Advertisement

Evaluating the deterioration effects of building stones using NDT: the Küçükköy Church, Cappadocia Region, central Turkey

  • M. Ergün HatırEmail author
  • Mustafa Korkanç
  • M. Emin Başar
Original Paper

Abstract

Many churches have been constructed during the last two millennia in the Cappadocia region of Central Anatolia. Among these buildings, the Küçükköy Church, constructed in 1834, is distinguishable from other churches by its icons and distinctive roof. However, this monument is in a state of rapid deterioration due to its derelict status, local atmospheric conditions, and the geological characteristics of the stones used in the structure. It is therefore important to determine deterioration status and the amount of deterioration of each building stone to facilitate the sustainable preservation of this monument. In recent years, non-destructive tests (NDT) have been commonly used to evaluate the detrioration status of such historic buildings. In the study reported here, we conducted laboratory studies on stone samples and performed in situ NDT (P-wave velocity test, Schmidt hammer rebound [SHR] test, and surface moisture measurement test) to determine the deterioration status of building stones used in the Küçükköy Church. The lithological characteristics of building stones are known to be the most important parameters in the deterioration process. We found that the deterioration effects were most advanced in those building stones which had properties similar to one type of andesite, as demonstrated by high voids and low P-wave velocity and SHR values. The benefits of NDT is that they are repeatable and that reliable results are obtained rapidly and economically.

Keywords

Building stone Cappadocia region Deterioration Küçükköy Church Nigde Non-destructive tests 

Notes

Acknowledgements

This study was supported by the Research Fund of Selçuk University under Project 2015-ÖYP-047.

References

  1. Abbaneo S, Berra M, Binda L, Fatticcioni A (1995) A non destructive evaluation of brick–masonry structures: calibration of sonic wave propagation procedures. In: Proc Int Symp of Non Destructive Testing in Civil Engineering (NDT-CE). Deutsche Gesellschaft für Zerstörungsfreie Prüfung, Berlin, p 253–260Google Scholar
  2. Açıkgöz F, Demir F, Eryaman M, Tektaş M (2009) Niğde Kültür Envanteri (1). Tekten Basın Yayın Ltd. Şti, NiğdeGoogle Scholar
  3. Akin M, Özsan A (2011) Evaluation of the long-term durability of yellow travertine using accelerated weathering tests. Bull Eng Geol Environ 70:101–114.  https://doi.org/10.1007/s10064-010-0287-x CrossRefGoogle Scholar
  4. Anzani A, Binda L, Carpinteri A, Invernizzi S, Lacidogna G (2010) A multilevel approach for the damage assessment of historic masonry towers. J Cult Herit 11:459–470.  https://doi.org/10.1016/j.culher.2009.11.008 CrossRefGoogle Scholar
  5. Aoki H, Matsukura Y (2007) A new technique for non-destructive field measurement of rocksurface strength: an application of the Equotip hardness tester to weathering studies. Earth Surf Process Landf 32:1759–1769.  https://doi.org/10.1002/esp.1492 CrossRefGoogle Scholar
  6. ASTM International (2014) D5873 standard test method for determination of rock hardness by rebound hammer method. ASTM International, West ConshohockenGoogle Scholar
  7. Atabey E, Göncüoğlu MC, Turhan N (1990) 1/100.000 ölçekli açınsama nitelikli Türkiye jeoloji haritaları serisi KOZAN-J 19 paftası. MTA Genel Müdürlüğü, AnkaraGoogle Scholar
  8. Aydin A, Basu A (2005) The Schmidt hammer in rock material characterization. Eng Geol 81:1–14.  https://doi.org/10.1016/j.enggeo.2005.06.006 CrossRefGoogle Scholar
  9. Batum I (1978) Nevsehir guney batisindaki Gollu Dag ve Acigol volkanitlerinin jeokimyasi ve petrolojisi. [Geochemistry and petrology of Gollu Mountain and Acigol Volcanics of southwest Nevsehir.]. J Earth Sci 4:70–88Google Scholar
  10. Beekman P (1966) The Pliocene and Quaternary volcanism in the Hasan Dağ-Melendiz Dağ region Maden Tetkik ve Arama Genel Müdürlüğü Bülteni 66:99–106Google Scholar
  11. Binda L (1997) A role of riles committee: calibration of proposed test methods. In: Binda L, Modena C (eds) Evaluation and Strengthening of Existing Masonry Structures, 1st edn. RILEM Publications, Padua, pp 1–24Google Scholar
  12. Bortz S, Stecich J, Wonneberger B, Chin I (1993) Accelerated weathering in building stone. Int J Rock Mech Min Sci Geomech Abstr 30:1559–1562.  https://doi.org/10.1016/0148-9062(93)90156-8 CrossRefGoogle Scholar
  13. Buj O, Gisbert J, Franco B, Mateos N, Bauluz B (2010) Decay of the Campanile limestone used as building material in Tudela Cathedral (Navarra, Spain). Geol Soc Spec Publ 331:195–202.  https://doi.org/10.1144/sp331.17 CrossRefGoogle Scholar
  14. Casula G, Fais S, Ligas P, Mora P (2007) Experimental application of 3-d terrestrial laser scanning and acoustic techniques in assessing the quality of stones used in monumental structures. In: I.N. Prassianakis (ed), Proc 4th international conference on NDT. Crete, p 118–122Google Scholar
  15. Charola AE (2000) Salts in the deterioration of porous materials: An overview. J Am Inst Conserv 39:327–343.  https://doi.org/10.1179/019713600806113176 CrossRefGoogle Scholar
  16. Christaras B (1997) Estimation of damage at the surface of stones using non destructive techniques. WIT Trans Built Environ 26:121–128Google Scholar
  17. Christaras B, Auger F, Mosse E (1994) Determination of the moduli of elasticity of rocks. Comparison of the ultrasonic velocity and mechanical resonance frequency methods with direct static methods. Mater Struct 27:222–228.  https://doi.org/10.1007/bf02473036 CrossRefGoogle Scholar
  18. Christaras B, Cuccuru F, Fais S, Papanikolaou H (2015) Application of non destructive ultrasonic techniques for the analysis of the conservation status of building materials in monumental structures. Eng Geol Soc Territ 8:139–143Google Scholar
  19. Çobanoğlu İ, Çelik SB (2008) Estimation of uniaxial compressive strength from point load strength. Schmidt hardness and P-wave velocity. Bull Eng Geol Environ 67:491–498CrossRefGoogle Scholar
  20. Cuccuru F, Fais S, Ligas P (2014) Dynamic elastic characterization of carbonate rocks used as building materials in the historical city centre of Cagliari (Italy). Q J Eng Geol Hydrogeol 47:259–266.  https://doi.org/10.1144/qjegh2013-061 CrossRefGoogle Scholar
  21. Cultrone G, Luque A, Sebastián E (2012) Petrophysical and durability tests on sedimentary stones to evaluate their quality as building materials. Q J Eng Geol Hydrogeol 45:415–422.  https://doi.org/10.1144/qjegh2012-007 CrossRefGoogle Scholar
  22. De Beer J (1967) Subjective classification of the hardness of rocks and the associated shear strength. In: Proc 4th Reg Cong African Soil Mechanical Found Engineering. Capctawn, p 396–398Google Scholar
  23. Ekiz M (2015) Niğde ili ve ilçeleri arkeolojik yüzey araştırması raporu. T.C. Kültür ve Turizm Bakanlığı, 57 sayfa. http://www.ttk.gov.tr/wp-content/uploads/2016/11/7-Nigde.pdf. Accessed 12 Jan 2018
  24. El-Gohary M (2012) The contrivance of new mud bricks for restoring and preserving the Edfa Ancıent Granary-Sohag. Egypt Int J Conserv Sci 3:67–78Google Scholar
  25. El-Gohary MA (2017) Environmental impacts: Weathering factors, mechanism and forms affected the stone decaying in Petra. J Afr Earth Sci 135:204–212.  https://doi.org/10.1016/j.jafrearsci.2017.08.020 CrossRefGoogle Scholar
  26. Esaki T, Jiang K (2000) Comprehensive study of the weathered condition of welded tuff from a historic stone bridge in Kagoshima, Japan. Eng Geol 55:121–130.  https://doi.org/10.1016/S0013-7952(99)00112-X CrossRefGoogle Scholar
  27. Fais S, Casula G (2010) Application of acoustic techniques in the evaluation of heterogeneous building materials. NDT E Int 43:62–69.  https://doi.org/10.1016/j.ndteint.2009.10.004 CrossRefGoogle Scholar
  28. Fais S, Tocco R, Casula G (1999) ND acoustic techniques to assess the preservation of a church colonnade-a case history. In: 61st EAGE Conf and Exhibition. Helsinki, p 1–2Google Scholar
  29. Fais S, Ligas P, Palomba M, Tocco R (2002) Evaluation of preservation state of monumental buildings by ND acoustic techniques and mineralogical studies. In: Proc 5th Int Symp, Conservation of Monuments in the Mediterranean Basin; Protection and Conservation of the Cultural Heritage of the Mediterranean Cities. Seville, p 307–314Google Scholar
  30. Fener M, İnce İ (2015) Effects of the freeze–thaw (F–T) cycle on the andesitic rocks (Sille-Konya/Turkey) used in construction building. J Afr Earth Sci 109:96–106.  https://doi.org/10.1016/j.jafrearsci.2015.05.006 CrossRefGoogle Scholar
  31. Fookes PG, Dearman WR, Franklin JA (1971) Some engineering aspects of rock weathering with field examples from Dartmoor and elsewhere. Q J Eng Geol Hydrogeol 4:139–185CrossRefGoogle Scholar
  32. Fort R, Alvarez de Buergo M, Perez-Monserrat EM (2013) Non-destructive testing for the assessment of granite decay in heritage structures compared to quarry stone. Int J Rock Mech Min Sci 61:296–305.  https://doi.org/10.1016/j.ijrmms.2012.12.048 CrossRefGoogle Scholar
  33. Franzoni E, Bandini S, Graziani G (2014) Rising moisture, salts and electrokinetic effects in ancient masonries: From laboratory testing to on-site monitoring. J Cult Herit 15:112–120.  https://doi.org/10.1016/j.culher.2013.03.003 CrossRefGoogle Scholar
  34. Gökçe MV, İnce İ, Fener M, Taşkıran T, Kayabali K (2016) The effects of freeze–thaw (F–T) cycles on the Gödene travertine used in historical structures in Konya (Turkey). Cold Reg Sci Technol 127:65–75.  https://doi.org/10.1016/j.coldregions.2016.04.005 CrossRefGoogle Scholar
  35. Gokceoglu C, Zorlu K, Ceryan S, Nefeslioglu HA (2009) A comparative study on indirect determination of degree of weathering of granites from some physical and strength parameters by two soft computing techniques. Mater Charact 60:1317–1327.  https://doi.org/10.1016/j.matchar.2009.06.006 CrossRefGoogle Scholar
  36. Grinzato E, Marinetti S, Bison PG, Concas M, Fais S (2004) Comparison of ultrasonic velocity and IR thermography for the characterisation of stones. Infrared Phys Technol 46:63–68.  https://doi.org/10.1016/j.infrared.2004.03.009 CrossRefGoogle Scholar
  37. International Society for Rock Mechanics (ISRM) (1981) Suggested methods for determining hardness and abrasiveness of rocks. In: Brown ET (ed) Rock characterization, testing and monitoring: ISRM suggested Methods. Pergamon, Oxford, pp 95–96Google Scholar
  38. ISRM (2007) The complete ISRM suggested methods for rock characterization, testing and monitoring: 1974–2006. ISRM Turkish National Group, AnkaraGoogle Scholar
  39. Jo YH, Lee CH (2014) Quantitative modeling and mapping of blistering zone of the Magoksa Temple stone pagoda (13th century, Republic of Korea) by graduated heating thermography. Infrared Phys Tech 5:43–50.  https://doi.org/10.1016/j.infrared.2014.02.011 CrossRefGoogle Scholar
  40. Kahraman S (2001) Evaluation of simple methods for assessing the uniaxial compressive strength of rock. Int J Rock Mech Min Sci 38:981–994CrossRefGoogle Scholar
  41. Koca MY, Kıncal C (2004) Abandoned stone quarries in and around the Izmir city centre and their geo-environmental impacts-Turkey. Eng Geol 75(1):49–67CrossRefGoogle Scholar
  42. Kocaman M (2016) Niğde'nin geç Dönem Osmanlı kiliseleri. Selçuk Üniversitesi Sosyal Bilimler Enstitüsü Yüksek Lisans Tezi, Konya, 535 sayfaGoogle Scholar
  43. Korkanç M (2013) Deterioration of different stones used in historical buildings within Nigde province. Constr Build Mater 48:789–803CrossRefGoogle Scholar
  44. Korkanç M, Savran A (2015) Impact of the surface roughness of stones used in historical buildings on biodeterioration. Constr Build Mater 80:279–294.  https://doi.org/10.1016/j.conbuildmat.2015.01.073 CrossRefGoogle Scholar
  45. Korkanç M, Tuğrul A (2004) Evaluation of selected basalts from Niğde, Turkey, as source of concrete aggregate. Eng Geol 75:291–307.  https://doi.org/10.1016/j.enggeo.2004.06.015 CrossRefGoogle Scholar
  46. Korkanç M, İnce İ, Hatır ME, Tosunlar MB (2018) Historical Granaries at Taşkale (Turkey) Under Risk: A Geotechnical Analysis. MAA 18(1):149–162Google Scholar
  47. Laurie JB, Robertson RHS, Vicente MA (1986) The restoration of buildings constructed with Menorcan limestone. Q J Eng Geol Hydrogeol 19:283–289.  https://doi.org/10.1144/gsl.qjeg.1986.019.03.05 CrossRefGoogle Scholar
  48. Lim MK, Cao H (2013) Combining multiple NDT methods to improve testing effectiveness. Constr Build Mater 38:1310–1315.  https://doi.org/10.1016/j.conbuildmat.2011.01.011 CrossRefGoogle Scholar
  49. López-Doncel R, Wedekind W, Dohrmann R, Siegesmund S (2013) Moisture expansion associated to secondary porosity: an example of the Loseros Tuff of Guanajuato, Mexico. Environ Earth Sci 69:1189–1201.  https://doi.org/10.1007/s12665-012-1781-1 CrossRefGoogle Scholar
  50. Lourenço PB, Luso E, Almeida MG (2006) Defects and moisture problems in buildings from historical city centres: a case study in Portugal. Build Environ 41:223–234.  https://doi.org/10.1016/j.buildenv.2005.01.001 CrossRefGoogle Scholar
  51. Meteoroloji Genel Müdürlüğü (MGM) (2018) Meteoroloji Genel Müdürlüğü. https://www.mgm.gov.tr/veridegerlendirme/il-ve-ilceler-istatistik.aspx?m=NIGDE. Accessed 13 Jan 2018
  52. Norwegian Group for Rock Mechanics (NBG) (1985) Engineering geology and rock engineering. Handbook No. 2. Norwegian Group for Rock Mechanics, OsloGoogle Scholar
  53. Nicholson DT (2002) Quantification of rock breakdown for experimental weathering studies. In: Understanding and managing stone decay: Proc Int Conf Stone Weathering and Atmospheric Pollution Network (SWAPNET 2001). Karolinum Press, Prague, pp 59–74Google Scholar
  54. Öcal T (2013) Niğde Gümüşler Manastırı ve turizim potansiyeli. Fırat Üniversitesi Sosyal Bilimler Dergisi 23(2):31–49Google Scholar
  55. Orhan M, Isik NS, Topal T, Ozer M (2006) Effect of weathering on the geomechanical properties of andesite, Ankara, Turkey. Environ Geol 50(1):85–100CrossRefGoogle Scholar
  56. Özçelik Y (2011) Determination of the regions used as facing and building stone according to the material characteristics in an andesite quarry. Eng Geol 118(3–4):104–109CrossRefGoogle Scholar
  57. Özden UA, Topal T (2009) Evaluation of andesite source as armourstone for a rubble mound breakwater (Hisarönü, Turkey). Environ Earth Sci 59:39–49CrossRefGoogle Scholar
  58. Özşen H, Bozdağ A, İnce İ (2017) Effect of salt crystallization on weathering of pyroclastic rocks from Cappadocia, Turkey. Arab J Geosci 10:258.  https://doi.org/10.1007/s12517-017-3027-8 CrossRefGoogle Scholar
  59. Özvan A, Dinçer İ, Acar A (2011) Quality Assessment of Geo-Materials for Coastal Structures (Yumurtalık, Turkey). Mar Georesour Geotechnol 294:299–316CrossRefGoogle Scholar
  60. Papida S, Murphy W, May E (2000) Enhancement of physical weathering of building stones by microbial populations. Int Biodeterior Biodegrad 46:305–317.  https://doi.org/10.1016/S0964-8305(00)00102-5 CrossRefGoogle Scholar
  61. Přikryl R, Smith BJ (2007) Building stone decay: from diagnosis to conservation. Geological Society of London, LondonGoogle Scholar
  62. Raymahashay BC, Sharma S (1993) Decay of building stones: a mineralogical model for Konark Sun Temple, India. Q J Eng Geol Hydrogeol 26:155–157.  https://doi.org/10.1144/gsl.qjeg.1993.026.02.07 CrossRefGoogle Scholar
  63. Rirsch E, Zhang Z (2010) Rising damp in masonry walls and the importance of mortar properties. Constr Build Mater 24:1815–1820.  https://doi.org/10.1016/j.conbuildmat.2010.04.024 CrossRefGoogle Scholar
  64. Rivera-Gomez C, Galàn-Marin C (2013) In situ assessment of structural timber elements of a historic building by moisture content analyses and ultrasonic velocity tests. Int J Hous Sci 37:33–42Google Scholar
  65. Sandrolini F, Franzoni E (2007) Repair systems for the restoration of ancient buildings—dampness rise problem. Restoration of Buildings and Monuments 13:161–172Google Scholar
  66. Siedel H, Siegesmund S (2014) Characterization of stone deterioration on buildings. In: Siegesmund S, Snethlage R (eds) Stone in architecture: properties, durability. Springer, Berlin, Heidelberg, pp 349–414.  https://doi.org/10.1007/978-3-642-45155-3_6 CrossRefGoogle Scholar
  67. Snethlage R (2005) Leitfaden Steinkonservierung. Fraunhofer IRB, StuttgartGoogle Scholar
  68. Stück H, Siegesmund S, Rüdrich J (2011) Weathering behaviour and construction suitability of dimension stones from the Drei Gleichen area (Thuringia, Germany). Environ Earth Sci 63:1763–1786.  https://doi.org/10.1007/s12665-011-1043-7 CrossRefGoogle Scholar
  69. Török Á (2010) In situ methods of testing stone monuments and the application of nondestructive physical properties testing in masonry diagnosis. In: Dan MB, Přikryl R, Török Á (eds) Materials, technologies and practice in historic heritage structures. Springer, Dordrecht, pp 177–193CrossRefGoogle Scholar
  70. Török Á, Přikryl R (2010) Current methods and future trends in testing, durability analyses and provenance studies of natural stones used in historical monuments. Eng Geol 115:139–142.  https://doi.org/10.1016/j.enggeo.2010.07.003 CrossRefGoogle Scholar
  71. TS EN 1925 (2000) Natural stone test methods determination of water absorption coefficient by capillarity. Turkish Standards Institution, AnkaraGoogle Scholar
  72. Turkington AV, Paradise TR (2005) Sandstone weathering: a century of research and innovation. Geomorphology 67:229–253.  https://doi.org/10.1016/j.geomorph.2004.09.028 CrossRefGoogle Scholar
  73. Vařilová Z, Přikryl R, Cílek V (2011) Pravčice Rock Arch (Bohemian Switzerland National Park, Czech Republic) deterioration due to natural and anthropogenic weathering. Environ Earth Sci 63:1861–1878.  https://doi.org/10.1007/s12665-010-0881-z CrossRefGoogle Scholar
  74. Vasconcelos G, Lourenço PB, Alves C, Pamplona J (2007) Prediction of the mechanical properties of granites by ultrasonic pulse velocity and Schmidt hammer hardness. In: Proc 10th North American Masonry Conference. Missouri, p 998–1009Google Scholar
  75. Wedekind W, Ruedrich J, Siegesmund S (2011) Natural building stones of Mexico–Tenochtitlán: their use, weathering and rock properties at the Templo Mayor, Palace Heras Soto and the Metropolitan Cathedral. Environ Earth Sci 63:1787–1798.  https://doi.org/10.1007/s12665-011-1075-z CrossRefGoogle Scholar
  76. Yasar E, Erdogan Y (2004) Correlating sound velocity with the density, compressive strength and Young's modulus of carbonate rocks. Int J Rock Mech Min Sci 41:871–875CrossRefGoogle Scholar
  77. Yavuz H (2011) Effect of freeze-thaw and thermal shock weathering on the physical and mechanical properties of an andesite stone. Bull Eng Geol Environ 70:187–192CrossRefGoogle Scholar
  78. Yavuz H, Altindag R, Sarac S, Ugur I, Sengun N (2006) Estimating the index properties of deteriorated carbonate rocks due to freeze–thaw and thermal shock weathering. Int J Rock Mech Min Sci 43:767–775.  https://doi.org/10.1016/j.ijrmms.2005.12.004 CrossRefGoogle Scholar
  79. Yavuz AB, Kaputoglu SA, Çolak M, Tanyu BF (2017) Durability assessments of rare green andesites widely used as building stones in Buca (Izmir), Turkey. Environ Earth Sci 76:211CrossRefGoogle Scholar
  80. Zedef V, Koçak K, Döyen A, Özşen H, Kekeç B (2007) Effect of salt crystallization on stones of historical buildings and monuments, Konya, Central Turkey. Build Environ 42:1453–1457CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2018

Authors and Affiliations

  • M. Ergün Hatır
    • 1
    Email author
  • Mustafa Korkanç
    • 2
  • M. Emin Başar
    • 1
  1. 1.Department of Architecture, Faculty of ArchitectureSelçuk UniversityKonyaTurkey
  2. 2.Department of Geology, Faculty of EngineeringNiğde Ömer Halisdemir UniversityNiğdeTurkey

Personalised recommendations