Abstract
An electric field was applied across a deionized water droplet placed on a multi-walled carbon nanotube (MWCNT) membrane. Droplets of different size were tested by varying the voltage applied from 3 to 25 V during the electrowetting process. After electrowetting, it was observed that the topography of the membrane deformed from vertical alignment to a grouped pattern due to bubbles appearing during the electrowetting process, indicating the occurrence of electrolysis. For the droplet size ranging from 2 to 3.5 μl, the contact angle (CA) for smaller droplets reduced more dramatically than for larger droplets at the same voltage, and the contact angle saturation condition also varied in response to the droplet size. To reveal the droplet size effect, the Young-Lippmann equation is modified to simulate CA reduction on a MWCNT membrane.
Similar content being viewed by others
References
Daiguji H, Yang P, Majumdar A (2004) Ion transport in nanofluidic channels. Nano Lett 4:137–142. doi:10.1021/nl0348185
Karnik R, Fan R, Yue M, Li D, Yang P, Majumdar A (2005) Electrostatic control of ions and molecules in nanofluidic transistors. Nano Lett 5:943–948. doi:10.1021/nl050493b
Feng L, Li S, Li Y, Li H, Zhang L, Zhai J, Song Y, Liu B, Jiang L, Zhu D (2002) Super-hydrophobic surfaces: from natural to artificial. Adv Mater 14:1857–1860. doi:10.1002/adma.200290020
Prins MWJ, Welters WJJ, Weekamp JW (2001) Fluid control in multichannel structures by electrocapillary pressure. Science 291:277–280. doi:10.1126/science.291.5502.277
Kakade BA, Pillai VK (2008) Tuning the wetting properties of multiwalled carbon nanotubes by surface functionalization. J Phys Chem C 112:3183–3186. doi:10.1021/jp711657f
Zou L, Ma N, Sun M, Ji T (2014) Two kinds of composite films: graphene oxide/carbon nanotube film and graphene oxide/activated carbon film via a self-assemble preparation process. Solid State Sci 37:91–95. doi:10.1016/j.solidstatesciences.2014.08.012
Tie L, Guo Z, Liu W (2015) PH-manipulated underwater–oil adhesion wettability behavior on the micro/nanoscale semicircular structure and related thermodynamic analysis. ACS Appl Mater Interfaces 7:10641–10649. doi:10.1021/acsami.5b03533
Tie L, Guo Z, Li W (2014) Optimal design of superhydrophobic surfaces using a paraboloid microtexture. J Colloid Interface Sci 436:19–28. doi:10.1016/j.jcis.2014.09.009
Wang Z, Ci L, Chen L, Nayak S, Ajayan PM, Koratkar N (2007) Polarity-dependent electrochemically controlled transport of water through carbon nanotube membranes. Nano Lett 7:697–702. doi:10.1021/nl062853g
Guo Z, Su B (2011) Electricity-driven wettability with a low threshold voltage. Appl Phys Lett 99:082106–082108. doi:10.1063/1.3628457
Wang HZ, Huang ZP, Cai QJ, Kulkarni K, Chen CL, Carnahan D, Ren ZF (2010) Reversible transformation of hydrophobicity and hydrophilicity of aligned carbon nanotube arrays and buckypapers by dry processes. Carbon 48:868–875. doi:10.1016/j.carbon.2009.10.041
Mo Y, Yan D, Huang F (2014) Mechanical and wettability properties of chemically modified surface texture with carbon nanotubes. Appl Phys A 114:1387–1392. doi:10.1007/s00339-013-8015-6
Li J, Ling J, Yan L, Wang Q, Zha F, Lei Z (2014) UV/mask irradiation and heat induced switching on-off water transportation on superhydrophobic carbon nanotube surfaces. Surf Coat Technol 258:142–145. doi:10.1016/j.surfcoat.2014.09.040
Li P, Lim X, Zhu Y, Yu T, Ong CK, Shen Z, Wee ATS, Sow CH (2007) Tailoring wettability change on aligned and patterned carbon nanotube films for selective assembly. J Phys Chem B 111:1672–1678. doi:10.1021/jp066781t
Sun T, Liu H, Song W, Wang X, Jiang L, Li L, Zhu D (2004) Responsive aligned carbon nanotubes. Angew Chem Int Ed 43:4663–4666. doi:10.1002/anie.200460774
Roy S, Bhadra M, Mitra S (2014) Enhanced desalination via functionalized carbon nanotube immobilized membrane in direct contact membrane distillation. Sep Purif Technol 136:58–65. doi:10.1016/j.seppur.2014.08.009
Wu X, Xu H, Xu P, Shen Y, Lu L, Shi J, Fu J, Zhao H (2014) Microwave-treated graphite felt as the positive electrode for all-vanadium redox flow battery. J Power Sources 263:104–109. doi:10.1016/j.jpowsour.2014.04.035
Saranya R, Arthanareeswaran G, Dionysiou DD (2014) Treatment of paper mill effluent using Polyethersulfone/functionalized multiwalled carbon nanotubes based nanocomposite membranes. Chem Eng J 236:369–377. doi:10.1016/j.cej.2013.09.096
Zanin H, Saito E, Ceragioli HJ, Baranauskas V, Corat EJ (2014) Reduced graphene oxide and vertically aligned carbon nanotubes superhydrophilic films for supercapacitors devices. Mater Res Bull 49:487–493. doi:10.1016/j.materresbull.2013.09.033
Yang J, Zhang Z, Men X, Xu X, Zhu X (2011) Thermo-responsive surface wettability on a pristine carbon nanotube film. Carbon 49:19–23. doi:10.1016/j.carbon.2010.08.033
Hanumansetty S, O’Rear E, Resasco DE (2015) Hydrophilic encapsulation of multi-walled carbon nanotubes using admicellar polymerization. Colloids Surf A 474:1–8. doi:10.1016/j.colsurfa.2015.02.047
Rouhollah S, Sorina H, Mohsen A (2015) Advances in the biomedical application of polymer-functionalized carbon nanotubes. Biomater Sci 3:695–711. doi:10.1039/c4bm00421c
Pu J, Wan SW, Lu Z, Zhang G, Wang L, Zhang X, Xue Q (2013) Controlled water adhesion and electrowetting of conducting hydrophobic graphene/carbon nanotubes composite films on engineering materials. J Mater Chem A1:1254–1260. doi:10.1039/c2ta00344a
Kakade B, Mehta R, Durge A, Kulkarni S, Pillai V (2008) Electric field induced, superhydrophobic to superhydrophilic switching in multiwalled carbon nanotube papers. Nano Lett 8:2693–2696. doi:10.1021/nl801012r
Tan X, Zhou Z, Cheng MMC (2012) Electrowetting on dielectric experiments using graphene. Nanotechnology 23:375501–375508. doi:10.1088/0957-4484/23/37/375501
Chakrapani N, Wei B, Carrillo A, Ajayan PM, Kane RS (2004) Capillarity-driven assembly of two-dimensional cellular carbon nanotube foams. Proc Natl Acad Sci USA 101:4009–4012. doi:10.1073/pnas.0400734101
Bertossi R, Caney N, Gruss JA, Dijon J, Fournier A, Marty P (2015) Influence of carbon nanotubes on deionized water pool boiling performances. Exp Therm Fluid Sci 61:187–193. doi:10.1016/j.expthermflusci.2014.10.028
Aoki KJ, Li C, Nishiumi T, Chen J (2013) Electrolysis of pure water in a thin layer cell. J Electroanal Chem 695:24–29. doi:10.1016/j.jelechem.2013.02.020
Ma H (2015) Oscillating heat pipes. Springer, New York
Acknowledgements
This research was supported by Fundamental Research Funds for the Central Universities (No. 3132015033), Scientific Study Project for Institutes of Higher Learning, Ministry of Education, Liaoning Province (No. L2014195), and the National Natural Science Foundation of China (No. 51376027).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Cui, W., Ma, H., Tian, B. et al. Electrowetting on a multi-walled carbon nanotube membrane with different droplet sizes in an electric field. J Mater Sci 51, 4031–4036 (2016). https://doi.org/10.1007/s10853-016-9721-1
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10853-016-9721-1