of interest.

References

  1. 1.
    Oyama, A., Fujii, K.: A study on airfoil design for future Mars airplane. AIAA paper, pp. 2006–1484 (2006)Google Scholar
  2. 2.
    Jung, J., Yee, K., Misaka, T., Jeong, S.: low Reynolds number airfoil design for a mars exploration airplane using a transition model. Trans. Japan Soc. Aeronaut. Space Sci. 60–6, 183–299 (2017)Google Scholar
  3. 3.
    Fish, F.E., Battle, J.M.: Hydrodynamic design of the humpback whale flipper. J. Morphol. 225, 51–60 (1995)CrossRefGoogle Scholar
  4. 4.
    Miklosovic, D.S., Murray, M.M., Howle, L.E., Fish, F.E.: Leading-edge tubercles delay stall on humpback whale (Megaptera Novaeangliae) flippers. Phys. Fluids 16–5, L39–L42 (2004)CrossRefzbMATHGoogle Scholar
  5. 5.
    Johari, H., Henoch, C.W., Custodio, D., Levshin, A.: Effects of leading-edge protuberances on airfoil performance. AIAA J. 45–11, 2634–2642 (2007)CrossRefGoogle Scholar
  6. 6.
    Arai, H., Doi, Y., Nakashima, T., Mutsuda, H., Miyoshi, J.: Experimental investigation of stall delay by wavy leading edges of 3-dimensional wing. J. Japan Soc. Naval Arch. Ocean Eng. 9, 55–62 (2009). in JapaneseGoogle Scholar
  7. 7.
    Hansen, K., Kelso, R.M., Dally, B.B.: Performance variations of leading-edge tubercles for distinct airfoil profiles. AIAA J. 49–1, 185–194 (2011)CrossRefGoogle Scholar
  8. 8.
    Dropkin, A., Custodio, D., Henoch, C.W., Johari, H.: Computation of flowfield around an airfoil with leading-edge protuberances. J. Aircraft 49–5, 1345–1355 (2012)CrossRefGoogle Scholar
  9. 9.
    Malipeddi, A.K., Mahmoudnejad, N., Klaus, A., Hoffmann, K.A.: Numerical analysis of effects of leading-edge protuberances on aircraft wing performance. J. Aircr. 49–5, 1336–1344 (2012)CrossRefGoogle Scholar
  10. 10.
    Skillen, A., Revell, A., Favier, J., Pinelli, A., Piomelli, U.: Investigation of wing stall delay effect due to an undulating leading edge: An LES study. In: Proceedings of International Symposium on Turbulence and Shear Flow Phenomena, CON4E (2013)Google Scholar
  11. 11.
    Cai, C., Zuo, Z.G., Liu, S.H., Wu, Y.L., Wang, F.B.: Numerical investigations of hydrodynamic performance of hydrofoils with leading-edge protuberances. Adv. Mech. Eng. 7–7, 1–11 (2015)Google Scholar
  12. 12.
    Miklosovic, D.S., Murray, M.M., Howle, L.E.: Experimental evaluation of sinusoidal leading edges. J. Aircr. 44–4, 1404–1408 (2007)CrossRefGoogle Scholar
  13. 13.
    Pedro, H.T.C., Kobayashi, M.H.: Numerical study of stall delay on humpback whale flippers. In: 46th AIAA Aerospace Science Meeting and Exhibit, pp. 1–8 (2008)Google Scholar
  14. 14.
    Chen, J.H., Li, S.S., Nguyen, V.T.: The effect of leading edge protuberance on the performance of small aspect ratio foils. In: 15th International Symposium of Flow Visualization ISFV15-040-S21 (2012)Google Scholar
  15. 15.
    Abrantes, T.T.D., Cruz, A.A.R., De Paula, A.A., Kleine, V.G., Büttner, F.: The wing three-dimensional effects on wavy leading edge performance. AIAA paper, pp. 2017–4467 (2017)Google Scholar
  16. 16.
    Cai, C., Zuo, Z.G., Liu, S.H., Wu, Y.L., Wang, F.B.: Numerical evaluations of the effect of leading-edge protuberances on the static and dynamic stall characteristics of an airfoil. IOP Conf. Series: Mater. Sci. Eng. 52–5, 1–8 (2013)Google Scholar
  17. 17.
    Hansen, K., Kelso, R.M., Doolan, C.: Reduction of flow induced airfoil tonal noise using leading edge sinusoidal modifications. Acoust. Australia 40–3, 172–177 (2012)Google Scholar
  18. 18.
    Guerreiro, J.L.E., Sousa, J.M.M.: Low-Reynolds-number effect in passive stall control using sinusoidal leading edges. AIAA J. 50–2, 461–469 (2012)CrossRefGoogle Scholar
  19. 19.
    Ohtake, T., Nakae, Y., Motohashi, T.: Nonlinearity of the aerodynamic characteristics of NACA0012 aerofoil at low Reynolds numbers. J. Japan Soc. Aeronaut. Space Sci. 55-644, 439–445 (2007)Google Scholar
  20. 20.
    De Paula, A.A., Mattos B.S., Padilha, B.R., Meneghini, J.: The airfoil thickness effect on wavy leading edge performance. AIAA Paper, pp. 2016–1306 (2016)Google Scholar
  21. 21.
    Favier, J., Pinelli, A., Piomelli, U.: Control of the separated flow around an airfoil using a wavy leading edge inspired by humpback whale flippers. Comptes Rendus Mecanique 340, 107–114 (2012)CrossRefGoogle Scholar
  22. 22.
    Serson, D., Meneghini, J.R., Sherwin, S.J.: Direct numerical simulations of the flow around wings with spanwise waviness at a very low Reynolds number. Comput. Fluids 46, 117–124 (2017)MathSciNetCrossRefzbMATHGoogle Scholar
  23. 23.
    Nicoud, F., Ducros, F.: Subgrid-scale stress modelling based on the square of the velocity gradient tensor. Turb. Combust. 62, 183–299 (1999)CrossRefzbMATHGoogle Scholar

Copyright information

© Springer Nature B.V. 2018

Authors and Affiliations

  • Takahiro Yasuda
    • 1
    Email author
  • Keita Fukui
    • 2
  • Keiji Matsuo
    • 2
  • Hisato Minagawa
    • 1
  • Ryo Kurimoto
    • 1
  1. 1.School of EngineeringThe University of Shiga PrefectureShigaJapan
  2. 2.Graduate School of EngineeringThe University of Shiga PrefectureShigaJapan

Personalised recommendations